Table of Contents
Advertisement
WARNING: Wait at least five
seconds before removing the fuel pump
nozzle to allow any residual fuel to drain
into the fuel tank.
WARNING: Stop refueling after the
fuel pump nozzle automatically shuts
off for the second time. Failure to follow
this will fill the expansion space in the
fuel tank and could lead to fuel
overflowing.
WARNING: Do not remove the fuel
pump nozzle from its fully inserted
position when refueling.
An engine that suddenly becomes noisy or
operates poorly after a fuel fill could be
using substandard fuel. We recommend
that you purchase diesel fuel from a
reputable fuel station.
Use only clean, approved containers that
prevent the entry of dirt or water whenever
you store diesel fuel.
Do not store diesel fuel in a galvanized
container. The fuel dissolves the zinc in the
galvanized container. The zinc will then
remain in the fuel. If you run the
contaminated fuel through the engine, the
zinc damages the fuel injectors. Engine
damage caused may not be covered by
the vehicle warranty.
Use the following guidelines to avoid
electrostatic charge build-up when filling
an ungrounded fuel container:
•
Place the approved fuel container on
the ground.
•
Do not fill a fuel container while it is in
the vehicle (including the cargo area).
•
Keep the fuel pump nozzle in contact
with the fuel container when filling.
•
Do not use a device that would hold
the fuel pump handle in the fill position.
2025 F-650/750 (TBC) , enUSA, Edition date: 202310, First-Printing
Fuel and Refueling
Fuel Filler Cap
be under pressure. If you hear a hissing
sound near the fuel filler inlet, do not
refuel until the sound stops. Otherwise,
fuel may spray out, which could cause
serious personal injury.
Note: If you do not use the correct fuel filler
cap, excessive pressure or vacuum in the
fuel tank may damage the fuel system or
cause the fuel cap to disengage in a crash.
The fuel tank has a threaded fuel filler cap.
Note: If you must replace the fuel filler cap,
replace it with a fuel filler cap that is
designed for your vehicle. The vehicle
warranty may be void for any damage to the
fuel tank or fuel system if the correct
genuine Ford, Motorcraft or other certified
fuel filler cap is not used.
When refueling the vehicle fuel tank do the
following:
1.
2. Apply the parking brake and switch the
3. Turn the fuel filler cap
4. Refuel your vehicle as required.
5. Replace the fuel filler cap, turn it
Fuel Fill Rate
Your vehicle has a fuel fill inlet that is able
to accept fuel up to 20 gal (75 L) per
minute from a fuel-dispensing nozzle.
Pumping fuel at greater flow rates may
result in premature nozzle shut off or spit
back.
112
WARNING: The fuel system may
Bring your vehicle to a complete stop
and shift into neutral (N) or park (P).
ignition off.
counterclockwise and remove it.
clockwise until you feel a strong
resistance.
Advertisement
Table of Contents
