Changing The Brake Fluid; Checking And Lubricating The Cables; Checking And Lubricating The Throttle Grip And Cable - Yamaha XVS1100 Owner's Manual

Changing the brake fluid

Have a Yamaha dealer change the
brake fluid at the intervals specified in
the periodic maintenance and lubrica-
tion chart. In addition, have the oil seals
of the brake master cylinders and cali-
pers as well as the brake hoses re-
placed at the intervals listed below or
whenever they are damaged or leak-
ing.
Oil seals: Replace every two
years.
Brake hoses: Replace every four
years.
PERIODIC MAINTENANCE AND MINOR REPAIR
EAU00742
Checking and lubricating the
cables
The operation of all control cables and
the condition of the cables should be
checked before each ride, and the ca-
bles and cable ends should be lubricat-
ed if necessary. If a cable is damaged
or does not move smoothly, have a
Yamaha dealer check or replace it.
Recommended lubricant:
Engine oil
WARNING
@
Damage to the outer sheath may in-
terfere with proper cable operation
and will cause the inner cable to
rust. Replace a damaged cable as
soon as possible to prevent unsafe
conditions.
@
EAU02962
Checking and lubricating the
throttle grip and cable
The operation of the throttle grip and
the condition of the throttle cable
should be checked before each ride,
and the cable should be lubricated or
replaced if necessary.
NOTE:
@
Since the throttle grip must be removed
to access the throttle cable end, the
throttle grip and the cable should al-
ways be lubricated at the same time.
@
EW000112
1. Remove the throttle grip by remov-
2. Disconnect the throttle cable, hold
3. Connect the throttle cable, and
6-22
ing the screws.
it up, and then apply several drops
of oil to the cable end, allowing it to
trickle into the sheath.
then grease the inside of the throt-
tle grip housing.
EAU03197
6