American Eagle 40P Manual

American Eagle 40P Manual

Single-stage piston compressor

Advertisement

Subject to Change without Notification.
© 2020 American Eagle
®
Specifications • Installation • Assembly
American Eagle
740 North State Street
PO Box 169
Garner, IA 50438
800-392-3015
www.americaneagleacc.com
Model 40P
Single-Stage Piston
Compressor Manual
Rev 1
PN 106758

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 40P and is the answer not in the manual?

Questions and answers

Summary of Contents for American Eagle 40P

  • Page 1 Model 40P Single-Stage Piston ® Compressor Manual Specifications • Installation • Assembly American Eagle 740 North State Street PO Box 169 Garner, IA 50438 800-392-3015 Subject to Change without Notification. Rev 1 www.americaneagleacc.com © 2020 American Eagle PN 106758...
  • Page 2 H YDRA U LIC FLO W ( GP M) H Y DRAUL I C P R E SS URE (PS I ) CO MP RESS OR SPE ED ( RPM ) MADE IN THE U.S.A. BY AMERICAN EAGLE. PN 54490 Page ii | American Eagle 40P Compressor Manual ®...
  • Page 3: Table Of Contents

    Typical Hydraulic Circuit for Compressor with Auxiliary Cooler ......... 10 Chapter 3 - Assembly Drawings ....................11 40P Case Assembly - PN 100358 ................... 11 40P Complete Assembly - PN 100355 ................... 12 HV30 Compressor Assembly - PN 98537 ................13 Chapter 4 - Replacement Parts ....................
  • Page 4: Introduction

    This manual is not binding. American Eagle reserves the right to change, at any time, any or all of the items, components, and parts deemed necessary for product improvement or commercial/production purposes.
  • Page 5: Chapter 1 - Specifications

    23.40” Electrical 12V DC Crankcase Oil Capacity 1.5 Quarts Cooler Fan 1200 CFM, 12 Volt (Pull) Drive Type Direct Driven NOTICE Duty cycle on Piston Compressors is 50:50 over 10 minutes. American Eagle 40P Compressor Manual | Page 1 ®...
  • Page 6 This page intentionally left blank. Page 2 | American Eagle 40P Compressor Manual ®...
  • Page 7: Chapter 2 - Installation

    Procedure: Assemble rod onto the crankshaft taking care to align the machined surfaces together and tighten cap screws finger tight. Tighten bolts until hand tight and torque to 18 ft-lbs. Check twice the torque reading before final assembly of the cylinders. American Eagle 40P Compressor Manual | Page 3 ®...
  • Page 8: Component Installation, Continued

    CPRSR RELAY (12V CONTROL INPUT) * CUSTOMER ADDED WIRING MUST MATCH OR YEL 14GA SPEED CTRL EXCEED PIGTAIL WIRE SIZE FOR POWER (12V CONTROL OUTPUT) SUPPLY AND GROUND CIRCUIT BLK 12GA GROUND Page 4 | American Eagle 40P Compressor Manual ®...
  • Page 9: Electrical Schematic

    12V power supply. The yellow wire is required from the compressor when connecting the speed control into the system. W/ 25AMP ATO FUSE American Eagle 40P Compressor Manual | Page 5 ®...
  • Page 10: Hydraulic System

    The airline is routed using a ¾” 200 psi air/steam hose. This delivery line should be free from all obstructions. Note: There should be no check valve installed between the compressor and the air tank (One is already included in the compressor package). American Eagle recommends the installation of a ten-gallon air tank (minimum) to maintain proper operation of the air compressor.
  • Page 11: Compressor Pressure Switch

    2. After kick out pressure is set, adjust the kick on screw setting to 115 psi minimum/120 psi maximum. 3. Cycle compressor to verify correct settings. 4. For questions about this procedure, please contact American Eagle Customer Service at 800-321-3741. American Eagle 40P Compressor Manual | Page 7 ®...
  • Page 12: Typical Hydraulic Circuit For Single-Section Pump

    PN 30533 Typical Hydraulic Circuit for Single-Section Pump Page 8 | American Eagle 40P Compressor Manual ®...
  • Page 13: Typical Hydraulic Circuit For Tandem (Two Part) Pump

    Typical Hydraulic Circuit for Tandem (Two Part) Pump American Eagle 40P Compressor Manual | Page 9 ®...
  • Page 14: Typical Hydraulic Circuit For Compressor With Auxiliary Cooler

    Typical Hydraulic Circuit for Compressor with Auxiliary Cooler HYDRAULIC RESERVOIR FILTER FILTER SCREEN AUXILIARY COOLER SUCTION PORT SINGLE HYDRAULIC PUMP COMPRESSOR RETURN PRESSURE Page 10 | American Eagle 40P Compressor Manual ®...
  • Page 15: Chapter 3 - Assembly Drawings

    40P Case Assembly - PN 100358 PN 100358 ITEM PART DESCRIPTION QTY. 100361 PANEL FRONT CPRSR 40P SHROUD PC WHITE 100362 PANEL BACK CPRSR 40P SHROUD PC WHITE 100360 PANEL SIDE RH 40P SHROUD PC WHITE 100359 PANEL SIDE LH 40P SHROUD PC WHITE...
  • Page 16: Complete Assembly - Pn 100355

    0523 WASHER 0.38 LOCK C6162 FTG 12-12 MP-MP HEX NIPPLE STRAIGHT 0560 FTG 6 MFS PLUG 45 106753 TUBE ASM 0.75 AIR CPRSR TO BLKHEAD 40P ZC V2 10078 COUPG 3/8 KW L150 1.438 3864 FTG 12-12 MJ-MP 90 10084 FAN 12.00 PULL 12 VOLT 132A COMP 47 104558 TUBE ASM 0.75 COOLER TO BLKHEAD 40P ZC...
  • Page 17: Hv30 Compressor Assembly - Pn 98537

    RING OIL HV 60 RING RAIL 5817 ROLL PIN 0.19X.50 5819 GAUGE OIL PSI 1.5 5828 WASHER LONG HD BOLT (BRASS) 9979 GASKET CYL HEAD (VALVE PLATE) HV-60 9980 GASKET CYL HEAD HV-60 American Eagle 40P Compressor Manual | Page 13 ®...
  • Page 18 This page intentionally left blank. Page 14 | American Eagle 40P Compressor Manual ®...
  • Page 19: Chapter 4 - Replacement Parts

    Canister Filter Element (Qty 1), Compressor Oil (2 Quarts), 106759 Canister Filter Element Only 106182 Canister Filter Assembly Synthetic Compressor Oil C0887 (Quart) Synthetic Compressor Oil (Case 7259 of 12 quarts) American Eagle 40P Compressor Manual | Page 15 ®...
  • Page 20 ® Subject to Change without Notification. © 2020 American Eagle...

Table of Contents

Save PDF