Subscribe to Our Youtube Channel
Related Manuals for Spudnik 930 ELIMINATOR
Summary of Contents for Spudnik 930 ELIMINATOR
- Page 1 OWNER / OPERATOR & PARTS MANUAL 930 ELIMINATOR CUSTOM ELIMINATOR SERIAL # 930-55-172 Revision: 6/13/17...
- Page 3 Service Centers Phone: (208) 785-0480 E-Mail: spudnik@spudnik.com Web Site: www.spudnik.com BLACKFOOT, ID (Corporate Headquarters) 584 West 100 North P.O. Box 1045...
-
Page 4: Table Of Contents
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Table Of Contents Introduction ..............................iii Foreword ..............................iv Warranty ..............................v General ..............................vi Product Characteristics ..........................vii 1. Safety Exemption from Liability ......................1 Warning Symbols and other Instruction Notices ................ -
Page 5: Introduction
We strive to put the best quality and workmanship into each of our machines, and hope as you use your SPUDNIK 930 ELIMINATOR, that you will find this to be true. This manual has been prepared to aid you in the safe operation and service of your machine. -
Page 6: Foreword
ANUAL Foreword This manual is intended to familiarize the user with the SPUDNIK 930 ELIMINATOR and its designated use. This manual contains important information on how to operate the machine safely, properly, and efficiently. Observing the instructions in this manual help to avoid dangers, reduce repair costs and down-times, and to increase the reliability and service life of the machine. -
Page 7: Warranty
The selling dealer has no authority to make any representation or promise on behalf of Spudnik, or to modify the terms or limitations of this warranty in any way. -
Page 8: General
Particular attention should be paid to the section entitled “Safety”. And instructions which are not understood must be clarified before initial operation of the machine. In such cases, please consult your SPUDNIK agent or contact us directly. -
Page 9: Product Characteristics
SPUDNIK representative. Original spare parts and accessories approved by SPUDNIK are a contribution to safety and overall performance of the machine. The use of other parts may invalidate the liability of SPUDNIK for any consequences arising from such use. Please refer to the ‘Limited Warranty Policy for New Spudnik Machinery’ section and ‘General’... -
Page 10: Safety
CAUTION: Indicates that unsafe practices, which could SPUDNIK shall not be liable for any damage to agricultural result in personal injury if proper precautions are not taken. produce and other items, which occur as a result of operating and adjustment errors or others incorrect usage. -
Page 11: Identification Of Important Instruction
16. Replace all worn or missing bolts with SAE Grade 5 or better SPUDNIK shall not be liable for any damage caused by the unless specifically stated otherwise. use of parts, accessories, and ancillary equipment not Non-observance of the safety and accident prevention supplied and/or approved by SPUDNIK. -
Page 12: Operating Safety Practices
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-1 Safety 1.6 Operating Safety Practices 1.7 Electrical System and Electronics Empty machinery of product before moving. This will lessen Use only original fuses with the specified current rating. the chance of damaging the equipment and make it easier to Switch off the machine immediately if a fault occurs in the move. -
Page 13: Maintenance And Inspection Guidelines
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-1 Safety 1.8 Maintenance and Inspection Guidelines The securing of loads and the instruction of crane To prevent accidents, all relevant rules and regulations concerning safe and competent working must be observed. operators should only be entrusted to experienced persons. -
Page 14: Acknowledgement Signature
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-1 Safety 1.9 Acknowledgement Signature Anyone who will operate and/or maintain the equipment must read and clearly understand ALL Safety, Operating and Maintenance information presented in this manual. Do not operate or allow anyone else to operate this equipment until such information has been reviewed. -
Page 15: Machine Overview
If stickers and labels become illegible or destroyed, replace them as soon as possible by contacting your local Spudnik dealer. To install labels; Clean and dry the surface area that label will be installed. -
Page 16: Operation
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-3 Operation 3.1 Initial Set-up Position eliminator squarely to system feeding eliminator. Adjust the eliminator to the required height to reduce drop. Any equipment that receives product from the eliminator needs to be adjusted up close to the discharge chute. This will help reduce bruising of the potatoes. -
Page 17: Maintenance
Oil in gearboxes must be checked every 100 hours of operation. Level should be to parting line of gearbox. Use 80W90 gear oil (Spudnik p/n: 991214) Oil should be changed when it becomes dirty and/or contaminated. 4.3 Drive Chains ... -
Page 18: Cleaning And Storage
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-5 Cleaning and Storage 5.1 Cleaning after every operation 5.3 Storage of the machine In order to keep wear down to a minimum, follow the instructions Perform the actions described above. given below: ... -
Page 19: Parts Manual
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-6 Parts Manual SERIAL# 930-55-172 Revision: 6/13/2017... - Page 20 930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-6 Parts Manual SERIAL# 930-55-172 Revision: 6/13/2017...
-
Page 21: 822144 - Shft,Elim,48"6 Pnt Fngr Hf A&Bcomplete
930 E & P LIMINATOR WNER PERATOR ARTS ANUAL Section-6 Parts Manual SERIAL# 930-55-172 Revision: 6/13/2017... -
Page 22: Miscellaneous Guidelines And Specifications
The torque charts below are for reference purposes only and its use by anyone is voluntary unless otherwise noted in this manual. Reliance on the torque charts below are at the sole risk of that person. Spudnik is not responsible for any loss claim or damage arising from following the reference torque specifications in these torque charts. - Page 23 930 E & P LIMINATOR WNER PERATOR ARTS ANUAL NOTES SERIAL# 930-55-172 Revision: 6/13/2017...
- Page 24 584 West 100 North P.O. Box 1045 Blackfoot, ID 83221 Phone (208) 785-0480 Fax (208) 785-1497 www.spudnik.com...
Need help?
Do you have a question about the 930 ELIMINATOR and is the answer not in the manual?
Questions and answers