Daikin VRV IV+ RYYQ14U7Y1B Series Installer And User Manual page 3

RYYQ+RYMQ+RXYQ8~20U7Y1B
VRV IV+ heat pump
4P546228-1B - 2020.10
11.2.5 Symptom: The fan direction does not correspond to the setting................................................................. 44
11.2.6 Symptom: White mist comes out of a unit (Indoor unit) .............................................................................. 45
11.2.7 Symptom: White mist comes out of a unit (Indoor unit, outdoor unit)........................................................ 45
11.2.8 Symptom: The user interface reads "U4" or "U5" and stops, but then restarts after a few minutes.......... 45
11.2.9 Symptom: Noise of air conditioners (Indoor unit)......................................................................................... 45
11.2.10 Symptom: Noise of air conditioners (Indoor unit, outdoor unit) .................................................................. 45
11.2.11 Symptom: Noise of air conditioners (Outdoor unit)...................................................................................... 45
11.2.12 Symptom: Dust comes out of the unit........................................................................................................... 46
11.2.13 Symptom: The units can give off odours ....................................................................................................... 46
11.2.14 Symptom: The outdoor unit fan does not spin.............................................................................................. 46
11.2.15 Symptom: The display shows "88"................................................................................................................. 46
11.2.16 Symptom: The compressor in the outdoor unit does not stop after a short heating operation ................. 46
11.2.17 Symptom: The inside of an outdoor unit is warm even when the unit has stopped.................................... 46
11.2.18 Symptom: Hot air can be felt when the indoor unit is stopped.................................................................... 46
12 Relocation
13 Disposal
14 Technical data
14.1 Information requirements for Eco Design...................................................................................................................... 49
For the installer
15 About the box
15.1 About LOOP BY DAIKIN ................................................................................................................................................... 51
15.2 Overview: About the box ................................................................................................................................................ 51
15.3 To unpack the outdoor unit............................................................................................................................................ 52
15.4 To remove the accessories from the outdoor unit ........................................................................................................ 53
15.5 Accessory pipes: Diameters............................................................................................................................................ 53
15.6 To remove the transportation stay ................................................................................................................................ 54
16 About the units and options
16.1 Overview: About the units and options.......................................................................................................................... 55
16.2 Identification label: Outdoor unit................................................................................................................................... 55
16.3 About the outdoor unit................................................................................................................................................... 56
16.4 System layout.................................................................................................................................................................. 56
16.5 Combining units and options.......................................................................................................................................... 57
16.5.1 About combining units and options............................................................................................................... 57
16.5.2 Possible combinations of indoor units........................................................................................................... 57
16.5.3 Possible combinations of outdoor units ........................................................................................................ 58
16.5.4 Possible options for the outdoor unit ............................................................................................................ 59
17 Unit installation
17.1 Preparing the installation site......................................................................................................................................... 61
17.1.1 Installation site requirements of the outdoor unit........................................................................................ 61
17.1.2 Additional installation site requirements of the outdoor unit in cold climates............................................ 63
17.1.3 Securing safety against refrigerant leaks ....................................................................................................... 64
17.2 Opening the unit ............................................................................................................................................................. 66
17.2.1 About opening the units................................................................................................................................. 66
17.2.2 To open the outdoor unit............................................................................................................................... 66
17.2.3 To open the electrical component box of the outdoor unit ......................................................................... 67
17.3 Mounting the outdoor unit............................................................................................................................................. 68
17.3.1 To provide the installation structure ............................................................................................................. 68
18 Piping installation
18.1 Preparing refrigerant piping ........................................................................................................................................... 70
18.1.1 Refrigerant piping requirements.................................................................................................................... 70
18.1.2 Refrigerant piping insulation.......................................................................................................................... 71
18.1.3 To select the piping size ................................................................................................................................. 71
18.1.4 To select refrigerant branch kits .................................................................................................................... 74
18.1.5 About the piping length.................................................................................................................................. 76
18.1.6 Piping length: VRV DX only............................................................................................................................. 76
18.1.7 Piping length: VRV DX and Hydrobox............................................................................................................. 80
18.1.8 Piping length: VRV DX and RA DX................................................................................................................... 81
18.1.9 Multiple outdoor units: Possible layouts ....................................................................................................... 82
18.2 Connecting the refrigerant piping .................................................................................................................................. 83
18.2.1 About connecting the refrigerant piping ....................................................................................................... 83
18.2.2 Precautions when connecting the refrigerant piping.................................................................................... 84
18.2.3 Multiple outdoor units: Knockout holes ........................................................................................................ 85
Table of contents
47
48
49
50
51
55
61
70
Installer and user reference guide
3