Summary of Contents for DAAN Groups Voltz Toys DG-80570
Page 1
Toys Customer Service can assist you with any replacement parts, damages, or defective issues reported. You can contact us directly at www.voltztoys.ca. A subdivision of The DAAN Groups Email: help@voltztoys.ca Phone number: 1-888-338-6589 Head Office: Unit 7-3600A Laird Rd, Mississauga, ON, L5L...
Page 2
Please read the manual before using the product. The manual and carton contain important information. Please keep the manual for later references. Failure to follow the instructions in the manual may result in damages, acci- dents, or defective issues with the product. To improve the product and quality, we may alter the structure, appearance, packing method, assembly method, and product function without any no- tice.
PRODUCT SPECIFICATIONS Car Model DG-80570 Battery 12V7AH/12V10AH Suitable age 37-95 months Weight Limit 35 kg Product Size 142 x 74 x 48 cm Speed 3-5 km / hour Electric motor Charging time 8-12 hours Charger AC 220V/110V (input) DC 12V1000mA (output) ASSEMBLY PREPARATION •...
1. MOTOR ASSEMBLY Parts required: #9 Disconnect the motors in the car. Slide the motor through the back axle and connect the cable. Place excess cable in the car body. 2. WHEEL ASSEMBLY Parts required: #5, #7, #13 Insert the sleeve into the car wheels. Slide the wheels into the axle. Secure the connection with washer/cotter pins.
3. STEERING WHEELASSEMBLY Parts required: #4 Conncet steering wheel cable with corresponding connector on the car. Slide as much cable as possible through the opening to avoid damage. Insert steering column through the centre opening of the steering wheel, align the opening on steering wheel and the steering column. Insert the screw and secure the connection with nut on the other end.
4. POWER CONNECTION Parts required: N/A Open the front hood cover. Twist the 2 connection pins on engine cover then remove it. Connect the power cable. After testing the connection, place the engine cover, lock it then close the front hood cover. 5.
Page 9
6. SIDE MIRROR ASSEMBLY Parts required: #8 Place the corresponding side mirror, align the mirror with opening, press it firmly for both sides. 7. REAR WINDSHIELD ASSEMBLY Parts required: #10 Align the rear windshield with opening, press it firmly.
Page 10
DASHBOARD 1. Mp3 player 3. Gear switch 2. Power switch MP3 PLAYER 1. USB port 5. Mode (Radio/Bluetooth/SD card/USB) 2. SD card slot 6. Education (Long press to volume down) 3. AUX port 7. Story (Play/Pause) 4. LCD display 8. Music (Long press to volume up)
REMOTE CONTROL INSTRUCTION Stop Speed Forward Right Backward Left Frequency NOTE: This product does not included the AAA(1.5v) 2.4GHz Remote Control Pairing Procedures This remote is equipped with a memory function to retain it’s connection with your car. When replacing the batteries, you do not need to re-pair the remote.
FUSE This car is equipped with an auto-reset fuse. If the car stops suddenly while driving, it is caused by the instantaneous current exceeding, enabling the fuse to trip. This will result in the car disabling for about 8 seconds, and this fuse can be reset.
Page 13
10. To maintain product life and safety, avoid damaging the charger, battery, or electrical circuit. The car must use the default configuration of the dedicated charger and power supply. 11. Rechargeable batteries should be removed from the toy before charging. 12.
CHARGING PROCEDURES • For safety purposes, charging must be done by adults. • When initially assembled, connect the (red) battery wires under the hood. Charge for 8-12 hours before using. • The charging port is located on the dashboard. Follow the instructions to charge the battery.
Page 15
WARNING 1. The assembly of the car must be done by an adult. When unassembled, it contains potentially hazardous parts that are sharp or small. Please keep out of children’s reach. 2. Choking hazards of small parts. 3. Not for children under 36 months. Recommended for 37-95 months. 4.
MAINTENANCE AND SERVICE 1. Before using, adults are responsible for reviewing the product and es- sential parts are in a functional condition. Check whether screws are loose or other potential hazards. Any damaged or defective parts must be repaired or resolved before using. 2.
14. Low batteries should be removed from the car and kept away from chil- dren. 15. Disconnect the batteries when completely inactive or discontinued. Do not let children use the car in this state. TROUBLESHOOTING...