5.7 Osi/Osxi; Oil Capacity; Oil Type - Volvo Penta 4.3OSi-C Operator's Manual

5.7 OSi/OSXi

Battery size ...................................................... 12 volt with 650 Cold Cranking Amp (CCA) rating (135 minute reserve ca-
Bore and stroke ................................................ 4.000 x 3.480 inches (101.60 x 88.39 mm)
Charging system .............................................. 65 amp alternator, with internal transistorized voltage regulator
Cooling system ................................................ Variable volume pump on engine
Cylinders (number) .......................................... 90° V-8
Displacement ................................................... 350 cubic inches (5.7 liters)
Firing order ....................................................... 1 – 8 – 4 – 3 – 6 – 5 – 7 – 2
Fuel filter .......................................................... Volvo Penta P/N 3852413
Fuel filter location ............................................. Refer to photographs on pages 18 through 21.
Fuel type .......................................................... Inside the U.S.: 89 octane (AKI) unleaded gasoline
Full throttle operating range ............................. OSi: 4600 – 5000 RPM
Idle RPM (fixed ................................................ OSi: 600 RPM
Ignition timing ................................................... Authorized Volvo Penta dealer service only

Oil capacity

Engine .............................................................. Without filter: 5 quarts (4.7 liters)
Drive unit .......................................................... XDP: approximately 2.6 quarts (2.5 liters)
Oil filter ............................................................. Volvo Penta P/N 3850559
Oil filter location ............................................... Refer to Features pages.

Oil type

Engine .............................................................. OSi: DuraPlus™ Premium engine oil labeled for API service CE/SG
Drive unit .......................................................... DuraPlus GL 5 synthetic gear lube
Power steering fluid ......................................... DuraPlus power steering fluid
Power Trim/Tilt fluid ......................................... Same as engine
Spark plugs ...................................................... OSi: Volvo Penta P/N 3861326
Spark plug gap ................................................. 0.060 inches (1.52 mm)
Spark plug installation torque .......................... 20 ft. lb. (27 Nm)
pacity)
CAUTION! Do not use a deep cycle battery as the start battery on fuel-
injected models.
Recirculating pump on engine
Thermostatically controlled temperature
Outside the U.S.: 93 octane (RON) unleaded gasoline
OSXi: 4600 – 5000 RPM
OSXi: 600 RPM
With filter: 6 quarts (5.7 liters)
OSXi: DuraPlus™ Heavy Duty SAE 30 Synthetic motor oil
OSXi: Volvo Penta P/N 3861326
73