Page 1
CLUBMAN Assembly and Operating Instructions FOR MODELS: 16440, 16540, 16640 CLUBMATE FOR MODEL: 16740 BD16640 PICTURED ABOVE AUSTRALIA / NEW ZEALAND FOR OUTDOOR USE ONLY...
CONGRATULATIONS CONTENTS Dear customer, Important safety instructions ..........3 Gas specifications ..............4 Congratulations and thank you for choosing our barbecue. Know your Clubman/Clubmate barbecue ....... 5 We are sure you will find it a pleasure to use. Before you use the barbecue, we recommend that you read through Installation instructions ............
IMPORTANT SAFETY INSTRUCTIONS Failure to adhere to the above warnings may cause injury Please read the user manual carefully and store in a handy or property damage and affect your ability to make a claim place for later reference. under the manafacturer’s warranty. IMPORTANT TIPS &...
GAS SPECIFICATIONS FIG 1 Standard POL regulator (AU/NZ regulator) WARNING WARNING • Gas cylinders must be stored outdoors, out of reach of Gas shutoff valve children and must not be stored in a building, garage or any other enclosed area. Tighten in this direction •...
INSTALLATION INSTRUCTIONS The legs are folded on the underside of the BBQ. To unfold: Place the BBQ upside down, and release legs by unscrewing the 2 Hand Screws. Pull both Wheels Frames to a vertical position. Place the bottom shelf (or cross-brace) in between the horizontal members, and tighten with a hand-screw on each side.
Page 7
INSTALLATION INSTRUCTIONS Turn back the right way, and install the fat collecting cup holder. Place cup inside. Install the shelf on the right hand side. (Clubman Only. Clubmate has handles on both sides): The shelf should be installed such that the bottom screw in each bracket will go through the hole in the shelf.
Page 8
INSTALLATION INSTRUCTIONS Install cylinder hook over the 2 studs under the right-hand side shelf. Fit the handle on left hand side: INSTALLATION INSTRUCTIONS...
Page 9
INSTALLATION INSTRUCTIONS Assemble the black spacers to the ends of the handle tube. Insert the assembled tube in between the brackets. Insert threaded rod through brackets and handle, and tighten with a nut on each side. The Cooking Plate of this BBQ is designed so it can be removed for easier transportation of the appliance. To remove the plate, you must undo the 5 thumb screws holding it to the body.
USING YOUR BARBECUE Ignition: G. Light each burner by following this procedure (16540 and 16740): Model 16440 and 16640 does not require a battery and has a QuartzStart ignition system built into every valve. • Read all instructions before lighting. For 16540 and 16740 models, A battery must be inserted •...
PARTIAL ENCLOSURES TECHNICAL INFORMATION This appliance shall only be operated in an above ground, open air situation with natural ventilation, without stagnant WARNING WARNING areas, where gas leakage and products of combustion are Note: Do not modify this appliance. Any deviation from rapidly dispersed by wind and natural convection.
MAINTENANCE Use only soft cloth or sponge to clean the surfaces of barbecue and then carefully dry. Avoid leaving acidic or alkaline substances on the plate. It may cause discolouration and corrosion. Keep the igniters probes clean. Wipe away any apparent water or dirt.
TROUBLESHOOTING CONDITION POSSIBLE CAUSE SOLUTION Empty gas cylinder Replace cylinder Re-ignite and allow operating for Flame goes out while in use Air mixed in hoses a short while, till clears out Blockage Seek professional assistance Turn off knob button, then open the Gas cylinder valve close cylinder valve Re-ignite and allow operating for a...
Warranty FOR SALES IN AUSTRALIA AND NEW ZEALAND APPLIANCE: BEEFEATER CLUBMAN/ CLUBMATE BBQ This document sets out the terms and conditions of the product (c) c osmetic damage which does not affect the operation of the warranties for BeefEater Appliances. It is an important document. Appliance; Please keep it with your proof of purchase documents in a safe place (d) damage to the Appliance caused by: for future reference should there be a manufacturing defect in your (i) negligence or accident;...