LG LV120HCV Installation Manual

LG LV120HCV Installation Manual

Single zone vertical air handling unit - cv
Table of Contents

Advertisement

Quick Links

SINGLE ZONE
VERTICAL AIR HANDLING UNIT - CV
INSTALLATION MANUAL
LV120HCV (12,000 Btu/h)
LV180HCV (18,000 Btu/h)
LV240HCV (24,000 Btu/h
LV300HCV (30,000 Btu/h)
12,000 - 30,000 Btu/h

Advertisement

Table of Contents
loading

Summary of Contents for LG LV120HCV

  • Page 1 SINGLE ZONE VERTICAL AIR HANDLING UNIT - CV INSTALLATION MANUAL LV120HCV (12,000 Btu/h) LV180HCV (18,000 Btu/h) LV240HCV (24,000 Btu/h LV300HCV (30,000 Btu/h) 12,000 - 30,000 Btu/h...
  • Page 2 For continual product development, LG Electronics U.S.A., Inc., reserves the right to change specifications without notice. ©LG Electronics U.S.A., Inc. This document, as well as all reports, illustrations, data, information, and other materials are the property of LG Electronics U.S.A., Inc.
  • Page 3: Table Of Symbols

    Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 4 There is a risk of equipment damage. water leakage. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 5 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 6 Do not block the inlet or outlet. Unit may malfunction. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 7: Table Of Contents

    Bundling and Cutting Line ..............40 Insulation ....................42 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 8: General Data

    T = Thermostat Compatible CV = Lite Generation: Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 9: Specifications

    -4°F using the Low Ambient Wind Baffle Kit (sold separately). Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 10 6 12k, 18k, and 24k VAHUs are supplied with socket adapters for pipe transitions. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 11: Electrical

    RLA = Rated Load Amps. down to the nearest standard fuse size. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 12: General Installation Guidelines

    Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 13 4. In an area in which condensate does not drain properly. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 14: Oceanside Applications

    Building Sea wind Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 15: Required Outdoor Unit Clearances

    Standard Case 4 Minimum Standard Case 5 Minimum Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 16 Figure 5: Close up of Bolt Attachment. Anchor Bolt 13/16 Unit: Inch Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 17 6. Seal all wiring and piping access holes to prevent insects from entering the Bolt Bolt unit. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 18: Required Indoor Unit Clearances

    Service More than Unit : inch 13-25/32 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 19 • Go to the Electrical Connections section of this manual for information on conduit / electrical wiring to the indoor unit. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 20: Horizontal Right Installation

    Figure 12: Install Pan on Right. Figure 13: Replace Panels. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 21: Vertical Downflow Installation

    Figure 16: Evaporator Coil/ Drain Pan Assembly. Rotated Horizontal 180° Drain Pan Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 22 Figure 21: Reinstall Coil Assembly. Evaporator Sensor Coil/Drain Wiring Pan Assembly Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 23 Figure 25: Reinstall Sensors. Figure 26: Reinstall Panels. Sensors panel Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 24: Installing Ductwork

    Figure 28: Securely Fasten Supply Duct. More than 10 screws (M4*25L) Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 25: Refrigerant Safety Standards / Device Connection Limitations

    Additional Refrigerant Needed (oz/ft) 0.21 0.43 Due to our policy of continuous product innovation, some specifications may change without notification. © INTRODUCTION | 25 LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 26: Selecting Field Supplied Piping

    Always follow local codes when selecting and installing copper pipe and piping system components. Approved piping for use with LG Single Zone products will be marked “R410 RATED” along the length of the pipe. Piping wall thickness must meet local code requirements and be approved for a maximum operating pressure of 551 psi. When bending piping, try to keep the number of bends to a minimum, and use the largest radii possible to reduce the equivalent length of installed piping;...
  • Page 27: Copper Expansion And Contraction

    4. Calculate the difference in the two expansion distance values. The result will be the change in pipe length. Due to our policy of continuous product innovation, some specifications may change without notification. © INTRODUCTION | 27 LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 28 L = Centerline Minimum Radius (inches). Due to our policy of continuous product innovation, some specifications may change without notification. © 28 | INTRODUCTION LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 29: Piping Handling

    1 hour Due to our policy of continuous product innovation, some specifications may change without notification. © INTRODUCTION | 29 LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 30: Refrigerant System Engineering

    Failure to do so may cause significant performance degradation. Proper leak checks must be performed. Using isolation valves does not automatically void any LG product warranty, however, a limited warranty may be voided in whole or part must any field supplied accessory fail in any way that causes product failure.
  • Page 31 ~ 12" – 19" Due to our policy of continuous product innovation, some specifications may change without notification. © INTRODUCTION | 31 LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 32 Pipe Sleeves at Penetrations LG requires that all pipe penetrations through walls, floors, and pipes buried underground be properly insulated and routed through an appropriate wall sleeve of sufficient size to prevent compression of refrigerant pipe insulation and free movement of the pipe within the sleeve.
  • Page 33: Flaring And Brazing Procedures

    ~ 19.7 (49/64 - 25/32) 15.88 19.05 Due to our policy of continuous product innovation, some specifications may change without notification. © INTRODUCTION | 33 LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 34 Do not braze in an enclosed location, and always test for gas leaks before / after brazing. There is risk of fire, explosion, and physical injury or death. Due to our policy of continuous product innovation, some specifications may change without notification. © 34 | INTRODUCTION LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 35: Refrigerant Piping Connections

    Always include plenty of insulation on all refrigerant and drain piping to ensure condensate does not form and cause damage to walls, floors, etc. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 36: Directional Pipe Formation

    Drainage from the Indoor Units Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 37: Outdoor Unit Connections

    15.88 45.4 - 59.3 19.05 71.5 - 87.5 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 38: Indoor Unit Connections

    Do not block the outlet side Auxiliary valve Tape Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 39: Drain Hose

    Drain Hose Ai r Indoor Unit Water Waving leakage Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 40: Bundling And Cutting Line

    Drain hose Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 41 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 42: Insulation

    3/8 inch thick EPDM insulation that is plenum-rated with a heat-resistance factor of more than 248°F. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 43: Electrical System Installation

    Failure to properly provide a National Electrical Code-approved earth ground can result in property damage and equipment malfunc- tion. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 44: Power Wiring Specifications And Best Practices

    Do not include splices or wire nuts in the communication cable. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 45 Failure to properly provide a NEC approved earth ground can result in property damage and equipment malfunction. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 46 • Never use a common multiple-core communications cable. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 47: Wall Controller Installation

    Wired Controller Connections Controllers can connect to the indoor unit in one of two different ways. 1. LG Wired Remote Extension Cable with Molex plug (PZCWRC1; sold separately) that connects to the CN-REMO terminal on the indoor unit PCB. 2. Field-supplied controller cable that connects to the indoor unit terminal block (must be at least UL2547 or UL1007, and at least FT-6 rated if local electric and building codes require plenum cable usage).
  • Page 48: External Static Pressure Setting / Installer Mode

    3 seconds to exit installer setting mode. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 49: Third Party Thermostat

    When connecting the thermostat, please refer to the thermostat manual. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 50: Indoor Unit Electrical Connections

    Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 51: Optional Electric Heater For Idu

    Terminal Block Relay Heater Cable If a Third-Party Dry Contact and an LG internal heater or an LG Auxiliary Heat Kit is installed, supplemental heat capability cannot be controlled by the Third-PartyThermostat. Table 18: Electric Heater Capacities. Model Number / Heater Capacity Indoor Unit Model No.
  • Page 52: Outdoor Unit Electrical Connections

    Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 53: Electrical System Installation

    Wiring Diagram for LVN120HCV, LVN181HV4, LVN241HV4, LVN300HCV Figure 74: Indoor Unit Wiring Diagram. 7.19 Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 54: Outdoor Unit Wiring Diagram Lvu120Hcv, Lvu180Hcv, Lvu240Hcv, Lvu300Hcv

    *This function can be optional or factory installed depending on the application model. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 55: Nj Wiring Diagrams Legend

    Auxiliary Heater Relay Kit Auxiliary Heater Relay Kit Second stage heat Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 56: Nj Chassis Dip Switch Settings

    • SW5 OFF: Fan discontinuous operation. There would be reduction in heating capacity while defrosting or oil return operation. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 57: Final Installation Procedures

    Gas (Vapor) Service Port and cause product malfunction. Outdoor Unit Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 58: Triple Leak / Pressure And Evacuation Procedures

    Schrader ports (with core removed) using a vacuum hose. Open the gauge manifold and the vacuum pump valves. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 59: Triple Evacuation Procedure

    13. Shut the valve before turning off and disconnecting the vacuum pump. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 60: Trim Charge, Test Run

    Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 61: Pump Down, Cooling Only Mode

    • Entire lock or Mode lock cannot be set if you set heating or automatic operation through the central controller. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 62: Troubleshooting

    Outdoor brushless direct current (BLDC) fan motor lock error Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 63 Outdoor brushless direct current (BLDC) fan motor lock error Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 64: Cautions For Refrigerant Leaks

    ASHRAE Standard 15-2010 / 34-2010 and addenda current as of the date of this publication. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 65: Installation Checklist

    Power to outdoor unit and power/communications to indoor unit CANNOT be run in the same conduit. Due to our policy of continuous product innovation, some specifications may change without notification. ©LG Electronics U.S.A., Inc., Englewood Cliffs, NJ. All rights reserved. “LG” is a registered trademark of LG Corp.
  • Page 66 20001747 ISO 9001: 2008 LG ELECTRONICS INC. For further technical materials such as submittals, engineering manuals, service manuals, and catalogs, visit www.lghvac.com. LG Electronics, U.S.A., Inc. Commercial Air Conditioning Division 4300 North Point Parkway Alpharetta, Georgia 30022 IM_SZ_VAHU_CV_03_23 www.lg-vrf.com...

Table of Contents