Truck Bed Operation; Load Bed (P/N 74821G01); Dumping The Truck Bed - Cushman HAULER 1200X EFI 2019 Owner's Manual

TRUCK BED OPERATION

Failure to follow these instructions can cause personal injury, damage the vehicle or
cause the vehicle to tip over. Be aware of the load when operating the vehicle. Read,
understand and follow the warning label attached to the front of the truck bed.
Do not allow passengers to ride in the truck bed. A sudden move or stop can cause
severe injury or death to passengers in the truck bed.
Before operating, make sure the area behind the vehicle is clear.

Load Bed (P/N 74821G01)

WARNING
READ THE MANUAL
A truck bed warning label is attached to the inside front of the truck bed. Understand and comply with the warnings on
this label for safe operation of the vehicle.
• See the truck bed warning label for maximum load.
• Position the load in the truck bed as far forward as possible.
• Make sure the center of gravity of the load is within the height limit shown on label.
• Secure the load to the truck bed.
• Be aware of the load when you operate the vehicle.
• Do not allow passengers to ride in the truck bed. Do not drive the vehicle with the truck bed lifted or with the tailgate
unsupported.
Never fill a gas container in the truck bed. Static discharge can ignite gasoline vapor and
cause an explosion.
Always put the gasoline container on the ground before filling. Never fill a gasoline container in the truck bed. Static
electricity is built up during the fueling process and can discharge and cause the gasoline vapor to ignite.

DUMPING THE TRUCK BED

If the bulk of the cargo weight is at the rear of the bed, the bed may unexpectedly dump
when the release lever is pulled and cause serious injury to anyone close by. Never pull
the release lever unless the load is positioned evenly or located at the front of the truck
bed.
Never leave the truck bed in the upright position after emptying the cargo. The bed can
unexpectedly close and cause serious injury. Never drive the vehicle with the truck bed
in the raised position.
1. Select a level location to dump the truck bed load. Do not attempt to dump or unload the vehicle if it is on an
incline.
2. Apply the brakes and engage the parking brake on vehicles with mechanical brakes.
SECURE LOAD
MAX BED WEIGHT
500 LBS or 227 KG
P
MAX CENTER OF
DO NOT FILL GAS
GRAVITY HEIGHT 5"
CAN IN LOAD BED
(12 CM) ABOVE FLOOR
NO
PASSENGERS
IN LOAD BED
MAX
500 lb.
227 kg
MAX
5 in.
12 cm
MAX
100 lb.
45 kg
MAX TAILGATE
LOAD 100 LBS
OR 45 KG
O
PERATION
HIGH CENTER
OF GRAVITY MAY
CAUSE TIP OVER
MAX
o
14 / 25%
74821G01
MAX SIDE
SLOPE 14°
31