Summary of Contents for DAAN Groups Voltz Toys DG-80850
Page 1
Toys Customer Service can assist you with any replacement parts, damages, or defective issues reported. You can contact us directly at www.voltztoys.ca. A subdivision of The DAAN Groups Email: help@voltztoys.ca Phone number: 1-888-338-6589 Head Office: Unit 7-3600A Laird Rd, Mississauga, ON, L5L...
Page 2
Please read the manual before using the product. The manual and carton contain important information. Please keep the manual for later references. Failure to follow the instructions in the manual may result in damages, acci- dents, or defective issues with the product. To improve the product and quality, we may alter the structure, appearance, packing method, assembly method, and product function without any no- tice.
PRODUCT SPECIFICATIONS Car Model DG-80850 Battery & Motor 24V7AH+2*240W motors Suitable age 37-95 months Weight Limit 50 kg Product Size 140 x 92 x 74 cm Speed 6-8 km / hour Charging time 8-12 hours AC 110V/220V (input) Charger DC 24V1000mA / 28.8V800mA (output) Fuse Auto-reset fuse ASSEMBLY PREPARATION...
1. MOTORS ASSEMBLY Parts required: N/A Start the installation by flip the car to up-side-down position. Slide the motors to corresponding matching side. Make sure the motor and cables is inserted to the car body opening for both sides. 2. WHEEL ASSEMBLY Parts required: #7, #8, #9 Install the wheels in the following order, from inner end to outer: wheel, tire sleeve, washer.
3. POWER CONNECTION Parts required: N/A Flip the car back to normal orientation. Connect the motor cable from each side. 4. ROLL BAR ASSEMBLY Parts required: #5 Align the roll bar with corresponding opening, press firmly until it clicks.
5. SEAT ASSEMBLY Parts required: #6 Place the seat to corresponding location as shown in the diagram. Lock the position by turning the socket screw to lock position. 6. STEERING WHEEL ASSEMBLY Parts required: #4 Connect the steering wheel cable with corresponding socket from the car unit.
7. WINDSHIELD ASSEMBLY Parts required: #2, #15 Align the windshield with the car opening. Press firmly and secure the con- nection with screws. 8. AIR SCOOP ASSEMBLY Parts required: #14, #15 Attache the air scoop against the unit at designated location. Secure the connection by putting 2 screws from inside the car body to the scoop.
9. HOOD ASSEMBLY Parts required: #3 Slide buckle from each side into the car body from the right angle position. Align the pillars from the hood along with the corresponding opening on the car. 10. SIDE MIRROR ASSEMBLY Parts required: #10 Place the corresponding side mirror, align the mirror with opening, press it firmly for both sides.
Page 10
DASHBOARD 1. Mp3 player 4. Gear switch 2. Horn and music button 5. Motor switch 3. Power switch 6. Mode switch MP3 PLAYER 1. USB port 5. Mode (Radio/Bluetooth/SD card/USB) 2. SD card slot 6. Education (Long press to volume down) 3.
REMOTE CONTROL INSTRUCTION NOTE: This product does not included the AAA(1.5v) 2.4GHz Remote Control Pairing Procedures This remote is equipped with a memory function to retain it’s connection with your car. When replacing the batteries, you do not need to re-pair the remote.
FUSE This car is equipped with an auto-reset fuse. If the car stops suddenly while driving, it is caused by the instantaneous current exceeding, enabling the fuse to trip. This will result in the car disabling for about 8 seconds, and this fuse can be reset.
Page 13
10. To maintain product life and safety, avoid damaging the charger, battery, or electrical circuit. The car must use the default configuration of the dedicated charger and power supply. 11. Rechargeable batteries should be removed from the toy before charging. 12.
CHARGING PROCEDURES • For safety purposes, charging must be done by adults. • When initially assembled, connect the (red) battery wires under the hood. Charge for 8-12 hours before using. • The charging port is located on the dashboard. Follow the instructions to charge the battery.
Page 15
WARNING 1. The assembly of the car must be done by an adult. When unassembled, it contains potentially hazardous parts that are sharp or small. Please keep out of children’s reach. 2. Choking hazards of small parts. 3. Not for children under 36 months. Recommended for 37-95 months. 4.
MAINTENANCE AND SERVICE 1. Before using, adults are responsible for reviewing the product and es- sential parts are in a functional condition. Check whether screws are loose or other potential hazards. Any damaged or defective parts must be repaired or resolved before using. 2.
14. Low batteries should be removed from the car and kept away from chil- dren. 15. Disconnect the batteries when completely inactive or discontinued. Do not let children use the car in this state. TROUBLESHOOTING...