Advertisement
INSTALLATION INSTRUCTIONS
10. Your unit may come with internal packaging.
This packaging must be removed prior to
installing the air conditioner back into the
cabinet.(see Fig.7).
Shipping Packaging
Plastic tie
Install Top Angle and
2
Side Bracket
1. Attach foam gasket to top angle
above holes as shown in Fig.6.
2. Install top angle and side retainers
to cabinet as shown in Fig.8 (10 sc-
rews).
Assemble W indow Filler Panels
3
1. Place cabinet on floor, a bench, or
a table.
,,
2. Slide
section of window filler panel
I
into side retainer on the side of the
cabinet (see Fig.9 &
Do both sides.
Plastic
Frame
Fig.9
Fig.7
Fig.8
Fig.10
).
Window Filler
Panel
Side Retainer
Top
View
3. Insert top and bottom legs of window
filler panel frame into channel in the
top angle and bottom rail. Do both
sides.
4. Insert washer head locking 7/16" screws
(2) into holes in top leg of filler panel
frame (see step 6). Do not totally tigh-
ten. Allow leg to slide freely. Screws
will be tightened after section 6.
4
Place Cabinet in window
1.Open window and mark center of window inner sill
as shown(Fig.11).
2. Place cabinet in window with bottom sill angle
firmly seated over window sill as shown. Bring
window down temporarily behind top angle to
hold cabinet in place(Fig.12).
Fig.11
3. Shift cabinet left or right as needed to line up
center of cabinet on center line marked on inner sill.
4. For wooden window: Fasten cabinet to window inner
sill with two screws into holes (Fig.13) (You may
wish to pre-drill pilot holes).
For Vinyl-Clad window: Place two safety locks into
the holes located in the bottom of the cabinet and
drive two #10X1/4 pan-head Phillips locking
screws through the safety locks into the cabinet
as shown (FIG.13B)(on some models).
5. Remove protective strip from adhesive side of
Bottom Rail Foam Seal.
Apply Seal over screws fastening bottom rail to
window inner sill.
12
Air Conditioner
Plastic
Cabinet
Frame
Locking
Screw
Ⅰ
" " Section
Hole
Window
Filler
Panel
Fig.10
Window
inner Sill
Window
outer Sill
Fig.12
Sill
Angle
Advertisement
