Checking The Stand; Checking The Switches; Checking The Front And Rear Suspension - APRILIA SCARABEO 500 - 2003 Manual

2
1

CHECKING THE STAND

R e a d p a g e 4 3 ( M A I N T E N A N C E )
carefully.
WARNING
FOR THE SIDE STAND ONLY
Caution: the vehicle might fall or tip
over.
NOTE
The following instructions apply
to both stands.
The stand (1) must rotate freely.
Check for the following:
◆
The springs (2) must not be damaged,
worn, oxidised or weakened.
◆
The stand must rotate freely. Grease the
j o i n t i f n e e d e d , s e e p a g e 7 7
(LUBRICANT CHART).
use and maintenance Scarabeo 500 ABS
54
2
1

CHECKING THE SWITCHES

The vehicle is fitted with two switches:
√ Brake light switch on the rear brake lever
(integral braking system).
√ Brake light switch on the front brake lever.
If you need assistance or technical advice,
contact your aprilia Official Dealer for
guaranteed quality service.
CHECKING THE FRONT AND REAR
SUSPENSION
R e a d p a g e 4 3 ( M A I N T E N A N C E )
carefully.
CAUTION
Have front suspension oil changed at
an aprilia Official Dealer for accurate,
prompt service.
Have the front suspension oil changed
every 30000 km (18750 miles) or every 4
years.
Perform the following checks after the first
1000 km (625 miles) and every 6000 km
(3750 miles) afterwards:
◆
Keep the front brake lever squeezed in
and press down repeatedly on the
handlebar to compress the front fork.
◆
The front fork should compress in a
smooth motion. Inspect the fork legs for
any traces of oil.
◆
Ensure that all parts are properly
tightened and check the articulated joints
of the rear and front suspension for
proper operation.
CAUTION
In the event of malfunction or if the
suspension needs expert servicing,
contact an aprilia Official Dealer.