TRAPP TR 200 Instruction Manual page 33

www.trapp.com.br
Warning!
All maintenance and cleaning should be
made with the equipment switched off and
the spark plug wire disconnected.
The air filter shall be always clean for the engine to
work perfectly.
Blocking of the filter due to lack of cleaning causes
serious operating problems for the engine, among
them loss of power, and damage to the cylinder,
piston and piston rings.
In the first 5 hours
Change the oil of the crankcase

Every 8 hours or daily
Check the oil level

Clean the area around the muffler and the controls

Clean the protective screen

Every 25 hours or annually
Clean the air filter*

Clean the pre-purifier*

Every 50 hours o annually
Change the engine oil

Check the muffler and spark arrester

Annually
Replace the oil filter

Replace the pre-purifier

Replace the spark plug

Replace the fuel filter

Clean the air cooling system*

* In very dusty places or when particles brought by the air are present, clean more frequently.
Air Filter - TR 200G
Periodic Maintenance Plan of
Combustion Engine - TR 200G
Air filter - foam
Dip and tighten (do not twist) it in a solution of

neutral detergent water, removing all the dirt.
Dry it, rolling and pressing it in a dry cloth (do not

twist it).
Moisten the filter slightly with clean oil (20W-50),

always pressing it to distribute the oil equally,
removing the excess.
Air filter - paper
Pass compressed air from inside to outside the filter

or knocking its base lightly against a flat surface.
33