Subscribe to Our Youtube Channel
Related Manuals for Smithco Super Star LE
Summary of Contents for Smithco Super Star LE
- Page 1 Operator’s Super Star LE 42-400-A June 2009 Product Support: Hwy SS & Poplar Ave; Cameron WI 54822 1-800-891-9435 productsupport@smithco.com...
-
Page 2: Table Of Contents
CONTENTS Introduction ............ 1-12 Introduction ..................1 Symbols ..................2-3 Safe Practices .................. 4 Super Star Diesel Specifications ............5 Euro Star Specifications ..............6 Setup ....................7 Controls & Instruments Euro Star ............. 8 Controls & Instruments Super Star Diesel ......... 9 Operation .................. -
Page 3: Introduction
All Smithco Smithco Smithco Smithco machines have a Serial Number and Model Number. Both numbers are needed when ordering Smithco parts. Refer to engine manual for placement of engine serial number. The serial number plate on the Super Rakes is located on the right side main frame. -
Page 4: Symbols
SYMBOLS Read Electrical Power No Electrical Operator’s Power Manual Engine - Stop Engine - Start Engine - Run Temperature Water Engine Oil Light Temperature Gasoline Diesel Glow Plug - On Glow Plug - Off Glow Plug Hour Meter Hour Meter Fuse Hand Throttle Choke - Closed... - Page 5 SYMBOLS Up/Down Arrow Down/Lower Up/Raise Manual No Smoking Moving Parts Operation Step Hot Surface Pinch Point Hydraulic Fluid Lift Arm Tractor Penetration Engage Disengage Ground Speed Fast Slow Forward High Warning Danger Reverse Neutral Caution...
-
Page 6: Safe Practices
17. Keep the area of operation clear of all bystanders. 18. Never carry passengers. 19. Stop engine before making repairs/adjustments or checking/adding oil to the crankcase. 20. Use parts and materials supplied by Smithco Smithco only. Do not modify any function or part. Smithco Smithco Smithco hese machines are intended for professional maintenance on golf courses, sports turf, and any other area maintained turf and related trails, paths and lots. - Page 7 SPECIFICATION SUPER STAR LE WEIGHTS AND DIMENSIONS Length 64" (163 cm) Width 57" (145 cm) Height 47" (119 cm) Wheel Base 51" (104 cm) Weight 950 lbs. (451 kg) SOUND LEVEL At ear level 85 dB At 3 ft. (0.914 m) 83 dB At 30 ft.
-
Page 8: Setup
SETUP The Bunker Rakes arrive from Smithco Smithco with some assembly required before service. Smithco Smithco Smithco 1. Set park brake. Push the brake down past center and the park brake is engaged. 2. Rear wheel mounting. Block front tire. Jack up rear of machine being careful not to damage underside of machine. -
Page 9: Controls & Instruments Super Star Diesel
CONTROLS & INSTRUMENTS SUPER STAR LE INSTRUMENTS LOCATED ON THE CONTROL PANEL Electric On/Off Valve Switch - Toggle switch that turns 2 Wheel to 3 Wheel Drive. For 42-117 Optional Electric Valve Kit. Oil Light - The oil light should come on when ignition is on without engine operating. -
Page 10: Operation
OPERATION AND DAILY CHECK LIST STARTING ENGINE Before operating this machine, become familiar with all controls and functions of these units. Also complete all maintenance requirements and read all safety warnings. By knowing the machine thoroughly, how it operates and by doing the prescribed maintenance steps, you can expect relatively trouble-free operation for years to come. -
Page 11: Daily Checklist
DAILY CHECKLIST Use all procedures and parts prescribed by the manufacturer's. Read the engine manual before operation. The suggested maintenance checklist is not offered as a replacement for the manufacturer’s but as a supple- ment. You must adhere to guidelines established by manufacturer for warranty coverage. In adverse conditions such as dirt, mud or extreme temperatures, maintenance should be more frequent. -
Page 12: How To Rake A Sand Trap
HOW TO RAKE A SAND TRAP HOW TO RAKE A SAND TRAP View bunker to determine the most efficient pattern to follow so that rake pattern and configuration of bunker will flow in same general direction and look attractive. Enter bunker at its lowest point. Perhaps drain area or another point where “lip” of the trap is minimal. Operate at 2-4 m.p.h. -
Page 13: Battery
BATTERY BATTERY Batteries normally produce explosive gases which can cause personal injury. Do not allow flames, sparks or any ignited object to come near the battery. When charging or working near battery, always shield your eyes and always provide proper ventilation. Battery cable should be disconnected before using "Fast Charge". -
Page 14: Declaration Of Conformity
Název stroje Maskinnavn Machinenaam Masina nimi Laitteen nimi Nom de la machine Maschinenbezeichnung Gépnév Denominazione della macchina Iek rtas nosaukums Mašinos pavadinimas Smithco Diesel Super Star Isem tal-Magna Nazwa urz dzenia Nome da Máquina Numele echipamentului Názov stroja Naziv stroja Nombre de la máquina Maskinens namn Designation Ozna ení... - Page 15 The place and date of the declaration Místo a datum prohlášení Sted og dato for erkl æringen Plaats en Smithco West Inc. datum van de verklaring Deklaratsiooni väljastamise koht ja kuupäev Vakuutuksen paikka ja päivämäärä Lieu et date de la déclaration Ort und Datum der Erklärung...
-
Page 16: Limited Warranty
January 1, 2007, to be free from defects in materials or workmanship for the period of time listed below. Where a warrantable condition exists, Smithco will repair the Product at no cost to you including diagnosis, labor (at the Smithco standard labor rate, subject to the Smithco flat rate schedule), and parts. - Page 17 Smithco may require the return of failed parts or components in order to determine the validity of any warranty claim. Smithco will not be obligated to replace components of other manufacturers if inspection by the original component manufacturer indicates that failure was due to normal wear and tear, expected consumption through use or improper care or service.
Need help?
Do you have a question about the Super Star LE and is the answer not in the manual?
Questions and answers