Roof Insert - Panorama Sunroof: Cleaning And Lubricating - Audi A8 2010 Maintenance Manual

3.25 Roof insert - panorama sunroof: clean‐
ing and lubricating
WARNING
Risk of injury as engine of high-voltage vehicle can start un‐
expectedly!
♦ Observe warnings for high-voltage system:
♦ For work that must be performed with the ignition switched
on ⇒ page 11 .
Special tools and workshop equipment required
♦ Spray-on grease - G 060 751 A3-
♦ Lubricating paste - G 060 751 A2-
♦ Krytox lubricating paste - G 052 141 A2-
♦ Cleaning solution - D 009 401 04-
♦ Industrial vacuum cleaner, e.g. wet/dry vacuum cleaner - VAS
5128-
♦ Commercially available paintbrush: approx. 15 mm wide and
bent by approx. 40° using workshop equipment
♦ Fine-pored sponge (e.g. a piece of household sponge without
a scouring surface)
Cleaning and lubricating the roof insert is a repair measure and
should be charged separately.
Protect vehicle interior from becoming dirty.
Step 1 - cleaning and lubricating slotted guide for glass panel:
– Open sunroof sun blind completely.
– Open glass panel completely.
– Remove grease and dirt from slotted guide with a lint-free
cloth.
– Use a paintbrush to lubricate inside of slotted guide for glass
panel -arrows- with lubricating paste - G 060 751 A2- .
– Remove surplus lubricant from slotted guide with a lint-free
cloth.
– Repeat procedure on opposite side of vehicle.
Step 2 - cleaning and lubricating guide rails:
Glass panel opened completely.
– First use an industrial vacuum cleaner to remove any loose
residue from guide rail.
– Remove grease and dirt from guide rail with a lint-free cloth.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Audi A8 2010 ➤
Maintenance - Edition 11.2014
3. Maintenance
55