Hybrid grill, infrared, gas & charcoal cooking system (49 pages)
Summary of Contents for Member's Mark PRO G62304
Page 1
PRO SERIES 5-BURNER GAS GRILL Assembly Instructions & User Manual Model G62304 STOP Do not return this product to the store. If you need help or require parts, call the Customer Care Hotline: 1-833-454-0864 This manual must remain with the product at all times. FOR OUTDOOR USE ONLY.
Page 2
IMPORTANT SAFETY WARNINGS THIS MANUAL MUST REMAIN WITH THIS PRODUCT AT ALL TIMES CAUTION DANGER Read and follow all safety statements, 1. If you smell gas: assembly instructions, use and care directions a. Shut off gas to the appliance. before attempting to assemble and cook. b.
MODEL G62304 TABLE OF CONTENT INSTALLATION / ADDITIONAL WARNINGS LP GAS CYLINDER HOOK-UPS AND WARNINGS SAFETY HOSE AND REGULATOR: Installing LP gas cylinder Regulator reset procedure Leak test procedure LIGHTING INSTRUCTIONS START GRILLING PREVENTION MAINTENANCE STORING YOUR GRILL TROUBLESHOOTING ASSEMBLY INSTRUCTIONS WARRANTY AND SERVICE DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
MODEL G62304 INSTALLATION Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
MODEL G62304 LP GAS CYLINDER REQUIREMENTS DO NOT connect to a LP gas cylinder exceeding 9 kg (20 lb) capacity or use a cylinder with any other type of cylinder valve connection device. LP gas supply cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders of the U.S.Department ofTransportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders Spheres and Tubes for the Transportation of Dangerous Goods.
MODEL G62304 LP GAS CYLINDER RUBBER SEAL INSPECTION LP GAS WARNINGS: • Inspect LP gas cylinder valve rubber seal for cracks, wear or deterioration prior to use. A damaged rubber seal can cause a gas leak, possibly resulting in an explosion, fire or severe bodily harm.
Page 7
MODEL G62304 INSTALLING THE LP GAS CYLINDER HOSE AND REGULATOR Your grill is equipped with a Type 1 connection device with the following features: The system will not allow gas flow from cylinder until a positive connection to valve has been made. NOTE: The cylinder valve and all control knobs must be turned “OFF”...
MODEL G62304 REGULATOR RESET PROCEDURE If you are experiencing any of the following performance issues, you may have activated the flow limiting feature in your regulator: • Burners not getting hot enough. • Low or incomplete burner flames. Flow Limiting Device Video •...
MODEL G62304 LEAK TEST PROCEDURE WHEN TO PERFORM A LEAK TEST: • After assembling your grill and before lighting for the first time, even if purchased fully assembled. • Every time LP gas cylinder is refilled, exchanged or if any of the gas components are disconnected or replaced. •...
Page 10
MODEL G62304 LP CYLINDER REMOVAL, TRANSPORT AND STORAGE BEFORE DISCONNECTING THE LP CYLINDER: Turn “OFF” all control knobs and the LP gas cylinder valve. 2. Turn coupling nut counter-clockwise by hand only - do not use tools to disconnect. Remove LP gas cylinder from inside cabinet.
MODEL G62304 LIGHTING INSTRUCTIONS LIGHTING THE MAIN BURNERS: BBQ MODE All burners will function in BBQ Mode. The thermostatic control knob must be set to BBQ. Open the lid before attempting to light the burners. 2. Make sure all control knobs and the LP gas cylinder shut-off valve are “OFF.” Lighting Instruction Video Scan this QR code.
Page 12
MODEL G62304 LIGHTING INSTRUCTIONS LIGHTING THE MAIN BURNERS: THERMOSTATIC CONTROL Open the lid before attempting to light the burners. 2. Make sure all control knobs and the LP gas cylinder shut-off valve are “OFF.” 3. SLOWLY turn the LP gas cylinder shut-off valve counter-clockwise to open. Wait 30 seconds for the pressure to stabilize. 4.
Page 13
MODEL G62304 LIGHTING INSTRUCTIONS WHEN SWITCHING FROM THERMOSTATIC CONTROL TO BBQ MODE ATTENTION Burner #2 and burner #4 include a thermocouple and safety shut-off valve that will restrict the use of both burners when the thermostatic control knob has been turned on. Push in and turn the thermostatic control knob, clockwise to BBQ mode.
Page 14
MODEL G62304 LIGHTING INSTRUCTIONS LIGHTING THE SIDE BURNER/SEAR BURNER (IF APPLICABLE) Open lid before lighting side burner. 2. Make sure control knob is “OFF”. 3. With LP gas cylinder open, push and turn control knob to “HI”. Press igniter for 3-5 seconds.
Page 15
MODEL G62304 LIGHTING INSTRUCTIONS USING THE SIDE BURNERS • The side burner can be used to prepare side dishes such as beans, potatoes, corn, or to warm sauces. • The burner valve can be adjusted from high to low depending upon your cooking demands. WARNING •...
MODEL G62304 START GRILLING WARNING: Read and follow all warnings and instructions contained in the preceding sections of this manual. • DO NOT cover cooking grates or other components with aluminum foil, as this blocks ventilation and damage to grill or result in personal injury.
Page 17
MODEL G62304 START GRILLING TIPS FOR TEMPERATURE MAINTENANCE AND COOKING TIMES When using the Thermostatic Control system, the temperatures inside the grill are constantly monitored and burner flames adjusted to maintain set temperature. However, to maintain stable cooking temperatures and retain heat inside your grill, do the following: 1.
Page 18
MODEL G62304 START GRILLING GRILL COOKING TIPS: WARNING TO ENSURE THAT IT IS SAFE TO EAT, FOOD MUST BE COOKED TO THE MINIMUM INTERNAL TEMPERATURES LISTED IN THE TABLE BELOW. USDA SAFE MINIMUM INTERNAL TEMPERATURES Fish 145° F (63° C) Pork 160°...
MODEL G62304 PREVENTION CONTROLLING FLARE-UPS/GREASE FIRES: • Flare-ups are a common occurrence when cooking meats on a gas grill. Use caution when opening lid, as sudden flare-ups may occur. Excessive flare-ups can overcook your food and create a dangerous situation for you and your grill. Excessive flare-ups result from the build-up of grease in your grill.
Page 20
MODEL G62304 PREVENTION BLOCKED BURNER VENTURI Blockages in the burner venturi caused by spiders, insects or nests can cause a FLASHBACK FIRE. A flashback fire occurs when a blockage in the venturi tubes caused by spiders, insects and nests blocks the flow of gas, forcing it back towards the control panel and control knob.
MODEL G62304 MAINTENANCE PROPER CARE & MAINTENANCE ATTENTION: If you are experiencing any of the following performance or safety issues: 1) grill not reaching temperature potential, 2) yellow burner flames, 3) the smell gas, 4) popping noises, 5) delayed burner ignition, 6) uneven heat, 7) flash fires, or 8) grease fires, TURN OFF YOUR GRILL immediately and perform the following maintenance regime.
MODEL G62304 MAINTENANCE CLEANING THE BURNERS Keeping burners free of blockages including spiders, insects, nests and other debris that can block the burner ports is essential for safe operation. 1. Use a clean grill brush to clean the outside of the burner. 2.
Page 23
MODEL G62304 MAINTENANCE CLEANING THE EXTERIOR PAINTED, PORCELAIN ENAMEL SURFACES (IF APPLICABLE) 1. Clean painted and porcelain-coated surfaces with warm soapy water. 2. After wiping down all surfaces, rinse thoroughly with water. 3. Dry with a soft microfiber cloth. DO NOT USE ANY CHEMICAL CLEANERS ON PAINTED SURFACES AS THEY COULD STRIP THE PAINT AND PERMANENTLY DAMAGE THE SURFACE, LEAVING IT UNPROTECTED.
MODEL G62304 TROUBLE SHOOTING RESOLVING IGNITION ISSUES, QUICK CHECK: Press the ignition button located on the left shelf fascia (see image A). You should hear a continuous clicking sound when the button is pressed. If you hear no sound, 1) replace the battery (see image B), 2) check that all wires are firmly pushed in (see image C).
Page 25
MODEL G62304 TROUBLE SHOOTING PROBLEM IDENTIFYING THE CAUSE: Flow limiting device in regulator has been activated, either due to a leak or improper lighting. You must conduct a leak test (page 9) and reset the regulator (page 8). Low or out of propane. Flame blows out on LOW High wind condition.
Page 26
WARNING: H OT S U R FAC E S WARNING: EXTERIOR SURFACES WILL BECOME VERY HOT. TO PREVENT BURNS, ALWAYS WEAR INSULATED PROTECTIVE GRILL MITTS WHEN WORKING AT THE GRILL. • KEEP AWAY FROM COMBUSTIBLE MATERIALS. • KEEP CHILDREN AND PETS AWAY FROM THIS GAS-FIRED GRILL. •...
MODEL G62304 ASSEMBLY INSTRUCTIONS HARDWARE PACK Description Picture 1/4"-20UNC x18 Screw 1/4"-20UNC x 13 Screw NO.10-24UNC x13 Screw NO.8-32UNC X10 Screw ST4.8X10 Tapping Screw NO.5-40 X 10 Screw ST4.2X20 Tapping Screw Bezel, Knob Knob AA Battery Caster Pin Spacer, Door Handle ST4.2X10 Tapping Screw 5 Washer Connector...
Page 29
MODEL G62304 ASSEMBLY INSTRUCTIONS EXPLODED DIAGRAM HARD- WARE B19 B17 ASSEMBLY MANUAL 1-833-454-0864...
Page 30
MODEL G62304 ASSEMBLY INSTRUCTIONS Description Part No. Description Part No. TOP LID G623-7200-C1 INFRARED SEAR BURNER G623-1600-C1 TOP LID HANDLE G623-0011-C1 ELECTRODE, INFRARED SEAR BURNER G623-0027-C1 TEMPERATURE GAUGE G623-0064-C1 INFRARED SEAR BURNER VALVE BRACKET G614-0073-C1 TEMPERATURE GAUGE BEZEL G532-0006-C1 GREASE TRAY, INFRARED SEAR BURNER G614-0075-C1 TOP LID HARDWARE G545-0025-C1...
Page 31
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 32
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 33
MODEL G62304 ASSEMBLY INSTRUCTIONS Back view ASSEMBLY MANUAL 1-833-454-0864...
Page 34
MODEL G62304 ASSEMBLY INSTRUCTIONS ATTENTION: Use of a tarp is recommended to avoid damage to parts. ATTENTION: The wire sleeve should remain in place and only the twist tie be removed. Remove the twist tie! Remove the wrap! Remove the twist tie! Remove the wrap! ASSEMBLY MANUAL 1-833-454-0864...
Page 35
MODEL G62304 ASSEMBLY INSTRUCTIONS Back view Front view ASSEMBLY MANUAL 1-833-454-0864...
Page 36
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 37
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 38
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 39
MODEL G62304 ASSEMBLY INSTRUCTIONS Tighten the screws ASSEMBLY MANUAL 1-833-454-0864...
Page 40
MODEL G62304 ASSEMBLY INSTRUCTIONS Tighten the screws ASSEMBLY MANUAL 1-833-454-0864...
Page 41
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 42
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 43
MODEL G62304 ASSEMBLY INSTRUCTIONS Tighten the screws ASSEMBLY MANUAL 1-833-454-0864...
Page 44
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 45
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 46
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 47
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 48
MODEL G62304 ASSEMBLY INSTRUCTIONS Large - 2 C13 Small - 4 NOTE: Push in Firmly. ASSEMBLY MANUAL 1-833-454-0864...
Page 49
MODEL G62304 ASSEMBLY INSTRUCTIONS ASSEMBLY MANUAL 1-833-454-0864...
Page 50
MODEL G62304 ASSEMBLY INSTRUCTIONS PERFORM A LEAK TEST. Proceed to page 9, for instructions Leaking Test Video Scan this QR code. ASSEMBLY MANUAL 1-833-454-0864...
MODEL G62304 ASSEMBLY INSTRUCTIONS WARRANTY AND SERVICE This product is covered by the Sam's Club Member Satisfaction Guarantee. Please visit samsclub.com for more information. BEFORE YOU CALL FOR SERVICE, have the following information available: 1. Serial Number: The serial number is located on the front of this manual and on the rating label located inside your grill cart. 2.
Page 52
MODEL G62304 ASSEMBLY INSTRUCTIONS WARRANTY AND SERVICE LIMITATION AND EXCLUSIONS Winners Products has the following limitations to its warranty: 1. This limited warranty is non-transferable and becomes void if used for commercial or rental purposes. Which includes (but not limited to): Restaurants, hotels, resorts, time shares or rental properties.
Page 53
MODEL G62304 ASSEMBLY INSTRUCTIONS NOTE ASSEMBLY MANUAL 1-833-454-0864...
Page 54
MODEL G62304 ASSEMBLY INSTRUCTIONS NOTE ASSEMBLY MANUAL 1-833-454-0864...
Page 55
MODEL G62304 ASSEMBLY INSTRUCTIONS NOTE ASSEMBLY MANUAL 1-833-454-0864...
Page 56
Distributed by Sam’s West lnc. QUESTIONS OR COMMENTS? We would love to hear about your Member's 2101 SE Simple Savings Dr.Bentonville, Mark experience! Visit us at: Arkansas 72716-0745 samsclub.com/membersmarkhelp Made In China linktr.ee/member's.mark Winners Products Engineering Ltd 27/F, Cofco Tower, 262 Gloucester Road, CONTACT US: 1-833-454-0864 Causeway Bay, Hong Kong...
Need help?
Do you have a question about the PRO G62304 and is the answer not in the manual?
Questions and answers