Table of Contents
Advertisement
27.
Fuel filling must always take place with the motor stopped. Do not start the motor, if fuel
has been spilt. If it is necessary to tank up during work, wait until the motor has cooled
down.
28. Always stop the motor before you leave the machine. This is done through engaging the
red emergency stop button at the control panel and removing the key. Never leave the
sender on the machine, keep it in a safe place and away from other persons.
3 SAFETY PRECAUTIONS DURING MAINTENANCE AND ADJUSTMENTS
1.
Before attempting to carry out any kind of adjustment or maintenance on the machine, the
motor must be stopped. Engage the emergency stop button of the machine and remove the
key from the emergency stop button (to prevent unauthorized persons from starting the
motor.)
2.
Make sure that all parts of the machine are stationary before carrying out maintenance or
adjustments.
3.
Hydraulic system:
a.
Only persons who are familiar with hydraulic systems (including the risk on contact
with hydraulic fluid, especially under pressure) are allowed to carry out repair and
maintenance of the hydraulic system of the machine.
b.
The excess-pressure valves are set by the factory must not be adjusted without
previous agreement with the dealer, importer or service department at A/S.
c.
Claims for damages after incorrect use or maintenance/repair will not be accepted.
d.
Check the proper condition of the hoses before every use (if frayed, worn, twisted
etc.) and replace any damaged part immediately.
NB: Never attempt to find leaks in the hydraulic system with your hands – hydraulic
fluid under high pressure coming from minor leaks can be invisible, and such a fine
oil jet under high pressure can damage your hand; instead a piece of wood, carton or
the like should be used.
4.
Batteries:
The batteries contain a sulphuric acid electrolyte, which can cause serious burns and
produce explosive gases. Avoid getting this liquid on your skin, into your eyes or on your
clothing. Do not swallow the liquid. The necessary measures mentioned below must be
observed:
a.
Never be near open fire when checking the level of the electrolyte. Keep sparks,
flames and lit cigarettes away.
Page 8 / 49
Advertisement
Table of Contents
