Page 1
Alterations to this product, misuse of this product, or failure to follow instructions may result in serious injury or death. IMPORTANT Questions regarding the use, care, or suitability of this equipment for your application? Contact SAFEWAZE™. IMPORTANT Record identification information before using this product. Identification information may be found on the equipment label (see figure 8).
Page 2
Table 1 illustrates the connector options available for our 019-5000 Retractable series when ordered in a Single Leg configuration. Table 2 on page 3 illustrates the connector options available for the 019-5000 series when ordered in a Dual Leg configuration.
Page 3
1.1 Purpose SAFEWAZE™ 019-5000 series SRL’s are designed for use in environments where a fall could occur. The purpose is to prevent the fall or limit the potential free fall as much as possible. Applications include, but are not limited to: roofing, concrete, steel, MEP, industrial maintenance, and material handling.
When installing or using this equipment always refer to the following requirements and limitations: 2.1 Capacity SAFEWAZE™ 019-5000 series Self Retracting Lanyards (SRL’s) are all designed in compliance with ANSI Z359.14 to meet the weight capacity range of (130-310 lbs), OSHA up to 420 lbs (190.51 kg).
Page 5
The SRL must be used with a Full Body Harness. Connection to the Full Body Harness must be made at the Dorsal D-ring. SAFEWAZE™ 019-5000 series SRL’s are not rated for use with a body belt. Use of SAFEWAZE™ 019-5000 series SRL’s with a body belt may result in injury.
Page 6
FALLSAFE USA 2.14 COMPATIBILITY OF COMPONENTS Unless otherwise noted, SAFEWAZE™ equipment is designed for use with SAFEWAZE™ approved components and subsystems only. Substitutions or replacements made with non approved components or subsystems may jeopardize compatibility of equipment and may affect safety and reliability of the complete system.
Snap hooks and carabiners used with this equipment must be double locking and/or twist lock. Carabiners supplied for use with SAFEWAZE™ 019-5000 Series are available in forged steel or aluminum. Both carabiners are double locking. Ensure all connections are compatible in size, shape and strength. Do not use equipment that is not compatible. Ensure all connectors are fully closed and locked.
Page 8
(A) and slide lock (B), which allows bracket to swing open without complete removal from harness. FIGURE 5 - 9013 DUAL BRACKET INSTALLATION Bar assembly of bracket which inserts behind Locking Button (A) webbing at dorsal D-ring Slide Lock (B) Curved Portion of 9013 Dwg. 1 Dwg. 2 Page 8 V1.1 2019 Copyright SAFEWAZE™...
WARNING: fall arrest. Age and fitness seriously affect a worker’s ability to withstand falls. Pregnant women or minors must not use SAFEWAZE™ SRL’s. Failure to heed this warning may result in serious injury or death. 4.1 OPERATION Inspect the SRL, as described in section 8, before using the equipment. Refer to Figure 6 for the most common system connections used with SRL applications.
4.4 SYSTEM CONNECTIONS Figure 6 illustrates harness and anchorage connections for SAFEWAZE™ SRL Fall Arrest Systems. When using a snap hook to make a connection, ensure roll-out cannot occur (see figure 2). Do not use snap hooks or carabiners that will not completely close over the anchor point.
Page 11
4.6 DUAL LEG SAFEWAZE™ SRL With the dual leg version of the SAFEWAZE™ 019-5000 series SRL mounted on the back of a Full Body Harness, the user can have continuous fall protection (100 % tie-off) while ascending, descending, or moving laterally (see figure 7 With the lifeline leg of one SRL attached to an anchorage point, the worker can move to a new location, attach the unused lifeline leg of the other SRL to another anchorage point, and then disconnect from the original anchorage point.
Page 12
SRL passes inspection, it may remain in service. 8.5 DISPOSAL Dispose of the SAFEWAZE™ 019-5000 series SRL if it has been damaged by fall arrest forces or inspection reveals an unsafe or defective condition that cannot be repaired by an authorized SAFEWAZE™ Service Center. Before disposing of the SRL, cut the web lifeline in half so that it is not mistakenly reused.
Page 13
Swivel Top Snaphook Hinge Labeling Gate Cover Energy Load Impact Absorber Indicator Hook Nose Hook Body Hinge Gate Hook Nose FIGURE 10 - EXAMPLES OF EQUIPMENT DAMAGE Webbing Damage Examples Frayed Heavily Soiled Welding Burns Page 13 V1.1 2019 Copyright SAFEWAZE™...
Page 14
This Page Intentionally Left Blank Page 14 V1.1 2019 Copyright SAFEWAZE™...