Hyundai HL960A Operator's Manual page 232

11) 11) FUEL TANK FUEL TANK
(1)
Fill fuel fully when system the operation to mini-
mize water condensation, and check it with fuel
gauge before starting the machine.
(2) Drain the water and sediment in the fuel tank by
opening the drain cock.
※
Be sure to LOCK the cap of fuel tank.
※
Remove the strainer of the fuel tank and clean
it if contaminated.
Stop the engine when refueling. Stop the engine when refueling.
All lights and flames shall be kept at a safe All lights and flames shall be kept at a safe
distance while refueling. distance while refueling.
12) 12) PREFILTER PREFILTER
※
Inspect or drain the collected water daily and Inspect or drain the collected water daily and
replace the element every 1000hours. replace the element every 1000hours.
(1) (1) Drain water Drain water
①
Open the drain valve to evacuate water for 10
seconds.
②
Close drain valve.
※
Do not use tools. Do not use tools.
※
Don't tighten up a drain valve so strong. Don't tighten up a drain valve so strong.
(2) (2) Replace element Replace element
①
Loosen the air vent plug and drain the unit of
fuel. Follow "Drain water" instructions above.
②
Remove the drain pipe and WIF sensor from fil-
ter body.
③
Remove the filter body from filter head.
④
Pre-fill a new filter body with fuel and lubricate a
gasket on the new filter body.
⑤
Install the filter on the filter head. Tighten the fil-
ter until the gasket contacts the filter head sur-
face. Tighten the prefilter an additional 3/4 turn
after contact.
⑥
Connect the drain pipe and WIF sensor to filter
body.
Cap
Strainer
Drain plug
Air vent plug
Filter head
Drain Valve
6-25
760F6MI13
Lift pump
Filter body
WIF sensor
Drain pipe
300A6MA48A