Engine Shut-Off Cord (Lanyard); Oil; Engine; Install Cowling - Yamaha E60H Owner's Manual

Operation
turns smoothly and that it completely re-
turns to the fully closed position.
Look for loose or damaged connections of

the throttle and shift cables.
Remote control models:
Turn the steering wheel full-right and full-

left. Make sure operation is smooth and
unrestricted throughout the whole range
with no binding or excessive free play.
Operate the throttle levers several times to

make sure there is no hesitation in their
travel. Operation should be smooth over
the complete range of motion, and each le-
ver should return completely to the idle po-
sition.
Look for loose or damaged connections of

the throttle and shift cables.
EMU36484

Engine shut-off cord (lanyard)

Inspect the engine shut-off cord and clip for
damage, such as cuts, breaks, and wear.
1. Clip
2. Engine shut-off cord (lanyard)
EMU27121

Oil

Check to be sure you have plenty of oil for

your trip.
34
1
2
ZMU06873
EMU27142

Engine

Check the engine and engine mounting.

Look for loose or damaged fasteners.

Check the propeller for damage.

EMU36965

Install cowling

(1) Be sure that all cowling lock levers are
released.
(2) Be sure that the rubber seal is seated all
the way around the top cowling.
(3) Place the top cowling on the bottom
cowling.
(4) Check to be sure the rubber seal is seat-
ed correctly between the top cowling
and the bottom cowling.
(5) Move the cowling lock levers to lock the
top cowling as shown. NOTICE: If the
top cowling is not installed correctly,
water spray under the top cowling
can damage the engine, or the top
cowling can blow off at high speeds.
[ECM01992]
After installing, check the fitting of the top
cowling by pushing it with both hands. If the
top cowling is loose, have it repaired by your
Yamaha dealer.
ZMU06118