Related Manuals for Lincoln LMC 1
Summary of Contents for Lincoln LMC 1
- Page 1 User Manual LMC 1 9.3EN-98001-A07 LMC 1 Lincoln Multi Controller 1 6603m07 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 2 Subject to modifications without prior notification. © 2007 by LINCOLN GmbH Postfach 1263 Phone: +49 (6227) 33-0 D-69183 Walldorf Fax: +49 (6227) 33-259 Page 2 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 3: Table Of Contents
… Quicktour Operating mode Connection Operation Commissioning - Parameter defaults - Selecting the lubrication system Adapting the parameters Page 3 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 4: Introduction
/ system. Therefore, for the operation of your device always use original parts made by Lincoln 1013A94 GmbH. Page 4 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 5: Safety Instructions
Disposal Dispose of the LMC 1 in an environmentally friendly way, according to the relevant and legal regulations. Page 5 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 6: Description
12 - DIP-switch (from left: SW1, SW2, SW3, SW4) 6608m06 Fig. 2 The LMC 1 control p.c.b. (VDC) Page 6 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 7: Menu Reference List
Are displayed or hidden depending on the parameter default (see “DIP-switch combinations“, page 11) in the set-up mode (see “Quicktour“, pages 16 and 32). Page 7 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 8: Installation
Controller Display I1 - I8 Signal input connection 6610b06 Q1-Q5 Control output (ACTUATOR) connection Fig. 5 Connection diagram Page 8 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 9: Technical Data
Safety Test DIN EN 61000-6-4 Emitted Interference Walldorf, 05-May-06, Dr. Ing. Z. Paluncic DIN EN 61000-6-2 Interference Immunity Page 9 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 10: Troubleshooting
E-AP Supply air pressure too low Check compressed air supply. Readjust pressure regulator if necessary. Page 10 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 11: Parameters, Survey
6664c06 Configuration mode 6668b06 EMU – electronic change-over control SU – pressure-controlled change-over control 3ZWV - 3/2-way valve Page 11 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 12: Pma Lubrication Systems
To set parameters back ENTER or acknowledge settings & continue in operating mode? t > 30 sec. Operating mode Page 12 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 13 Q5 - Reserve PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 13 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 14 Please refer to page 15 for possible parameter adaptations. 6001a02 Page 14 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 15 - Count value 1 pause cycle Conclude the selection with the “ENTER“ key. Continue with the * c–bl * menu item. Page 15 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 16: Progressive Systems
To set parameters back ENTER or acknowledge settings & continue in operating mode? t > 30 sec. Operating mode Page 16 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 17 Q5 - Reserve PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 17 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 18 Please refer to page 19 for possible parameter adaptations. Page 18 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 19 If the ratio is reversed, the fault indication * E-PD * appears in the LMC 1 display (see page 10). Page 19 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 20: Two-Line Systems
To set parameters back ENTER or acknowledge settings & continue in operating mode? t > 30 sec. Operating mode Page 20 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 21 Q5 - Change-over device 2 PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 21 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 22 The standard settings to control your two-line system are now complete and the system is ready for operation. Please refer to page 23 for possible parameter adaptations. Page 22 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 23 If the ratio is reversed, the fault indication * E-PD * appears in the LMC 1 display (see page 10). Page 23 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 24: Centro-Matic ® Systems
To set parameters back or acknowledge settings & ENTER continue in operating mode? t > 30 sec. Operating mode Page 24 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 25 Q5 - Reserve PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 25 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 26 6001a02 Please refer to page 27 for possible parameter adaptations. Page 26 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
- Page 27 If the ratio is reversed, the fault indication * E-PD * appears in the LMC 1 display (see page 10). Page 27 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 28: Cobra Chain-Lubrication Systems
To set parameters back ENTER or acknowledge settings & continue in operating mode? t > 30 sec. Operating mode Page 28 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 29: Connection
Q5 - COBRA 1X-2 PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 29 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... -
Page 30: Operation
Fig. 32) outside of the configuration mode, the actual rest of the expired pause cycle is shown in the display. 6001a02 Page 30 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 31 If you want to change a menu item again, press the “ENTER“ key. You will once more automatically arrive at the start of the configuration mode. Page 31 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 32: Spray-Lubrication Systems
To set parameters back ENTER or acknowledge settings & ENTER continue in operating mode? t > 30 sec. Operating mode Page 32 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 33 Q5 - Reserve PE - Protective earth conductor L+ - Power supply + M - Power supply – Page 33 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 34: Parameter Defaults
Please refer to page 35 for possible parameter adaptations. Page 34 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259... - Page 35 If you want to change a menu item again, press the “ENTER“ key. You will once more automatically arrive at the start of the configuration mode. Page 35 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...
-
Page 36: Mounting Channels For Fastening
Phone: (+65) 6588-0188 Printed in Germany Fax: (+1) 800 424 5359 Fax: (+65) 6588-3438 Web site: Email: sales@lincolnindustrial.com.sg www.lincolnindustrial.com Page 36 of 36 LINCOLN GmbH • Postfach 1263 • D-69183 Walldorf • Tel +49 (6227) 33-0 • Fax +49 (6227) 33-259...