5.7 Osi/Osxi - Volvo Penta 4.3OSi-B Operator's Manual

5.7 OSi/OSXi

Battery size
Bore and stroke
Charging system
Cooling system
Cylinders (number)
Displacement
Firing order
Fuel filter
Fuel filter location
Fuel type
Full throttle operating range
Idle RPM (fixed
Ignition timing
Oil capacity
Engine
Drive unit
Oil filter
Oil filter location
Oil type
Engine
Drive unit
Power steering fluid
Power Trim/Tilt fluid
Spark plugs
Spark plug gap
Spark plug installation torque
12 volt with 650 Cold Cranking Amp (CCA) rating (135 minute reserve
capacity)
CAUTION! Do not use a deep cycle battery as the start battery on fuel-
injected models.
4.000 x 3.480 inches (101.60 x 88.39 mm)
65 amp alternator, with internal transistorized voltage regulator
Variable volume pump on engine
Recirculating pump on engine
Thermostatically controlled temperature
90° V-8
350 cubic inches (5.7 liters)
1 – 8 – 4 – 3 – 6 – 5 – 7 – 2
Volvo Penta P/N 3852413
Refer to photographs on pages 18 through 21.
Inside the U.S.: 89 octane (AKI) unleaded gasoline
Outside the U.S.: 93 octane (RON) unleaded gasoline
OSi: 4600 – 5000 RPM
OSXi: 4600 – 5000 RPM
OSi: 600 RPM
OSXi: 600 RPM
Authorized Volvo Penta dealer service only
Without filter: 5 quarts (4.7 liters)
With filter: 6 quarts (5.7 liters)
XDP: approximately 2.6 quarts (2.5 liters)
Volvo Penta P/N 3850559
Refer to Features pages.
OSi: DuraPlus™ Premium engine oil labeled for API service CE/SG
OSXi: DuraPlus™ Heavy Duty SAE 30 Synthetic motor oil
DuraPlus GL 5 synthetic gear lube
DuraPlus power steering fluid
Same as engine
OSi: Volvo Penta P/N 3861326
OSXi: Volvo Penta P/N 3861326
0.060 inches (1.52 mm)
20 ft. lb. (27 Nm)
67