Suzuki DF350A Service Manual page 21

Crankshaft / Conrod
Item
Conrod small end inside diameter
Conrod big end oil clearance
Conrod big end inside diameter
Crank pin outside diameter
Crank pin outside diameter
difference (Out-of-round and taper)
Conrod bearing thickness
Conrod big end side clearance
Conrod big end width
Crank pin width
Crankshaft center journal runout
Crankshaft journal oil clearance
Crankcase bearing holder inside
diameter
Crankshaft journal outside diameter std.
Crankshaft journal outside diameter
difference (Out-of-round and taper)
Crankshaft bearing thickness
Crankshaft thrust play
Crankshaft thrust bearing thickness std.
Electrical
Item
Ignition timing
Over revolution limiter
CKP sensor resistance
CMP sensor resistance
Ignition coil resistance
Battery charge coil resistance
Battery charge coil output (12 V)
Standard spark plug
Fuse amp. rating
Recommended battery capacity (12 V)
Fuel injector resistance
IAT sensor/Cylinder temp. sensor/Ex.
mani. temp. sensor
ECM main relay coil resistance
Starter motor relay coil resistance
PTT motor relay coil resistance
Unit
std. mm (in.)
std. mm (in.)
Limit mm (in.)
std. mm (in.)
std. mm (in.)
Limit mm (in.)
std. mm (in.)
std. mm (in.)
Limit mm (in.)
std. mm (in.)
std. mm (in.)
Limit mm (in.)
std. mm (in.)
Limit mm (in.)
std. mm (in.)
mm (in.)
Limit mm (in.)
std. mm (in.)
std. mm (in.)
Limit mm (in.)
mm (in.)
Unit
Degree
r/min
Ω at 20 °C
Ω at 20 °C
Ω at 20 °C
Primary
Secondary kΩ at 20 °C
Ω at 20 °C
Watt
Type NGK
Gap mm (in.)
A
Ah (kC)
Ω at 20 °C
kΩ at 25 °C
Ω at 20 °C
Ω at 20 °C
Ω at 20 °C
DF350AT
22.010 – 22.018 (0.8665 – 0.8669)
0.045 – 0.063 (0.0018 – 0.0025)
0.080 (0.0031)
57.000 – 57.018 (2.2441 – 2.2448)
53.982 – 54.000 (2.1253 – 2.1260)
0.010 (0.0004)
1.482 – 1.497 (0.0583 – 0.0589)
0.300 – 0.450 (0.0118 – 0.0177)
0.550 (0.0217)
20.750 – 20.800 (0.8169 – 0.8189)
21.100 – 21.200 (0.8307 – 0.8346)
0.04 (0.002)
0.030 – 0.048 (0.0012 – 0.0020)
0.065 (0.0026)
78.000 – 78.018 (3.0709 – 3.0716)
72.982 – 73.000 (2.8733 – 2.8740)
0.010 (0.0004)
2.499 – 2.514 (0.0984 – 0.0990)
0.11 – 0.31 (0.004 – 0.012)
0.35 (0.014)
2.425 – 2.475 (0.0955 – 0.0974)
DF350AT
5° ± 4° ATDC (at 600 r/min) – 9° BTDC (at 6 000 r/min)
168 – 252
0.16 – 0.32
ILZKR7D8
0.7 – 0.8 (0.028 – 0.031)
Main fuse: 60
Starter motor: 30
Ignition coil, Injector, ECM, F/P, VVT, CMP sensor: 30
PTT switch: 10
Throttle valve: 15
Shift actuator: 15
Low pressure fuel pump: 15
Isolator: 40
130 (468) or larger
10 – 14
1.8 – 2.3
145 – 190
145 – 190
16 – 24
General Information:
Data
Data
6 400
—
—
—
648
0A-12