Related Manuals for saro LADY 900
Summary of Contents for saro LADY 900
- Page 1 OPERATION AND MAINTENANCE MANUAL Translation of the original instructions in Italian GAS PASTA COOKER LADY QUEEN 1001 UM500009 - 10/2015...
- Page 2 Reproduction of this document, either in total or in part, is forbidden without prior written consent by the Manufacturer, who reserves the right to modify it without any obligation to give notice, unless this represents a safety risk. Drafted by: VEGA srl GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 3: Table Of Contents
Tables and annexes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 GAS PASTA COOKER - LADY 900... - Page 4 This page intentionally left blank GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 5: General Information
General information 1 GENERAL INFORMATION GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 6: Purpose And Description Of The Manual
- Section 6 is intended for qualified fitters and concerns correct installation of the appliance. - Section 7, if present, contains tables and annexes. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 7: Correct Manual Storage
No part of the manual should be removed, torn out or arbitrarily changed. DANGER This manual is an integral part of the appliance and must be kept until final disposal of the same. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 8: Identification Data
In the event of any request for information or technical assistance, it will be necessary to specify the model and type of appliance, as well as its serial number. 1 .3 .1 Appliance type and model The appliance type and model are indicated on the identification plate. GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 9 The CE mark applied on the identification p late c onfirms th at th e ap pliance co mplies wi th th e safety requirements specified in the following directives: Directive 2016/426/EU (Gas appliances) GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 10: Requests For Assistance
- For all of the above reasons, in the event of an emergency, we recommend contacting the Manufacturer's Technical Assistance Department directly. IMPORTANT For any type of service request it is necessary to specify the data on the identification plate and the type of fault . GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 11: Technical Information
Technical information 2 TECHNICAL INFORMATION GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 12: General Description Of The Appliance
Do not use the appliance to fry food since it was not designed for such use . DANGER Do not tamper with the seals applied by the fitter to the gas supply system. GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 13 E. Tank drainage tap (inside the structure) F. False bottom (inside cooking tank) G. Fume extraction grille H. Burner control knob and ignition switch (inside the structure) Fig. 3 Appliance main components in STANDARD version GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 14 2. "1/2 tank" perforated basket 3. "1/3 tank" perforated basket 4. "1/6 tank" perforated basket Fig. 4 Accessories supplied All baskets are made of stainless steel and are fitted with a heat-resistant handle. GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 15: Safety Information
Safety information 3 SAFETY INFORMATION GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 16: Safety
It is strictly forbidden to modify or carry out any type of intervention on the appliance, except those related to routine maintenance . Any modification not explicitly approved by the Manufacturer will automatically void the warranty and the appliance conformity to the directives . GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 17 The appliance has been manufactured using recyclable raw materials and does not contain any harmful or toxic substances. All materials must be disposed of in compliance with the regulations applicable in the country of use of the appliance. Always comply with environmental protection regulations. GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 18 Safety information This page intentionally left blank GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 19: Information For Correct Use
Information for correct use 4 INFORMATION FOR CORRECT USE GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 20: First Use
It is strictly forbidden to start the appliance without water in the cooking tank; make sure that during appliance operation there is ALWAYS water inside the cooking tank . Fig. 5 Tank maximum filling level GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 21: Complete Map Of The Controls
- Use supply knob (A) to fill the tank, then fill the tank up to the maximum level. WARNING This operation must be carried out once the water has sufficiently cooled down. To empty the tank proceed as shown. - Open the discharging tap. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 22: Burner Start And Turning Off
4 .4 .3 Burner turning off - To turn burner off, turn knob (B) until reaching position (Pilot). To turn also pilot flame off, turn knob (B) until reaching position position. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 23: Recommendations For Use
- clean and dry the alliance; - after cleaning and drying the appliance, protect it with a film of a suitable product (for example, Vaseline oil spray or a similar product); GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 24 Information for correct use This page intentionally left blank GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 25: Maintenance Information
Maintenance information 5 MAINTENANCE INFORMATION GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 26: Maintenance Recommendations
- caustic potash at 5% (max) - caustic soda at 5% Rinse-aid products containing: Products for eliminating unpleasant smells - citric acid - acetic acid Tab. 3 Table of cleaning products GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 27 The evaporation of saline solutions on the surfaces is particularly harmful for them. See also par. Useful tips for stainless steel care on page 28. GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 28: Useful Tips For Stainless Steel Care
. Besides eliminating marks or rings, they also restore the shine to the steel and prevent the infiltration of humidity and dirt, which cause corrosion. GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 29 - When pots, washing machine compartments, bain-marie recipients, sinks, etc. are not used, they should preferably remain uncovered in order to keep the passivation film protecting the stainless steel stable and prevent it from coming into contact with possible aggressive agents. GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 30: Troubleshooting
Contact a qualified Clean the burner gas are obstructed technician. ring. Leak from the gas Contact a qualified Smell of gas Check sealing. piping technician. Tab. 4 Problems associated with gas GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 31: Instructions For Qualified Fitters
Instructions for qualified fitters 6 INSTRUCTIONS FOR QUALIFIED FITTERS GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 32: General Information
. The various types of material must be separated and taken to special collection centres . Always comply with environmental protection regulations . GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 33: Technical Data
Burners Cooking tanks type capacity electric power 1 15.0 kW 15 kW LQ/CPG1V40 1 40-litre tank burner 2 15.0 kW L9/CPG2V80 2 40-litre tanks 30 kW burners Tab. 5 Technical data GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 34 6 .4 .2 Dimensions pasta cooker Fig. 12 pasta cooker dimensions Fig. 13 One tank Fig. 14 Two tanks A. Gas supply ø 1/2" B. Water inlet C. Water drain ø 1” GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 35 G25,1 20 ÷ 25 1,164 1,587 Consumption of methane gas 20 ÷ 25 1,354 1,846 (cu. m/h) G25,1 1,352 1,843 Tab. 6 Methane gas Fig. 15 Gas burner primary air adjustments GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 36 Pilot nozzle marking for liquid 28 ÷ 50 0,867 1,183 Consumption of liquid gas (cu. m/h) 28 ÷ 50 0,855 1,165 Tab. 7 LPG gas Fig. 16 Gas burner primary air adjustments GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 37: Positioning And Installation
Appliance installation and maintenance must be carried out by qualified and authorized personnel, who must comply with the safety regulations applicable in the country where the appliance is to be installed. GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 38 - Carry out water supply system connection (chap. Water supply system connection on page 42). - Carry out drain pipe connection (chap. Drain pipe connection on page 42). 200 mm Fig. 17 Minimum distance from flammable walls GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 39 Air intakes must be of a suitable size, must be protected by grilles and must be placed in such a way that they cannot be obstructed. Fig. 18 Ventilation of the installation premises GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 40 (see Fig. 20 Fume extraction through extraction hood). - The power of the mechanical extraction system must not be lower than required. 1,8 m Fig. 19 Fume extraction Fig. 20 Fume extraction through extraction hood GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 41: Gas Connection
Tab. 10 Gas category and pressure. If the gas indicated on the plate is not the same available in the premises, follow the instructions in chap. Adjustment for operation with different gases on page 47. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 42: Water Supply System Connection
The appliance has a floor drain pipe; carry out drain pipe connection using plastic heat-proof pipes (at least 90°C) in compliance with the hygiene regulations applicable in the country where the appliance is to be installed. GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 43: Inspection And Start-Up
- check correct ignition and combustion of every burner; - check the correct functioning of the pilot flames and that the nozzles are correct; - check the proper functioning of the safety thermocouple. GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 44 Using red paint, seal the pressure control screw, then refit the front panel and knobs. IMPORTANT The Manufacturer shall not be held responsible for any damage to people or objects caused by installation errors . GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 45 After testing, if necessary, train users so that they acquire all the necessary skills to start-up the appliance in safe conditions, as provided for by applicable regulations. IMPORTANT While explaining, always refer to this Use and Maintenance Manual . GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 46: Adjustments
35. DANGER Carbon monoxide is an odourless, colourless and toxic gas and is lethal even at very low concentrations . GAS PASTA COOKER - LADY 900 © Copyright 2015... -
Page 47: Adjustment For Operation With Different Gases
- Refit all the parts removed so that the appliance can be used. A. Main burner B. Fixing screw for air adjustment C. Air adjustment bushing D. Main burner nozzle E. Gas ramp F. Nut Fig. 22 Burner main parts GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 48 - No air adjustment is required. A. Pilot blowpipe B. Burner body C. Thermocouple D. Ignition electrode E. Fixing screw F. Nozzle G. Pilot bracket Fig. 23 Pilot nozzle main parts GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 49: Maintenance To Be Carried Out By A Fitter Or Qualified Technician
- Clean the gas outlet holes by means of a drill (for instance, a twist drill) or a similar tool; - Once cleaned, refit the pieces in reverse order; - Check the combustion gas extraction duct and the anti-draught device (if present). GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 50 - Remove the thermocouple (C) from the support and disconnect it from the safety thermostat circuit; - Install the new thermocouple, repeating the above sequence in reverse order; - Refit all the parts removed so that the appliance can be used. GAS PASTA COOKER - LADY 900 © Copyright 2015...
-
Page 51: Tables And Annexes
Tables and annexes 7 TABLES AND ANNEXES GAS PASTA COOKER - LADY 900 © Copyright 2015... - Page 52 G 30 (butane) 11.000 45,6(MJ/kg) 12,67(kW/kg) Liquefied (Kcal/kg) petroleum family 22.190 gases (LPG) 92,91 (MJ/m3) 25,8 (kW/m3) (Kcal/m3) G 31 (propane) 11.000 46,4(MJ/kg) 12,88(kW/kg) (Kcal/kg) Tab. 9 Families of standardised gases GAS PASTA COOKER - LADY 900 © Copyright 2015...
- Page 53 28 - 30/37 SWEDEN II2H3B/P G30 / G31 SWITZERLAND II2H3B/P G30 / G31 SWITZERLAND II2H3+ G30 / G31 28 - 30/37 TURKEY II2H3B/P G30 / G31 Tab. 10 Gas category and pressure GAS PASTA COOKER - LADY 900 © Copyright 2015...
Need help?
Do you have a question about the LADY 900 and is the answer not in the manual?
Questions and answers