Related Manuals for EKKO EA15B
Summary of Contents for EKKO EA15B
- Page 1 Service Manual Part Manual EA15B--Semi Electric Stacker Note: Before use, read this manual, be trained and understand all of the warning labels on the Stacker.
-
Page 2: Safety Guidance
Preface EKKO Lifts would like to thank you for your recent purchase of our semi-electric stacker EA15 series. The stacker is made of high-quality steel and was designed to give you a durable, reliable and ease of use equipment. For your safety and correct operation usage, please carefully read this instruction manual and warnings on this stacker before use. - Page 3 1.1Operator should read the manual before operation of the equipment, review and understand warning signs on the stacker before using it. 1.2Do not operate a stacker unless you are familiar with the unit and have been properly trained and authorized to do so. 1.3Do not operate a stacker unless you have inspected its condition.
-
Page 4: Maintenance
2.Maintenance 2.1Hydraulic oil Please check the oil level every six months. The oil can be hydraulic oil: ISO VG32, its viscosity should be 32cSt at 40oC, total volume is about 4.0 liters. 2.2Daily check and maintenance It is required to check the stacker every 8 hours daily. Special attention should be to the wheels and axles of debris stuck in between which may block the wheels. -
Page 5: Control Panel
4.Control panel Charging emergency handle light stop switch Charger voltmeter cable holder 4.1 Emergency Switch When you press this button, the pump station motor power will be cut off; When you pull this switch, the motor power will be switched on. 4.2 Voltmeter This meter shows the voltage of the battery. -
Page 6: Troubles Shooting
5.Troubles shooting Trouble Cause Solution The forks can’t -Low on hydraulic fluid -Add hydraulic lift to the max. fluid. height. forks -No hydraulic fluid. -Add hydraulic cannot lift at all. -The tank or fluid has fluid impurities. -Change fluid -The emergency switch is -Pull emergency pressed down switch up. - Page 7 6 Part List 6.1 EA15B Mast...
- Page 8 EA15B Mast 序号 代号 名称 规格 数量 GB/T 818-2000 十字槽盘头螺钉 M6×20 SPN10.0-6 防护罩夹 SPN10.0-4D 防护罩 SPN10.0-4C 防护罩 SPN-MG-04 配电箱总成 SPN10.0-3 小轮轴 GB 2674-86 内六角半圆头螺钉 M10×25 SPN10.4-3 压盖 GB/T 276-94 深沟球轴承 6205 GB/T 297-94 圆锥滚子轴承 30205 GB/T 97.1-2002 平垫圈 φ24 SPN10.6.1 从动轮轮架...
- Page 9 SPN10.4-5 转向轴 SPN10.4.3-1,4 拉紧螺栓 GB/T 41-2000 六角螺母 SPN10.4.3-2 拉紧器 GB/T 6176-2000 六角螺母 M18×1.5 GB/T 93-1987 弹性垫圈 Φ10 GB/T 95-2002 平垫圈 Φ10 GB 894.1-86 轴用弹性挡圈 φ25 GB 893.1-86 孔用弹性挡圈 φ52 SPN10.3-3 侧压垫 SPN10.0-1 前轮 GB 923-88 盖形螺母 GB 923-88 盖形螺母 GB/T 41-2000 六角螺母...
-
Page 10: Distribution Box
SPN10.8-1 活塞杆 3.0 SPN10.8-1 活塞杆 3.5 SPN10.8-5 活塞 SPN10.8-9 挡圈 ISO12A 链条 3.0 ISO12A 链条 3.5 SPN10.0-1 链条拉杆 GB/T 6170-2000 六角螺母 GB/T 93-1987 弹性垫圈 φ14 SPN10.2-5(G) 链轮 GB/T 70.1-2000 内六角圆柱头螺钉 M10×20 6.2 Distribution box... - Page 11 6.2 Distribution box 代号 名称 规格 数量 序号 SPN10.9-2 电器罩 GB/T 818-2000 十字槽盘头螺钉 M5×10 12V/20A（110v 美标） 内置式充电器 SPN-MG-04.01 充电器支架 GB／T41-2000 六角螺母 C 级 SPN10-10.1 电瓶固定架(电瓶固定) 蓄电池 GB/T 97.1-2002 平垫圈 Φ10 GB/T 93-1987 弹性垫圈 φ10 SPN10.9.1NZ 配电箱 （内置式） CMB1-VB1303060-120 泵站 发光二极管灯座 SL15GD-03.2 充电器线座...
- Page 12 6.3 Adjustable wide legs 6.3 Adjustable wide legs 代号 名称 规格 数量 序号 车腿焊合 outrigger SPN-MG-01.01.01.02 legs GB/T 70.1-2000 内六角圆柱头螺钉 M8×12 GB/T 97.1-2002 平垫圈 Φ20 GB/T 93-1987 弹性垫圈 Φ20 CLJ1030.06-8 压块 CLJ1030.06-7 调节螺杆/Shaft GB／T5780-2000 六角头螺栓/ Bolt M20×65 CLJ-MG-01.11 压板/Bar GB／T5780-2000 六角头螺栓/ Bolt M16×55 GB／T41-2000...
- Page 13 6.4 tray rack 7.4 tray rack 序号 代号 名称 规格 数量 SPN-MG-03.01 托盘架焊合/Carriage SPN10.3-3 侧压垫/End cap 内六角平端紧定螺钉 GB/T 77-2000 M12×20 /Pin （t35*100*1150） 加高锻打货叉/Forks GB／T41-2000 六角螺母/ Nut 调整挡块/Adjustment SPN10.3.2-2 pads GB 894.2-86 轴用弹性挡圈/Ring φ32 SPN10.3-2 长轴/Rod Φ32*885 GB 894.2-86 轴用弹性挡圈/washer φ25 孔用弹性挡圈/Snap GB 893.2-86 φ52...