Lp Cylinder Removal, Transport And Storage; Lp Cylinder Filling - Coleman REVOLUTION RV-601BBQ-3-KIT Manual

DANGER
• NEVER store a spare LP cylinder, empty or full, under or near the
appliance.
• Never fill a cylinder beyond 80% full.
• An over filled or improperly stored cylinder is a hazard due to
possible gas release from the safety relief valve. This could cause
an intense fire or explosion with risk of property damage, serious
injury or death.
• Do not store objects or materials inside the grill cart enclosure
that would block the flow of combustion air to the underside of
either the control panel or the burner box.
• If you see, smell or hear gas escaping, immediately get away from the LP cylinder/appliance and call
your fire department.
LP GAS WARNINGS:
• Always turn cylinder valve off when the grill is not in use.
• Always handle the tank valve with the utmost care.
• Never connect an unregulated LP gas cylinder to the grill.
• Always keep the cylinder, in use, securely fastened in an upright position.
• Never expose the cylinder to direct sunlight or excessive heat.
• Never insert any kind of object into the valve outlet as this may cause damage to the Backcheck.
A damaged Backcheck can leak resulting in fires, explosions, property damage, severe injuries or death.
• Do not store an LP cylinder in enclosed spaces such as a carport, garage, porch, covered patio or other
building. Make sure the storage area has a lot of ventilation.
• Do not store an LP cylinder in an area where children play.
L.P . CYLINDER REMOVAL, TRANSPORT AND STORAGE
Before disconnecting the LP cylinder:
1. Turn "OFF" all control knobs and the LP cylinder valve.
2. Turn coupling nut counterclockwise by hand only - do not use tools to disconnect. Remove LP Cylinder
from inside cart.
3. Install safety cap onto LP cylinder valve. Always use cap supplied with tank valve.
• Failure to use safety cap as directed may result in serious personal injury and/or property damage.
WARNING
When transporting and storing the cylinder, make sure it is in an upright position and not on its
side. Do not smoke around cylinder, especially when transporting in a vehicle.
L.P . CYLINDER FILLING
• Use only licensed and experienced dealers.
• Ensure that the dealer checks and tests the tank for leaks after filling.
• LP dealer must purge new cylinder before filling.
• Dealer should NEVER fill LP cylinder more than 80% of LP cylinder volume. Volume of propane in cylinder
will vary by temperature.
• Do not release liquid propane (LP) gas into the atmosphere. This is a hazardous practice.
• To remove gas from LP cylinder, contact an LP dealer or call a local fire department for assistance.
WARNING
If the above instructions are not completely adhered to, it could cause a fire/explosion, resulting
in death or serious Injury, or property damage.
CAUTION
A frosty regulator indicates gas overfill. Immediately close LP cylinder valve and call local LP gas
dealer for assistance.
3