Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Smithco Spray Star 3182
Summary of Contents for Smithco Spray Star 3182
- Page 1 Operator’s Spray Star 3180 3182 Radion 8140 3184 TeeJet 744 3185/3186 DynaJet/Aeros 3187/3188 DynaJet/Radion 8140 SN: 300G600 June 2020 Product Support: Hwy SS & Poplar Ave; Cameron WI 54822 1-800-891-9435 productsupport@smithco.com...
-
Page 2: Table Of Contents
CONTENTS Introduction ..............1-8 Introduction ..............1 Symbols ..............2 General Safety ............3-6 Specifications ............. 7 Optional Spray Equipment .......... 7 Set Up ................. 8 Operation ..............9-15 Controls & Instruments ........... 9-10 Operation ..............11-12 Tank Agitation ............13 Sprayer Cleaning ............ -
Page 3: Introduction
For more information visit www.P65Warning.ca.gov All Smithco machines have a Serial Number and Model Number. Both numbers are needed when ordering parts. The serial number plate on the Spray Star 3180 is located on top of the frame, between the hydro pump and spray tank. -
Page 4: Symbols
Ground Speed Oil Level Park Brake Park Brake Slow Fast Lift Arm Release No Riders Hydraulic Fluid Hot Surface Moving Parts Pinch Point Penetration 20° MAX Rollover Warning Headlamp Blower Seat Belt Danger Danger Caution PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 5: General Safety
It may also be used to alert against unsafe practices. IMPORTANT: Blue. Indicates procedures which should be followed to avoid damage to the machine. PARTS MANUALS AVAILABLE ONLINE AT smithco.com... - Page 6 25-370 Decal, 88 dBA 15-719 Decal, Speed Control 25-277 Decal, Battery Warning 25-279 Decal, Safety Warning 25-286 Decal, Pinch Point 25-298 Decal, Warning Hot 25-307 Decal, Fuel Only 32-619 Decal, Dash Panel 30-357 Decal, Control Panel PARTS MANUALS AVAILABLE ONLINE AT smithco.com...
- Page 7 17. Stop engine before making repairs/adjustments or checking/adding oil to the crankcase. 18. Use parts and materials supplied by Smithco only. Do not modify any function or part. 19. Use caution when booms are down as they extend out beyond the center line of the machine.
- Page 8 2 0 . If using Simulated Speed with a Radion 8140, one needs to change back to Ground Speed for proper rate control when spraying. PARTS MANUALS AVAILABLE ONLINE AT smithco.com...
-
Page 9: Specifications
30-350 26 Gallon Wash Tank 17-580 20' HD Super Boom 30-375 Foam Marker 30-006 Fresh Water Tank 15-835 Tank Rinse System 30-007 Chemical Cleanload Safe Fill 15-850 Sunshade Canopy 17-622 Drift Reduction Boom Shield PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 10: Setup
SETUP The Spray Star 3180 arrives from Smithco setup and ready for service. Depending on freight conditions bat- tery installed. The spray system is normally shipped attached to the 3180 Prime Mover. If a spray system is to be fitted to a Prime Mover by a dealer or factory, assemble and attach the components in accordance with the parts draw- ings in the Spray Star 3180 Parts/Service Manual. -
Page 11: Operation
Disengage the lever and you will have full accelerator pedal range. Q. Tank Agitation - Allows driver to turn on/off tank agitation without leaving driver seat. PARTS MANUALS AVAILABLE ONLINE AT smithco.com... - Page 12 This will release the brake shaft. Road speeds must not exceed 20 MPH. Re-assemble the disengage cover back to its original way when done towing. Machine is in free wheel mode when towing. Machine has no braking capibilities when being towed. PARTS MANUALS AVAILABLE ONLINE AT smithco.com...
- Page 13 3. Remove the ignition key and engage the park brake. Never leave the vehicle unattended with the engine running. Always bring the vehicle to a complete stop, engage park brake, turn key off and remove key. PARTS MANUALS AVAILABLE ONLINE AT smithco.com...
-
Page 14: Operation
Connect other end of cable (D) to engine block on unit being started (NOT to negative (-) terminal of battery) To prevent damage to other electrical components on unit being started, make certain that engine is at idle speed before disconnecting jumper cables. PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 15: Tank Agitation
Hold one in place and turn the other wrench to loosen assembly. Once apart, clean with wa- ter and check for deteriorating parts. Replace parts as needed by ordering the Spare Parts Kit 20-673-01P. PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 16: Sprayer Cleaning
Located to the right of the control panel. Use lever on compressor to designate which boom is to be used to dis- pense foam. Use dial located on the foamer to adjust pressure for the amount of foam that will be dispensed. Switch on compressor also turns foamer on or off. PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 17: Diagrams
MAIN WIRING DIAGRAM PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 18: Engine Wiring Diagram
ENGINE WIRING DIAGRAM PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 19: Hydraulic Diagram
HYDRAULIC DIAGRAM PARTS MANUALS AVAILABLE ONLINE AT smithco.com... -
Page 20: Reference
Widna tal-Operatur ▪ Dopuszczalny poziom hałasu dla operatora ▪ Nível sonoro nos ouvidos do operador ▪ Nivelul zgomotului la urechea operatorului ▪ Hladina hluku pôsobiaca na sluch operátora ▪ Raven hrupa pri ušesu upravljavca ▪ Nivel sonoro en el oído del operador ▪ Ljudnivå vid förarens öra PARTS MANUALS AVAILABLE ONLINE AT smithco.com... - Page 21 Hyväksyntänumero ▪ Numéro de certificat ▪ Bescheinigungsnummer ▪ Αριθμός Πιστοποιητικού ▪ Hitelesítési szám ▪ Numero del certificato ▪ 300002021-1 Sertifikāta numurs ▪ Sertifikato numeris ▪ Numru taċ-Ċertifikat ▪ Numer certyfikatu ▪ Número do Certificado ▪ Număr certificat ▪ Číslo osvedčenia ▪ Številka certifikata ▪ Número de certificado ▪ Certifikatsnummer PARTS MANUALS AVAILABLE ONLINE AT smithco.com...
-
Page 22: Quick Reference
1.06 Gal 50/50 Antifreeze/water mixture OTHER PARTS 15-818 #75 Fitting O-ring 15-817 #50 Fitting O-ring 16-953 Hinged Cover On Tank with Gasket 16-953-01 Gasket For Cover 16-169 Strainer Basket 20-663 Tank Lid Gasket 20-593 Circuit Breaker 50Amp PARTS MANUALS AVAILABLE ONLINE AT smithco.com... - Page 24 30 days from discovery of the condition. If you need help locating an Authorized Smithco Distributor, or if you have questions regarding your warranty rights or responsibilities, you may contact us at: Smithco Product Support Department 200 West Poplar Ave.
- Page 25 This warranty does not apply to normal “wear and tear” items. Normal “Wear and Tear” includes, but is not limited to, damage to seats due to wear or abrasion, worn painted surfaces, scratched decals or windows, etc. Smithco may require the return of failed parts or components in order to determine the validity of any warranty claim.
Need help?
Do you have a question about the Spray Star 3182 and is the answer not in the manual?
Questions and answers