Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Orca UVpro EKB 100
Summary of Contents for Orca UVpro EKB 100
- Page 1 Disinfection Box EKB 100 Instruction Manual...
- Page 3 UVC Disinfection Box Dear customer We thank you for choosing a product from orca GmbH. The following instruction manual is intended for your safety in dealing with our product. Before assembling and using this product, please read through the instruction manual carefully in order to avoid dangerous or harmful situations.
-
Page 4: Table Of Contents
CCESSORIES AND REPLACEMENT PARTS WARRANTY ........................18 DISPOSING OF COMPONENTS ..................18 9.1............................... 18 UBES 9.2........................... 18 ALLAST WITH SCREW CONNECTION APPENDIX ........................18 10.1. EG D ........................... 19 ECLARATION OF CONFORMITY orca GmbH www.orcagmbh.de Seite 2 von 20... -
Page 5: Safety Instructions
Decrease or absence of sterilization performance Users, installers, maintenance, and cleaning personnel must be made aware of possible dangers and follow the instruction manual’s instructions. Safety symbols DANGER DANGER ELECTRICAL VOLTAGE DAMAGE VIA UVC RAYS INFORMATION orca GmbH www.orcagmbh.de Seite 3 von 20... -
Page 6: Before Using The Product
The UVpro unit is a UVC sterilization system. Any other usage is improper. No alterations Only orca GmbH may alter the product. Alterations or changes made by anyone else are forbidden. Only original replacement parts are under warranty When replacing parts, only original parts may be used. -
Page 7: Avoiding Danger
There is a possibility of liquid mercury leaking out from broken or damaged tubes. If this happens, please air out the room and dispose of shards, fragments, and tubes in appropriate waste systems. orca GmbH www.orcagmbh.de Seite 5 von 20... -
Page 8: Measurements On Site
Warnings The appropriate warnings (for example “Attention, UVC radiation: Protect eyes and skin”) Must be set up in a place where they are easy to spot before one enters the dangerous area. orca GmbH www.orcagmbh.de Seite 6 von 20... -
Page 9: In Case Of Emergency
UVC rays lead directly to painful information of the cornea and redness of skin. It is possible that the effects only appear after a few hours have passed. In cases of emergency, see a doctor! The same applies to skin burns. orca GmbH www.orcagmbh.de Seite 7 von 20... -
Page 10: Technical Data And Description Of The System
Entkeimungsbox EKB 100 TECHNICAL DATA AND DESCRIPTION OF THE SYSTEM Overview Type UVpro EKB 100 In conformity with requirements EMV, CE, IP52 Material Sheet steel powder-coated, stainless steel: WN 1.4301 & WN 1.4305 Operating temperature [°C] 0...+40 Suitable UVpro tube... -
Page 11: Product Description
- Network, direct 230 V . Securing the connection via a residual current circuit ±10 % breaker (30 mA) is mandatory! orca GmbH www.orcagmbh.de Seite 9 von 20... -
Page 12: Dimensions And Sketch
Entkeimungsbox EKB 100 Dimensions and sketch orca GmbH www.orcagmbh.de Seite 10 von 20... -
Page 13: Installation
In cases of emergency, see a doctor! Installation Information The UVpro EKB 100 was carefully tested before delivery and subjected to a functional check. The high-quality packaging is intended to prevent transport damage, but even with careful handling, damage cannot be completely avoided. -
Page 14: Electrical Connection
After closing the door, the red power switch should be operated. The exposure time can be set with the rotary potentiometer. In case of doubt choose the highest value. The UV radiators will be switched on by pushing the green button. orca GmbH www.orcagmbh.de Seite 12 von 20... -
Page 15: Time Control
3. The number of flashes shows the chosen area (can be still changed by the potentiometer). 4. Press green button again shortly. The pre-selection will be memorized. Area 1 is pre-set in the delivery state and the pre-selection of the potentiometer therefor is ca. 1-8 min. orca GmbH www.orcagmbh.de Seite 13 von 20... -
Page 16: Issues, Cause And How To Fix It
12,000 h. the glass tube. As a rule of thumb, one hour of service life is calculated per ignition. orca GmbH www.orcagmbh.de Seite 14 von 20... -
Page 17: Maintenance
Touch the glass tubes only while wearing gloves. Eyes and skin must be protected from UVC radiation. Please always wear protective goggles, gloves, and covering clothing while working in proximity to UVC tubes. orca GmbH www.orcagmbh.de Seite 15 von 20... -
Page 18: Operating Time Of The Tubes
Frequent switching (> 3 circuits / day) accelerates the aging process considerably Inspect O-rings when changing tubes When changing UVC tubes, check the seals, clean them, and replace them if they are damaged. orca GmbH www.orcagmbh.de Seite 16 von 20... -
Page 19: Maintenance Of The Components
When procuring spare parts please make sure that they are original parts from UVpro or orca GmbH. We also recommend purchasing accessories from UVpro as well. Incorrect use of the equipment, or the use of unauthorized components can lead to health and... -
Page 20: Warranty
Ballast with screw connection The four-channel pipe with the ballast electronics can be recycled using the electrical equipment disposal. APPENDIX orca GmbH www.orcagmbh.de Seite 18 von 20... -
Page 21: Eg Declaration Of Conformity
EG Declaration of conformity EG-Declaration of conformity We hereby declare, orca GmbH, Hungenbach 1D, D-51515 Kürten Tel.: +49(0)2268/90830-0 That the products described below fulfill the essential safety and health requirements of the EC directives in their conception and design as well as in the version which we have placed on the market. In the case of a modification of the product that has not been coordinated with us, this declaration loses its validity. - Page 22 Entkeimungsbox EKB 100 orca GmbH www.orcagmbh.de Seite 20 von 20...
Need help?
Do you have a question about the UVpro EKB 100 and is the answer not in the manual?
Questions and answers