Huffy In-Ground Basketball System with Elevator Owner's Manual

A Huffy Company
In-Ground Basketball System with Elevator
SAFETY INSTRUCTIONS
FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT
IN SERIOUS INJURY, PROPERTY DAMAGE AND
WILL VOID WARRANTY.
Owner must ensure that all players know and
follow these rules for safe operation of the system.
To ensure safety, do not attempt to assemble this system without
following the instructions carefully. Proper and complete assembly, use
and supervision is essential for proper operation and to reduce the risk of
accident or injury. A high probability of serious injury exists if this system
is not installed, maintained, and operated properly. Check entire box and
inside all packing material for parts and/or additional instructional
material. Before beginning assembly, read the instructions and identify
parts using the hardware identifier and parts list in this document.
• If using a ladder during assembly, use extreme caution.
• Two (2) people are recommended for this operation.
• Seat the pole sections properly. Failure to do so could allow the
pole sections to separate during play.
• Before digging, contact utility company to locate underground
power cables, gas, and water lines. Ensure there are no overhead
power lines within 20 ft. (7 m) radius of pole location.
• Climate, corrosion, excessive use, or misuse could result in system
failure.
• If technical assistance is required, contact Huffy Sports.
• Minimum operational height is 6' 6" (1.98 m) to the bottom of
backboard.
• This equipment is intended for home recreational use only and NOT
excessive competitive play.
• Read and understand the warning label affixed to pole. Label is
shown on page 1.
• The life of your basketball pole depends on many conditions. The
climate, placement of the pole, the location of the pole, exposure to
corrosives such as pesticides, herbicides or salts are all important.
• Adult supervision is recommended when adjusting height.
• Serious injury could occur if teeth/face come in contact with
backboard, net, or rim.
Most injuries are caused by misuse and/or not following instructions.
Use caution when using this system.
For more information on assembly, placement, proper use and
maintenance, visit The American Basketball Council website at
http://www.smarthoops.com.
Toll-Free Customer Service Number for U.S: 1-800-558-5234, For Canada: 1-800-284-8339, For Europe: 00 800 855 85234 (Sweden: 009 555 85234),
Owner's Manual
REQUIRED TOOLS AND
MATERIALS:
• Two People
• Tape Measure
• Tape
• Shovel and Spade
• Concrete, 540 lb (245 kg)
Minimum and Container to Mix
• Carpenter's Level
• Wood Board (Scrap)
• Step Ladder 8 ft. (2.4 m)
• Wrenches: (Two) 7/16", 1/2",
9/16", 3/4" or two Large and
Small Adjustable Wrenches
• Sawhorse or Support Table
• Safety Goggles
• Hammer
• Wedge
• Phillips Head Screw Driver
For Australia: 1-800-333 061 - Internet Address: http://www.huffysports.com
WRITE IN YOUR
___________
MODEL NUMBER:
IMPORTANT
In U.S. and Canada only:
Have questions?...don't
go back to the store!
We appreciate your purchasing
one of our many fine products.
We are sure that you will be very
satisfied with your selection.
Although great care and effort
have been taken, occasionally
problems may occur. To ensure
prompt and correct handling of
any problems, or to answer any
questions, please contact our Toll-
Free Customer Service Number
listed below. Service will be
quicker if you have your Model
Number (found on carton) and
assembly instructions ready
when calling. PLEASE WRITE
YOUR MODEL NUMBER IN THE
SPACE PROVIDED ABOVE.
45
HEIGHT ADJUSTMENT
TO ADJUST BACKBOARD:
3
1. Grasp handle and depress lever.
2. Push toward pole while holding
lever. Raise or lower to desired
height while pushing forward on
handle.
2
3. Release handle making sure that
horizontal pin is locked into slot.
1
201247 2/99
Customer Service Center
N53 W24700 South Corporate Circle
Sussex, WI 53089
U.S.A.
WARNING
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT
IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow
these rules for safe operation of the system.
• DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
• During play, especially when performing dunk type
activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.
• Do not slide, climb, shake or play on pole.
• When adjusting height, keep hands and fingers away from
moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,
etc.). Objects may entangle in net.
• Keep organic material away from pole base. Grass, litter,
etc. could cause corrosion and/or deterioration.
• Check pole system for signs of corrosion (rust, pitting,
chipping) and repaint with exterior enamel paint. If rust
has penetrated through the steel anywhere, replace the pole
immediately.
• Check system before each use for proper ballast, loose
hardware, excessive wear and signs of corrosion and repair
before use.
• Check system before each use for instability.
• Never play on damaged equipment.
• Keep pole top covered with cap at all times.
• See instruction manual for proper installation.
In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339
201240 2/99