Harman P61-C Owner's Manual

Harman P61-C Owner's Manual

Freestanding pellet stove
Hide thumbs Also See for P61-C:

Advertisement

INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your local dealer with questions on installation, operation or service.
NOTICE: SAVE THESE INSTRUCTIONS
Model(s):
P43-C, P61-C & P68-C
Freestanding Pellet Stove
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and
national codes and regulations.
• Contact local building or fire officials about restrictions
and installation inspection requirements in your area.
To obtain a French translation of this manual, please
contact your dealer or visit www.harmanstoves.com
Pour obtenir une traduction française de ce manuel, s'il
vous plaît contacter votre revendeur ou visitez www.
harmanstoves.com
1
Owner's Manual
Care and Operation
CAUTION
NOTE
Harman® • P-Series Owner's Manual_R15 • 2018 - ___ • 01/22
Please read this entire manual before
installation and use of this pellet fuel-
burning room heater.
Failure to follow these instructions could
result in property damage, bodily injury
or even death.
• Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
• Do not overfire - If any external part starts to glow, you
are overfiring. Reduce feed rate. Overfiring will void
your warranty.
• Comply with all minimum clearances to combustibles
as specified. Failure to comply may cause house fire.
HOT SURFACES!
Glass and other surfaces are hot
during operation AND cool down.
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
stove.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
WARNING
WARNING
8390-044C

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the P61-C and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Harman P61-C

  • Page 1 To obtain a French translation of this manual, please contact your dealer or visit www.harmanstoves.com Pour obtenir une traduction française de ce manuel, s’il vous plaît contacter votre revendeur ou visitez www. harmanstoves.com Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 2: Welcome

    PART # / REV: 8390-044_R1 ADHESIVE: N/A ORIGINATOR: Spidlet MATERIAL: 24 Gauge Aluminum DATE: 11/15/18 INK: Black Background 352 Mountain House Road (4) Corners = R.062 Halifax, PA 17032 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 3: Table Of Contents

    P61-C ........
  • Page 4: Product Specific And Important Safety Information

    State of California to cause cancer, and carbon monoxide, which is know to the State of California to cause birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 5: Btu & Efficiency Specifications

    This wood heater needs periodic inspection and repair for proper operation. It is against federal regulations to operate this wood heater in a manner inconsistent with operating instructions in this manual. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 6: General Information

    • Unplug stove from receptacle. Connect the power cord to a 120 VAC, 60 Hz grounded receptacle. (A surge protector is recommended to protect the circuit board.) Be sure the polarity of the outlet the stove is plugged into is correct. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 7: Control Explanation

    Dealers exclusively. vary the distribution blower speed using the inner scale marked from 1 to 7. by turning the knob to the high or low side of each mode. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 8: Fuel Specification

    Hearth & Home Technologies is not responsible for stove robbing heat from your home. Damp pellet fuel could turn performance or extra maintenance required as a result of back into sawdust which does not flow properly through the using fuel with higher ash or mineral content. feed system. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 9: General Operating Information

    Regardless of the burn rate, when the area is warm enough ENGINE OIL. to satisfy the room sensor, the appliance will shut off. • DO NOT USE CHEMICALS OF FLUIDS TO START THE FIRE. • Combustible materials may ignite. Figure 3.1 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 10: Operating Instructions

    When this happens, the unit will need to be turned to the off position and restarted. If needed, follow the instructions in Section A “Starting Your First Fire”. Figure 4.3 Figure 4.4 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 11: Automatic Ignition

    WELL AWAY FROM THE HEATER, WHILE IN USE. Figure 4.6 Note: The firebox low pressure switch will not allow the auger motor or the igniter element to operate if the view door is open. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 12 The best way to shut down the stove is simply let it run out of pellets, then the stove will shut down automatically. This setting will produce continuous maximum heat output with the distribution blower at full speed. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 13: Maintenance And Service

    • Risk of shock if appliance not unplugged before servicing appliance. Follow the detailed instructions found in this section for each step listed in the chart below. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 14: Quick Reference Maintenance Chart

    4. Yearly cleaning is also known as a Total Clean. This requires completing all the Daily, Weekly, Monthly and Yearly maintenance mentioned. This should be done before you begin burning the unit each heating season. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 15: Glass Maintenance

    Replace glass only with high temperature mirrored ceramic glass. Inspect door gasket during cleaning and inspection Glass Gasket P68-C Freestanding Pellet Stove Glass Retainers and screws Door Frame Adhesive gasket Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 16: Burnpot Maintenance

    Use caution when cleaning burn pot clean-out chamber. Do not damage the high temperature igniter Igniter hot lead wires (High temperature) wires. Figure 5.3 - View from below through the ash pan opening. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 17: Combustion Blower Chamber

    Combustion Intake Cover while cleaning this area. Figure 5.4 Exhaust Passage ESP Sensor Figure 5.7 Pull up on Intake Retainer Figure 5.5 Pull and slide to the right Figure 5.6 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 18: Pellet Feeder Chamber

    NOTE: Views are shown with the rear motor covers removed. Feeder clean out cover 5/16" Wing Nut Figure 5.8 Pellet Metering Possible pellet fines Slide Plate buildup area. Figure 5.9 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 19: Troubleshooting And Frequently Asked Questions

    7. This is normal. Flame will settle down once the fire is established. Contact your dealer for additional information regarding operation and troubleshooting. Visit www.harmanstoves. com to find dealer. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 20: Troubleshooting

    FIRE HAS GONE OUT- Check for status light. 1. No fuel in hopper. 2. Draft is too low, blocked flue. 3. Something is restricting fuel flow. 4. Hopper lid not closed properly. 5. Feed motor or combustion blower has failed. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 21: Reference Materials

    If a fire occurs, call the fire department, shut down the stove, and evacuate the residence. Before using the appliance, have the venting system thoroughly inspected and replace any damaged components. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 22: Motor And Component Location

    Sensor for faults. If a fault should occur, the control sends a status is connected into the AC (high voltage) wiring. alert and at the same time the unit goes down to minimum feed/ minimum burn as a safety condition. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 23: Loss Of Power

    IMPORTANT! : UPS or Battery Backup cannot prevent smoke leakage from an improperly maintained unit. Keep the venting system clean and free from obstructions and maintain all gaskets to keep an airtight seal. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 24: Service Parts

    PART NUMBER Hopper Assembly 1-10-04300 Hopper Knob 1-00-02000-1 Pre HF2372946 1-00-773901 Hopper Latch Assembly Post HF2372946 SRV8000-050 Hopper Lid w/Hinge, Knob 1-10-773900 Additional service parts on following page. 1/22 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 25 Auger Motor Cover 2-00-773843P Auger Motor Shield 2-00-773815P Differential Switch 3-20-6866 Gasket Set, Burn Pot & Tailpipe Pkg of 5 Sets 1-00-07381 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 26 Arrow Burn Pot Scraper Pkg of 10 2-00-773850-10 Cradle Assembly Igniter Holder, Cradle, & Flat Bottom 1-00-777907 Diagnostic Display Module 3-20-05401 DDM Replacement Cable 1-00-05402 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 27 3-43-08400-7 Ash Lip Trim Bright Nickel 3-43-08400-8 Brushed Stainless 3-43-06729-7 Tile Frame No longer available 3-43-06729-8 Spring Clips (Required for installation of Tile Frame) Pkg of 20 3-31-232547-20 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 28: P61-C

    Depot ITEM Description COMMENTS PART NUMBER Hopper Assembly 1-10-05803 Hopper Knob 1-00-02000-1 Pre HF2402759 1-00-773901 Hopper Latch Assembly Post HF2402759 SRV8000-050 Additional service parts on following page. 1/22 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 29 Pkg of 2 1-00-142818 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Silicone Tubing, 1/8” 5 Ft 1-00-5113574 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 30 Fire Brick 4-1/2 x 9 x 1-1/4” Pkg of 7 1-00-900450125 Fire Brick , Full Skid 414 Pcs 3-40-900450-414 Hopper Heat Shield 2-00-06471B Feeder Cover 2-00-773826L Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 31 3-43-08400-7 Ash Lip Trim Bright Nickel 3-43-08400-8 Brushed Stainless 3-43-06729-7 Tile Frame No longer available 3-43-06729-8 Spring Clips (Required for installation of Tile Frame) Pkg of 20 3-31-232547-20 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 32: P68-C

    Depot ITEM Description COMMENTS PART NUMBER Hopper Assembly 1-10-00688 Pre HF2424081 1-00-773901 Hopper Latch Assembly Post HF2424081 SRV8000-050 Hopper Knob 1-00-02000-1 Additional service parts on following page. 1/22 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 33 Pkg of 2 1-00-142818 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Silicone Tubing, 1/8” 5 Ft 1-00-5113574 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 34 Pkg of 10 3-31-782108-10 Fire Brick 4-1/2 x 9 x 1-1/4” Pkg of 7 1-00-900450125 Fire Brick , Full Skid 414 Pcs 3-40-900450-414 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 35 Power Cord 3-20-39685 Thermister Probe (ESP Probe) 3-20-00844 Thermostat Extension 3-20-00607 Touch up Paint, Black, 12 oz Can 3-42-19905 Wiring Harness 3-20-08727 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 36 Ash Lip Trim Bright Nickel 3-43-08400-8 Brushed Stainless 3-43-06729-7 Tile Frame 3-43-06729-8 No longer available Pkg of 20 3-31-232547-20 Spring Clips (Required for the installation of Tile Frame) Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 37 Firebox and heat exchanger, FlexBurn® System 3 years Lifetime (engine, inner cover, access cover and fireback) None 1 Year All purchased replacement parts Page 1 of 2 4021-645L 10/20 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 38: Limited Lifetime Warranty

    EXPRESSED WARRANTY SPECIFIED ABOVE FOR THE APPLICABLE PRODUCT. Some States do not allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. Page 2 of 2 4021-645L 10/20 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 39 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...
  • Page 40: Contact Information

    Printed in U.S.A. - Copyright 2012 Harman® • P-Series Owner’s Manual_R15 • 2018 - ___ • 01/22 8390-044C...

This manual is also suitable for:

P43-cP68-c

Table of Contents

Save PDF