Replacement Parts Information - Mendota DXV45DT4 Installation And Operating Instructions Manual

6.7 REPLACEMENT PARTS INFORMATION

How to Access Components
The descriptions below show where the main fireplaces components are located and how to access them for service. The
descriptions show how to access the components after the fireplace has been installed. All components are also accessible from
the outside of the unit before the fireplace is installed.
Pilot: The pilot light is located on the right side the firebox to the right ends the burners.
Gas Valve: The main gas valve is located behind the lower grill and beneath the firebox.
Complete Valve Assembly: To make working on components easier, this fireplace has been designed with the valve, pilot,
shutter boxes, shutter cables and gas lines as part of one assembly that can be removed from the fireplace. To remove the
assembly first remove burners and burner airbox. After disconnecting the gas line and wires, below the firebox, remove hex nuts
that secure the valve mounting plate to firebox floor. Lift up and remove the entire assembly from the firebox.
Ignition Control Module: The ignition control module is mounted beneath the firebox on the floor. Access to the ignition control
module is available by removing the courtesy panel. The ignition control module is affixed with Velcro to the floor.
Convection Blowers: The convection blowers are mounted on the firebox's rear wall. To access the convection blowers, remove
the Valve Assembly first.
Accent Light: The accent light is mounted in the firebox top center area. The accent light wire harness is run from the light
housing to the left side and then down to the ignition control module.
General Replacement Parts List
PART NO
65-02-00103 GLASS GASKET
65-06-00658 GLASS FLAT
HA-42-00210 DOOR FRAME ASS'Y. – FLAT
35-01-00320 LOG SET
35-01-00239 GLOWING INSWOOL
35-01-00302 FIREBRICK KIT
05-02-00344 885 PROFLAME SIT VALVE
85-03-01114
DESCRIPTION PART NO
05-04-00050
05-04-00052
HA-42-00302
65-14-00038
65-14-00044
65-14-00053
65-14-00364
DXV45DT4
DESCRIPTION
PILOT ASS'Y. NAT.
LP PILOT ORIFICE
LP KIT
REAR ORIFICE (Nat. Gas) # 38
FRONT ORIFICE (NAT. Gas) # 44
REAR ORIFICE (LP Gas) # 53
FRONT ORIFICE (LP Gas) # 3/64
Page 90