Summary of Contents for SafeWaze NORTHSTAR CLASSIC SRL
Page 1
OSHA 1910.140, 1910.66, 1926.502 SRL Instruction Manual This manual is intended to meet the manufacturer’s instructions as required by ANSI Z359.14-2021 and should be used as part of an employee training program as required by OSHA. Copyright Safewaze 2022 220-00084...
TABLE OF CONTENTS INTRODUCTION ..................5 APPLICATION ..................5 APPLICABLE SAFETY STANDARDS ............ 5 WORKER CLASSIFICATIONS ............... 6 TRAINING ....................6 LIMITATIONS AND REQUIREMENTS ........... 6 INSPECTION FREQUENCY ..............7 PURPOSE ....................7 SPECIFICATIONS .................. 7 10.0 ACTUAL ARREST DISTANCE/MIN REQUIRED FALL CLEARANCE ...8-9 11.0 SWING FALLS ..................
Page 3
Use of this equipment for any other purpose, such as material handling, sports activities, or other action not described in these User Instructions is not approved by Safewaze. Use of this equipment in a manner outside the scope of those covered within this Manual can result in serious injury or death.
1.0 INTRODUCTION Thank you for purchasing a Safewaze Self Retracting Lifeline (SRL). This manual must be read and understood in its entirety and used as part of an employee training program as required by OSHA or any applicable state agency. This manual and any other instructional material must be provided to the user(s) of the equipment.
Free Fall: Safewaze SRLs when used correctly with the unit anchored directly overhead and no slack in the lifeline, will limit the free fall distance to 0 ft. (0 m). In order to limit free fall distances, keep attachment of the SRL below Dorsal D-ring height to as minimal a distance as possible. Safewaze Northstar Classic SRLs are not designed to allow for foot level tie-off.
Safewaze SRLs are authorized for use with Horizontal Lifeline Systems but must NEVER be used as the lifeline constituent of an HLL System. Safewaze Class 1 SRLs must be used in overhead applications only and are not authorized for use below the Dorsal D-ring.
10.0 ACTUAL ARREST DISTANCE / MINIMUM REQUIRED FALL CLEARANCE Personal Fall Arrest: Safewaze Class 1 SRLs can be used as part of a complete Personal Fall Arrest System (PFAS) for a maximum of one user. Only one user may be connected to an SRL. Avoid sharp and/or abrasive edges. If contact with an abrasive surface is unavoidable, proper edge protection must be used. The structure utilized for attachment must be capable of withstanding a load of 5,000 lbs.
Page 9
Arrest Distance of 42 in. Fall Clearance calculations may vary dependent upon the SRL being used. It is essential that the correct Arrest Distance is used to determine Minimum Required Fall Clearance. FIGURE 2 - EXAMPLE MINIMUM REQUIRED FALL CLEARANCE CALCULATION (CLASS 1 SRL) Northstar Classic SRL Minimum Required Fall Clearance OSHA 1910.66, OSHA 1926.502 ANSI Z359.14, ANSI A10.32 ANSI Z359.14, ANSI A10.32 OSHA 1910.66, OSHA 1926.502...
Table 9 provides the ability for the user to determine additional fall clearance requirements if a Swing Fall Hazard is present when using the a Northstar Classic SRL in an overhead application. The Y-Axis represents the height the SRL is anchored above the user’s Dorsal D-ring.
During normal operations, the lifeline constituent of the SRL will extend and retract freely with no slack or hesitation as the worker moves at normal speeds. In the event of a fall, Safewaze SRLs are equipped with a speed sensing braking system. The braking system will activate, stopping the fall, and absorbing much of the energy created by the fall.
Consult your doctor if there is reason to doubt your fitness to safely absorb the shock from a fall arrest. Age and fitness seriously affect a worker’s ability to withstand falls. Pregnant women or minors must not use Safewaze SRLs. Failure to heed this warning may result in serious injury or death.
18.2 SERVICE Only Safewaze or entities authorized in writing by Safewaze, shall make repairs to this equipment. Remove the SRL from use if the SRL has been subjected to fall arrest forces or has been used to affect a rescue. If unrepairable dispose of the SRL as recommended in Section 19. For questions regarding disposal, service, or repair of Safewaze SRLs, contact Safewaze at (800) 230-0319.
19.4 DISPOSAL Dispose of the Safewaze SRL if it has been damaged by fall arrest forces or inspection reveals an unsafe or defective condition that cannot be repaired by an authorized Safewaze Service Center. Before disposing of the SRL, cut the lifeline in half so that it is not mistakenly reused. For questions regarding disposal, service, or repair of Safewaze SRLs, contact Safewaze at (800) 230-0319.