Table of Contents
Advertisement
Quick Links
Operation
Manual
LIMITED WARRANTY
This product is warranted to be free from defects in material and/or workmanship for
a period of one year from date of original installation (with the exception of racks,
pans, and covers). Any component which proves to be faulty in material and/or
workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) with-
out cost to the customer for parts or labor. This warranty covers on location service
(i.e. trip charges and/or mileage). Travel mileage is limited to 100 miles (200 kilome-
ters -International) round trip (one trip warranty) from an authorized service agency
or its sub-service agency.
This warranty is subject to the following exceptions/conditions:
•
Use of any non-genuine Prince Castle parts voids this warranty.
•
All labor shall be performed during regular work hours. Overtime premium will
be charged to the buyer.
•
Damage caused by carelessness, neglect, and/or abuse (e.g., dropping, tam-
pering or altering parts, equipment damaged in shipment, by fire, flood or an
act of God) is not covered under this warranty.
540-1730_EN rev.B
ATTENTION:
Read the instructions before using the machine.
355 EAST KEHOE BLVD. ~ CAROL STREAM, IL, 60188, USA
PHONE: 630-462-8800 ~ TOLL FREE: 1-800-PCASTLE
FAX 630-462-1460 ~ WWW.PRINCECASTLE.COM
Extended Holding Bin
General Market Series
General Market Series
TABLE OF CONTENTS
Model Identification............................................................ 2
Model Specifications.......................................................... 2
Safety Information............................................................. 2
Configurations.................................................................. 3
Product Identification......................................................... 4
Installation....................................................................... 4
Operation........................................................................ 5
Setting Product Location.................................................... 6
Cleaning......................................................................... 6
Setting the Temperature.................................................... 7
Calibrating the Heaters...................................................... 8
Changing the Hold and Cook More Times.............................
Changing Product Names.................................................. 10
Changing Temperature Scale............................................. 11
Adjusting Alarm Volume.................................................... 11
Choosing a Language....................................................... 12
Default Menu.................................................................. 13
Zone Layouts.................................................................. 14
Dayparts........................................................................ 15
Troubleshooting............................................................... 16
Diagnostics..................................................................... 17
Wiring Diagrams............................................................... 18
Exploded Views............................................................... 20
1
Printed in USA 07/2023 © 2023
Extended Holding Bin
9
Advertisement
Table of Contents
Related Manuals for Prince Castle EHB22 Series
Summary of Contents for Prince Castle EHB22 Series
-
Page 1: Table Of Contents
Model Specifications…………………………………………………. 2 pans, and covers). Any component which proves to be faulty in material and/or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) with- Safety Information……………………………………………………. 2 out cost to the customer for parts or labor. This warranty covers on location service Configurations………………………………………………………... -
Page 2: Model Identification
NOTE: 110-120V SKUs are indicated with an “R1” or “F1” for use in US/CANADA. 208-240V SKUs indicated by “R2” or “F2”. Safety Information Important WARNING Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle Indicates information important to the proper operation of the unit. the buyer to corresponding changes, improvements,... -
Page 3: Configurations
Extended Holding Bin General Market Series Configurations EHB23 EHB22 EHB24 EHB42 EHB34 540-1730_EN rev.B Printed in USA 07/2023 © 2023... -
Page 4: Product Identification
• contact your local dealer, or if purchased directly, the Prince Castle Sales Department at 800-722-7853 or 1-630-462-8800 to arrange for a replacement unit. WARNING: NOTE: Plug the power cord into the proper electrical receptacle. -
Page 5: Operation
Extended Holding Bin General Market Series Operation This application is not intended for use by persons (including children) with reduced physical, sensory WARNING: or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety. -
Page 6: Setting Product Location
To change a menu selection for a specific pan cavity, use the following steps: C. Press the UP or DOWN Arrow D. Press the ENTER button A. Press and hold the PRINCE CASTLE LOGO button for 6 seconds. to select the menu item. button to scroll to the desired All Pan displays will show PROG. -
Page 7: Setting The Temperature
The SET PRODUCT TEMP menu is used to change the Hold and Cook-More times. Press and hold the PRINCE CASTLE LOGO button on the button bar, then immediately press and hold the ENTER button until the display shows one of six programming menus…..(hold for about 5 seconds) Use the UP or DOWN Arrow button to scroll to the PROD BURG ↑... -
Page 8: Calibrating The Heaters
Press ENTER to confirm setpoint temperature. Press PRINCE CASTLE LOGO BUTTON to save the setpoints. Repeat steps 2-5 for all necessary profile upgrades. NOTE: Setpoints are displayed on the front display board, and should be updated according to the product at this point. -
Page 9: Changing The Hold And Cook More Times
The display will show EGGS TIME ↑ ↓ENTR. Repeat Steps 2 – 4 for any other product. Press and release the PRINCE CASTLE LOGO button at any time to exit the Program Mode and return to the Run Mode. NOTE: If the ENTER button has not been pressed to save any changes, the program will revert to the original values. -
Page 10: Changing Product Names
The display will show PROD NAME ↑↓ ENTR. Repeat Steps 2 – 4 for any other product. Press and release the PRINCE CASTLE LOGO button at any time to exit the Program Mode and return to the Run Mode. NOTE: If the ENTER button has not been pressed to save any changes, the program will revert to the original names. -
Page 11: Changing Temperature Scale
Bar will display SET DEGR F/C ↑ ↓ ENTR and either the F or C will be blinking. Use the UP and DOWN arrows to select the desired temperature mode (the selected mode will blink) Press the ENTER button to confirm the selection. Press the PRINCE CASTLE LOGO button to save the setting. Adjusting Alarm Volume The SET VOLUME menu is used to change the alarm volume. -
Page 12: Choosing A Language
The SET LANGUAGE menu is used to change the language. English is the only language offered unless otherwise noted. Press and hold the PRINCE CASTLE LOGO button on the button bar, then immediately press and hold the ENTER button until the display shows one of six programming menus. -
Page 13: Default Menu
Extended Holding Bin General Market Series Default Menu Items Product Number Description Display French Moist Cook Hold Name Display More (min) Crispy (min) Burger BRG1 BRG1 Moist Burger BRG2 BRG2 Moist Crispy CHX1 POU1 Crispy Chicken Crispy CHX2 POU2 Crispy Chicken Crispy CHX3... -
Page 14: Zone Layouts
Extended Holding Bin General Market Series Default Menu Items (Continued) Product Number Description Display French Moist Cook Hold Name Display More (min) Crispy (min) Chicken STRS LPOU Crispy Large LRGB GRND Moist Fish Patty FISH PSSN Crispy Moist Grilled GCHK GPOU Moist Chicken... -
Page 15: Dayparts
Extended Holding Bin General Market Series Dayparts BACN BACN SCRM BACN SCRM SCRM SCRM SCRM SAUS SAUS SAUS SAUS SAUS SAUS SCRM SAUS SAUS SCRM SCRM BACN BACN SCRM SCRM BACN BACN Daypart SAUS SAUS SCRM SCRM SCRM SCRM BRG1 BRG1 BRG1 BRG1... -
Page 16: Troubleshooting
Refer to Kitchen Minder setup manual COMM DOWN Kitchen Minder For all technical support in North America, please contact PRINCE CASTLE LLC 1-800-722-7853 For technical support worldwide, contact your local service representative / installer. Printed in USA 07/2023 © 2023... -
Page 17: Diagnostics
BN04 (4 timer bars detected and done with programming) 7. You can check the version number on the timer bars by pressing the Prince Castle logo button and the down button on timer bar. *EHB34XX requires seven files. The two additional to those listed are mainbar2.hex and auxbar2.hex 540-1730_EN rev.B... -
Page 18: Wiring Diagrams
Extended Holding Bin General Market Series Wiring Diagrams LINE IN This Wiring diagram is used in all configura- tions except the 3X4 Printed in USA 07/2023 © 2023 540-1730_EN rev.B... - Page 19 Extended Holding Bin General Market Series Wiring Diagrams LINE IN This wiring diagram is used in the 3X4 configuration only 540-1730_EN rev.B Printed in USA 07/2023 © 2023...
-
Page 20: Exploded Views
Extended Holding Bin General Market Series Exploded View Model Power Cord GMS02 72-704S GMS60 72-693S GMS78 72-526S Part Number Description 88-824S LINE FILTER* *Only for GMS60 and GMS78 EHB22F1-GMS02 ITEM PART ITEM PART ITEM PART DESCRIPTION DESCRIPTION DESCRIPTION NUMBER NUMBER NUMBER HEATER ASSY, LOWER 197-232S... - Page 21 Extended Holding Bin General Market Series Exploded View Model Power Cord GMS16 72-705S GMS60 72-693S GMS78 72-526S Part Number Description 88-824S LINE FILTER* *Only for GMS60 and GMS78 EHB24F2-GMS16 ITEM PART ITEM PART ITEM PART DESCRIPTION DESCRIPTION DESCRIPTION NUMBER NUMBER NUMBER 197-232S FOOT 4 PACK...
- Page 22 Extended Holding Bin General Market Series Exploded View Model Power Cord GMS02 72-704S GMS60 72-693S GMS78 72-526S Part Number Description 88-824S LINE FILTER* *Only for GMS60 and GMS78 EHB42F1-GMS02 * Items 2-5 Dependent on Voltage ITEM PART ITEM PART ITEM PART DESCRIPTION DESCRIPTION...
- Page 23 Extended Holding Bin General Market Series Exploded View Model Power Cord GMS02 72-704S GMS60 72-693S GMS78 72-526S EHB23R2-GMS16 ITEM ITEM ITEM PART NUM- PART NUMBER DESCRIPTION PART NUMBER DESCRIPTION DESCRIPTION 510-523S 6CH AUX BAR KIT 197-232S FOOT 4 PACK 95-1819S USB CORD 540-1158S LATCH, CATCH...
- Page 24 Extended Holding Bin General Market Series Exploded View Model Power Cord GMS17 72-705S GMS50 72-404S EHB34R2-GMS17 ITEM ITEM PART NUM- ITEM PART NUMBER DESCRIPTION DESCRIPTION PART NUMBER DESCRIPTION 197-232S FOOT 4 PACK 510-528S 8 CH MAIN BAR KIT 540-1215S OVERLAY AND DISPLAY HEATER ASSY, LOWER 510-529S 8CH MAIN TOP BAR KIT...