Page 1
P-XX1598 ISSUE 1 RAVEL 600 BALANCED FLUE GAS LOG FIRE USER INSTRUCTIONS INSTALLATION INSTRUCTIONS SERVICE INSTRUCTIONS Do not use this appliance if the front glass panel is broken, removed or fi ed incorrectly. It is a regula on that these instruc ons be handed to the customer a er installa on is complete.
Contents Appliance Commissioning Check List ………………………………...……..…..……………......User Instruc ons—Important informa on, Ven la on & Warnings …….……..………………..User Instruc ons—Controls & Opera on …………………………………………..…………………………….. 5 User Instruc ons—General Maintenance & Cleaning ….……………………………...………………….… 6 Log Layout Instruc ons …………………………………………………………………………………………………..9 Running in and Troubleshoo ng …………………………...……………………………………………………………... 14 Unpacking the appliance ...…………………………………………………………………………………………………….
Safety Check 1.0 APPLIANCE COMMISSIONING CHECKLIST It is the installers responsibility to complete the following checklist when commissioning this appliance. The informa on recorded on this page may be requested at the me of any warranty call made. If the informa on is not made available it may affect the warranty support for the customers appliance.
INSTRUCTIONS Welcome 2.0 Congratula ons on the purchase of your new Wildfire Ravel 600 Balanced Flue gas fire. Ensure you keep these instruc ons in a safe place as they will be required for installa on, service and general upkeep of your appliance.
USER INSTRUCTIONS Controls 2.1 This appliance has a concealed slide control knob. It is discreetly concealed in the space between the decora ve trim and the glass door frame on the lower right hand side. Simply press the knob and it will protrude from its current posi on to enable opera on.
USER INSTRUCTIONS Ba ery 2.2 This gas appliance uses a single AAA type ba ery which supplies the power for the spark generator used during the igni on process. The ba ery box which houses this ba ery is located between the decora ve frame and the glass door panel in the lower le hand corner.
Page 7
USER INSTRUCTIONS Cleaning is recommended for some parts of this appliance. The glass can be cleaned with a non Cleaning abrasive glass cleaner and lint free cloth. See page 6 for details on cleaning inside glass panel and door removal. Metal parts can be cleaned with a lint fee damp cloth. HEALTH AND SAFETY NOTICE Fuelbed This appliance uses fuel effect pieces manufactured from Refractory Ceramic Fibres (RCF).
Page 8
USER INSTRUCTIONS This appliance MUST be installed and commissioned by a GAS SAFE installer. Under no Important circumstances must any a empt be made to fit or run this appliance unless it has been installed correctly. The appliance required some assembly prior to installa on and again, this should only be undertaken by the GAS SAFE installer.
USER INSTRUCTIONS 2.3 The following instruc ons detail how the ceramic fuel bed and loose components are to Log Setup be installed onto the appliance. Great care should be taken when handling these ceramic parts as they are fragile and can easily be broken. Do not force any component into posi on, if it does not fit easily then you are not fi...
Page 10
USER INSTRUCTIONS Place the volcanic rock on top of the centre burner as shown. Ensure a 4-5 mm gap is le FUELBED between each piece. Then using half of the glowing ember wire supplied, ruffle between fingers to make it loose, about 20mm wide and as long enough to cover the volcanic rock then align over the rock as shown.
Page 11
USER INSTRUCTIONS Place Log C onto the right raised burner as shown ensuring it fits securely. Place Log D in the orienta on shown below. Place Log E in the orienta on shown below.
Page 12
USER INSTRUCTIONS Place Log F onto the burner bed in front of the centre burner as shown below. Bark Place the bark around the fuel bed as shown. Ensure that no bark can interfere with the pilot opera on.
Page 13
USER INSTRUCTIONS Ensure that no bark is placed in the red area. Place Log G as shown in the picture below.
USER INSTRUCTIONS Running In 2.4 When this appliance is first used it is important to note that you will experience some fumes and smells in the room of opera on. Any fumes emi ed during the first few minutes of use can be quite pungent and it is advised that a window is opened un l this subsides.
These handles are for ini al handling only, they should be removed prior to the installa on into the fireplace opening. The Ravel 600 Edge Trim is supplied with the appliance. This is the only trim op on for the Ravel 600 BF Carefully remove the Ravel 600 Edge Trim from the mouth of the appliance.
INSTALLATION INSTRUCTIONS 3.1 NOTE THE FOLLOWING PRIOR TO THE INSTALLATION OF THIS APPLIANCE. Regulatory Informa on This gas appliance MUST be installed by a GAS SAFE registered installer by law. It must be installed in accordance to these installa on instruc ons and the GAS SAFETY (Installa on &...
INSTALLATION INSTRUCTIONS 3.4.0 Do not place so wall coverings (i.e. embossed papers etc,) furniture or other Site combus ble items too close to the appliance as they may discolour or scorch. Requirements Do not place or throw rubbish or otherwise on the fuel-bed. It is very important that you arrange for a GAS SAFE registered engineer to service your appliance every year –...
INSTALLATION INSTRUCTIONS 3.4.5 REGULATORY REQUIREMENTS FOR FLUE TERMINAL LOCATION THE FOLLOWING MUST BE NOTED PRIOR TO THE INSTALLATION OF THIS APPLIANCE. Figure 1 Terminal Posi on Minimum Distance Directly below an opening, airbrick, opening window etc. 300mm Above an opening, air brick, opening window etc. 300mm Horizontally to an opening, air brick opening window etc.
INSTALLATION INSTRUCTIONS 3.4.6 The following diagrams detailing installa on into studding also show the area which Studding must be clear of all combus ble materials. It is also possible to install this appliance into a studded cavity providing it complies to the following requirements: •...
INSTALLATION INSTRUCTIONS 3.5 SITING THE APPLIANCE AND PREPARING THE OPENING Figure 2 Figure 2 shows the maximum length flue a ached to the appliance. If the distance from the front face of the back panel to the outside wall exceeds 659mm the installa on cannot proceed. In most installa ons the flue sec on will need to be cut to the appropriate size.
Page 21
INSTALLATION INSTRUCTIONS It may be necessary to install a lintel above the cavity that has been created. If a lintel is required to support the recess in the inner leaf (brickwork) then it should either be steel or reinforced precast concrete.
INSTALLATION INSTRUCTIONS Methods of 3.6 This appliance has can be installed into a fireplace or a fabricated chimney breast to Installa on provide a hole in the wall solu on: Both installa on types will incorporate the EDGE trim which is supplied with the appliance.
INSTALLATION INSTRUCTIONS This fire is suitable for fi ng to non-combus ble fireplace back panels with a temperature ra ng of at least (Check with your fireplace retailer that your back panel and hearth are capable of withstanding the higher temperatures of a balanced flue appliance. Some micromarble products can contain a high content of resin which can cause smells and discoloura on of the backpanel.
INSTALLATION INSTRUCTIONS The Ravel 600 Edge Trim is supplied with the appliance. Remove this trim and Edge Trim place somewhere that damage cannot occur whilst preparing the installa on. Installa on The appliance is already prepared for installa on of this trim.
INSTALLATION INSTRUCTIONS 3.9.1 When the Ravel 600 Edge Trim op on is selected the following diagram shows the Edge Trim back panel/slip set dimensions which should be used. Installa on Cri cal Mantel Dimensions...
INSTALLATION INSTRUCTIONS 4.0 Fixing the Appliance - Screw Fixing Fixing the Appliance The appliance can be installed using the screw fixings supplied. See the diagrams below.
INSTALLATION INSTRUCTIONS Fi ng the 4.1 With the UNCUT FLUES FITTED to Flue System the appliance, drill the 3 holes as shown in the OUTER flue and fix with the 3 screws provided. Next place the fire into installa on posi on, temporarily, while the flue lengths are confirmed.
Page 28
INSTALLATION INSTRUCTIONS Now temporarily secure the wall plate using the screws and plug supplied. The flues needs to protrude through the wall plate by 12mm to ensure it can be fastened by the 3 lugs on the wall plate. Mark these 3 hole posi ons which need to be drilled at 3mm dia. Make a mark on the outer flue at a posi on 12mm past the wall plate surface.
Page 29
INSTALLATION INSTRUCTIONS FITTING THE TERMINAL & TERMINAL GUARD ONLY THE TERMINAL AND TERMINAL GUARD SUPPLIED WITH THIS PRODUCT SHOULD BE FITTED. THIS TERMINAL GUARD ALLOWS FOR BLAST FLAP CLEARANCE. From the outside carefully insert the inner flue, the flue guides on the inner flue should be towards the outside wall, to keep the two flues concentric before they enter the terminal.
Page 30
INSTALLATION INSTRUCTIONS Using the diagram below, fold the terminal guard, aligning the screw fixing holes in each corner to create the correct shape.
Page 31
INSTALLATION INSTRUCTIONS Screw the guard to the terminal loca ng bracket (fi ed earlier). This must be fi ed correctly to ensure that the correct clearance is maintained above the terminal for the blast relief flap to open fully. Now fix the guard to the wall using the screws and plugs provided.
INSTALLATION INSTRUCTIONS Connec ng 4.3 Connec ng the Appliance to the Gas Supply To Gas Supply The gas supply should be connected to the appliance by a concealed fi ng from the rear. In all installa on condi ons the gas connec on should be provided using 8mm (O/D) copper tubing.
INSTALLATION INSTRUCTIONS Connec ng the Appliance to the Gas Supply (Con nued) Next, remove the five (5) black screws as shown to release the access cover as shown. Fit the isola on valve (read note below) to the inlet pipe as shown here. This restrictor elbow is supplied loose and should be fi...
INSTALLATION INSTRUCTIONS 4.5 The following instruc ons detail how the ceramic fuel bed and loose components are to be LOG SETUP installed onto the appliance. Great care should be taken when handling these ceramic parts as they are fragile and can easily be broken. Do not force any component into posi on, if it does not fit easily then you are not fi...
Page 35
INSTALLATION INSTRUCTIONS Place the volcanic rock on top of the centre burner as shown. Ensure a 4-5 mm gap is le between each piece. Then using half of the glowing ember wire supplied, ruffle between FUELBED fingers to make it loose, about 20mm wide and as long enough to cover the volcanic rock then align over the rock as shown.
Page 36
INSTALLATION INSTRUCTIONS Place Log C onto the right raised burner as shown ensuring it fits securely. Place Log D in the orienta on shown below. Place Log E in the orienta on shown below.
Page 37
INSTALLATION INSTRUCTIONS Place Log F onto the burner bed in front of the centre burner as shown below. Bark Place the bark around the fuel bed as shown. Ensure that no bark can interfere with the pilot opera on.
Page 38
INSTALLATION INSTRUCTIONS Ensure that no bark is placed in the red area. Place Log G as shown in the picture below.
INSTALLATION INSTRUCTIONS Controls 4.6 This appliance has a concealed slide control knob. It is discreetly concealed in the space between the decora ve trim and the glass door frame on the lower right hand side. Simply press the knob and it will protrude from its current posi on to enable opera on.
INSTALLATION INSTRUCTIONS 4.7 Comple ng the Installa on of the Appliance Ensure that the fire operates correctly and that the burners cross light in less than 3 seconds. If cross ligh ng takes longer than this is or is not consistent, check the loca on of the two logs B & C. Check that the ember- wire is not interfering with the pilot in anyway as this will cause intermi ent ligh ng problems.
INSTALLATION INSTRUCTIONS 4.8 HEALTH AND SAFETY NOTICE This appliance uses fuel effect pieces manufactured from Refractory Ceramic Fibres (RCF). Care must be taken to avoid excessive exposure to these materials as they may cause irrita on to the eyes, skin, nose and throat. When Handling avoid inhaling and contact with skin and eyes.
SERVICING INSTRUCTIONS 5.0 Servicing the Appliance. Servicing The following procedures can and should only be performed by a Gas Safe registered installer. This appliance should be serviced annually by a Gas Safe registered installer. Isolate the appliance using the restrictor elbow and remove the 8mm nut from the restrictor as detailed below.
Page 43
SERVICING INSTRUCTIONS Removal of the Burner Tray (Con nued) Remove the two (2) black screws as shown below to release the middle burner. Next, remove the five (5) black longer screws as shown to release the access cover as shown below. Ensuring the gas is isolated, release the nut on the gas inlet pipe as shown below.
Page 44
SERVICING INSTRUCTIONS Removal of the Burner Tray (Con nued) Disconnect the igni on H.T. lead and unplug the black plas c connector. Finally remove the five (5) silver screws to release the burner tray from the appliance. The burner tray can now be carefully li ed out of the appliance.
SERVICING INSTRUCTIONS 5.2 Removal of the Slide Valve Remove the pipe nut as shown to allow the pilot gas supply tube to be removed from the slide valve. Next, remove the two screws at the rear of the valve shown then remove the thermocouple nut, the gas inlet nut, the...
SERVICING INSTRUCTIONS 5.3 Removal of the Pilot Assembly Follow the instruc ons below to remove the pilot assembly. On reassembly take great care to ensure the pilot injector is clear of debris and is refi ed correctly. Remove the electrode securing nut as shown in the diagram.
SERVICING INSTRUCTIONS 5.4 Removal of the Igniter (Spark Generator) The gas access covers must first be removed—see page 42. Remove the HT lead and remove the black & white switch connector. Next remove the inner hexagonal screw to remove the heat shield. Then remove the outer hexagonal screw as shown in the diagram below .
SERVICING INSTRUCTIONS 5.5 Removal of the Tee Valve First remove the inlet and outlet nuts from the Tee Valve as shown in the diagram below. Then remove the two nuts securing the Tee Valve to the underside of the burner tray. The Tee Valve can be removed and replaced.
SERVICING INSTRUCTIONS 5.6 Removal of the injectors To reveal the injectors, the burners must first be removed. Remove the four screws at the base of the upstanding burners. The two burners can now be li ed out of the appliance. Take note of the marking on each burner signifying LEFT &...
Page 50
SERVICING INSTRUCTIONS Removal of the injectors (con nued) To reveal the final injector, the base plate and central burner must be removed. Remove the two (2) M5 screws marked and the four (4) screws marked .The base plate can now be removed. Next, remove the two screws shown in the diagram and the central burner can now be li ed from the appliance.
SERVICING INSTRUCTIONS 5.7 Removal/Replacement of the Two Side Inner Glass Panels First remove the two clips from the top right and top le as shown in the diagram below. These two side panels can now be removed from the appliance.
SERVICING INSTRUCTIONS 5.7.1 Removal/Replacement of the Rear Inner Glass Panel Once the side glass panels have been removed, the rear glass panel can be lted forward from the top and li ed out of the appliance.
SERVICING INSTRUCTIONS 6.0 Record of annual services The extended warranty of the specified components within this appliance is condi onal on the annual service of the appliance by a Gas Safe registered engineer. Failure to maintain the product or to use the product in away which is not intended will void the manufacturer's warranty.
7.0 Product Fiche Manufacturer : Hearth Products Ltd Model No. F-201XX2 Fuel Type Natural Gas I2H Energy Efficiency Class Indirect Hea ng Func onality Direct Heat Output kW 4.3kW Indirect Heat Output kW 66.1% Useful Energy Efficiency (NCV) High : 75.1% Useful Energy Efficiency (NCV) Nominal Heat Output High : 4.3kW...
8.0 User Replaceable Parts Part Number Descrip on P-XX1241 Ceramic log set complete P-XX1241A—G Ceramic Log A thru G P-XX1212A Volcanic rock (2 Packs) P-XX1213 Ceramic Bark (2 Packs) P-XX1214 Ember Wire Pack P-XX140020A Glass Door Assembly Hearth Products Ltd Unit 14 Tollgate Industrial Estate, Stafford, ST16 3SU Www.hearthproducts.co.uk...
Need help?
Do you have a question about the RAVEL 600 and is the answer not in the manual?
Questions and answers