Advertisement
Quick Links
OPERATOR'S MANUAL
A Division of Snow Joe
, LLC
®
THANKS
OF A REMANUFACTURED PRODUCT.
To make sure you get the most out of
your product, be sure to register online at
ELECTRIC SNOW THROWER
R
18-INCH | 12-AMP
Model SJ617E-RM
FOR
snowjoe.com
to enjoy full product support.
YOUR
PASTE UPC LABEL HERE
Form No. SJ-SJ617E-RM-880E-V1
PURCHASE
Advertisement
Related Manuals for SNOWJOE SJ617E-RM
Summary of Contents for SNOWJOE SJ617E-RM
- Page 1 18-INCH | 12-AMP OPERATOR’S MANUAL Model SJ617E-RM A Division of Snow Joe , LLC ® Form No. SJ-SJ617E-RM-880E-V1 THANKS YOUR PURCHASE OF A REMANUFACTURED PRODUCT. To make sure you get the most out of your product, be sure to register online at snowjoe.com...
- Page 2 OPERATOR’S MANUAL Model SJ617E-RM A Division of Snow Joe , LLC ® Form No. SJ-SJ617E-RM-880E-V1 IMPORTANT! electric shock. There is an increased risk of electric shock if your body is earthed or grounded. Safety Instructions 6. Do not abuse the cord. Keep the cord away from heat, oil, sharp edges, or moving parts.
- Page 3 Electrical Safety 4. To prevent the appliance cord from disconnecting from the extension cord during operation, use the on-board cord 1. Ground fault circuit interrupter (GFCI) protection should restraint hook and/or make a knot with the two cords as be provided on the circuit(s) or outlet(s) to be used for shown in Table 1.
- Page 4 6. Body position – Maintain proper footing and balance • Abnormal operation – If you notice the snow thrower at all times. Place heels firmly on the ground and tightly running in an unstable state or hear abnormal sounds from grasp the handle bar. Watch for uneven surfaces and do the engine, immediately stop the machine, disconnect the not overreach.
- Page 5 Safety Symbols The following table describes safety symbols that may appear on this product. Read, understand, and follow all instructions on the machine before attempting to assemble and operate. Symbols Descriptions Symbols Descriptions READ THE OPERATOR'S MANUAL(S) – Read, understand, WARNING! Do not expose the and follow all instructions in the unit to rain or wet conditions.
- Page 6 Know Your Electric Snow Thrower Read the owner’s manual and safety rules carefully before operating your electric snow thrower. Compare the illustration below to the actual unit in order to familiarize yourself with the location of the various controls and adjustments. Save this manual for future reference.
- Page 7 If any damage is seen or suspected, do not assemble. Instead, contact the Snow Joe + Sun Joe customer ® ® service center at 1-866-SNOWJOE (1-866-766-9563) for assistance. Handle with care during assembly so that electrical wiring does not become damaged.
- Page 8 Chute Crank Assembly 4. Secure the middle frame to the lower frame using 2 knobs and 2 carriage bolts. Install the knobs on the outside of 1. Remove the cotter pin from the lower crank rod (Fig. 7). the unit, and tighten (Fig. 4). Fig.
- Page 9 4. Slide the crank rod connector over the top of the lower crank rod (Fig. 13). Fig. 10 Fig. 13 Crank rod connector Lower crank rod 3. Secure the lower crank rod in place with the cotter pin (Figs. 11 – 12). 5.
- Page 10 7. Slide the upper crank rod into the top of the crank rod connector (Fig. 16). Fig. 19 Fig. 16 Upper crank rod Locking arrow Crank rod connector Lower crank 2. Secure in place with the provided screw (Fig. 20). Fig.
- Page 11 4. Secure the carriage bolts and knobs. Make sure the knobs 3. Insert the female end of the extension cord into the are tightened (Fig. 22). appliance's polarized male plug (Fig. 24). Fig. 22 Fig. 24 Carriage bolt 4. Note that the snow thrower has a polarized male plug – one prong in the plug is slightly longer and wider than the other (Fig.
- Page 12 7. Do not push the snow thrower with excessive force. You Fig. 26 should push the machine gently and evenly in accordance with the unit’s throw rate. 8. Do not apply additional man-made load to the engine ON/OFF since this may cause engine damage. switch lever 9.
- Page 13 Changing Throw Direction and 2. The chute deflector on the top of the discharge chute controls the height of the snow stream. Loosen the knobs Throw Height to raise or lower the deflector to the desired height of snow you wish to throw. Tighten the knobs to secure the deflector (Fig.
- Page 14 Maintenance 1. Open the two side covers by removing the 5 screws on each side (Figs. 30 – 31). Fig. 30 WARNING Make sure to turn off the switch and disconnect the extension cord before performing any maintenance task on your snow thrower. Screws Screws Lifetime Lubrication (Motor and Auger) Lubrication is not necessary and may damage the unit.
- Page 15 Replacing the Scraper Bar 3. Remove the screws and the bushings from the drive wheel (Fig. 33). 1. The scraper bar is located at the base of the snow thrower beneath the rotor housing (Fig. 36). Fig. 33 Fig. 36 Screws Bushing 4.
- Page 16 1. Open the left side plate by removing the five screws 4. Use your right hand to press the belt with the ribbed side (Fig. 38). down. While holding the belt down with your right hand, use your left hand to turn the auger forward so that the auger pulley rotates in a clockwise direction.
- Page 17 Cover loosely with a tarp for added protection. Service and Support If your Snow Joe SJ617E-RM electric snow thrower requires ® service or maintenance, please call the Snow Joe + Sun Joe ®...
- Page 18 NOTE: Accessories are subject to change without any obligation on the part of Snow Joe + Sun Joe to provide notice of such ® ® changes. Accessories can be ordered online at snowjoe.com or via phone by contacting the Snow Joe + Sun Joe customer ® ®...
- Page 19 EXCLUSIONS: reach us at 1-866-SNOWJOE (1-866-766-9563), online at • Wearing parts like belts, augers, chains and tines are snowjoe.com, via email at help@snowjoe.com or tweet us not covered under this warranty. Wearing parts can be @snowjoe. purchased at snowjoe.com or by calling 1-866-SNOWJOE (1-866-766-9563).
- Page 20 snowjoe.com...
Need help?
Do you have a question about the SJ617E-RM and is the answer not in the manual?
Questions and answers