Page 8
Step 6 Set Wall Frames Front and back wall frames are positioned between long side walls. B4 =($1'**%,(2%,9%1"2%f@]Bd@e%/2'/%6'**%9/'&2$%'0'#($1%#($#32%,9%'%WD%$#32%6'**%9/'&24%;/'+2%6'**$ 6#1"%-/2]+)1%$1)3$4%IMPORTANT:%H/#2(1%2(3%&'/M23%6#1"%'%D?D%1,%+,/(2/4%<2+)/2%9/'&2$ 1,021"2/%'1%1"2%+,/(2/%)$#(0%K^L%9,)/%BA3%$#(M2/$ @4 =($1'** 1"2 ,1"2/ f@]Bd@e /2'/ 6'** 9/'&2 1, 1"2 /2'/ 6'** 9/'&24 c'#* 1"2 /2'/ 6'** 9/'&2$ 1,021"2/ 6"2/2%1"2.%8)11%6#1"%KWL%2#0"1%BA3%$#(M2/%K$1'002/%('#*$%,(%2'+"%$#32%,9%1"2%$1)3$L%4 F4 =($1'** ' B@D 9/'&27 (2E1 1, 1"2 9#/$1 WD $#32 6'** 9/'&24 c'#* 9/'&2$ 1,021"2/ 6"2/2 1"2.
Page 9
Step 7 Install 2x4 Tie Plates B4 =($1'**%'%BCD%*,(0%@E^%,(%1"2%8'+M%6'**4%5$2%BA3%$#(M2/$%$-'+2%BCe%'-'/1%1,%$2+)/2%1#2%-*'12$4 @4 :2-2'1%1,%#($1'**%'%BCD%*,(0%@E^%1#2%-*'12%,(%1"2%,--,$#12%9/,(1%6'**4 16' Long 2x4 Tie Plate 12' Long 2x4 Tie Plate Back Wall Frames F4 =($1'**%'%@E^]B@D%,(%1"2%$#32%6'**4%!"2%@E^%6#**%8)11%'0'#($1%1"2%BCD%*,(0%1#2%-*'12%,(%1"2%8'+M 6'**4%5$2%BA3%$#(M2/$4 ^4 =($1'**%'(,1"2/%%@E^]B@D%8,'/3$%,(%1"2%$'&2%$#32%6'**%9/'&24 I4 ?)1%1,%9#1%'(3%#($1'**%'%@E^]WD%8,'/3%1,%9#(#$"4 C4 :2-2'1%1,%#($1'**%@E^%1#2%-*'12$%,(%1"2%,--,$#12%$#326'**%9/'&2$4 Step 8A Install Siding on Wall Frames If a siding panel has a damaged edge, install this edge at a corner where it will be covered with corner trim.
Page 11
Step 9 thru 11 Steps not needed with this size and model. Step 12 Install Stairs IMPORTANT: Go now to the instructions in the stair kit book to install the stairs, floor joist and flooring.
Page 12
Step 13A Assemble Rear Gable Assemble the roof gables and trusses on the center of the loft floor. This will make it easier to stand the gable upright over the lower wall. B4 ?)1 K@L 16, @E^]BAD 8,'/3$ 1, ' *2(01" ,9 f_]Bd@e4 R,$#1#,( 1"2$2 @E^$7 on edge '(3 8)11 1,021"2/4 @4 R,$#1#,(%K@L%16,%WB]Fd^e%*,(0%@EC$%'(3%K@L%16,%_B]FdWe%*,(0%@EC%8,'/3$%,(%1"2%@E^%-*'12$%'$ $",6(%82*,64%!"2%1,-%@EC%8,'/3$%"'G2%8*)2%&'/M$%,(%1"2%2(3$4%R,$#1#,(%1"2$2%2(3$%1,021"2/ '1%1"2%1,-4...
Page 13
Step 13B Assemble Rear Gable continued Two Ridge Gussets have equal angles cuts. Four Knee Gussets have offset angles cuts. B4 <2+)/2%1"2%@EC%8,'/3$%1,021"2/%'1%1"2%M(22%'(3%/#302%6#1"%Bd@e%H<;%0)$$21$4 5$2%C3%+,&&,(%('#*$4%c'#*%I]Bd^e%E%B@e%H<;%9#**2/$%6"2/2%$",6(%82*,64 5/1/4" x 12" OSB Gusset 1/2" Gusset at Ridge 5-1/4" x 12" 1/2" Gusset OSB Filler at Knee @4 R*'+2 K@L 16, WB]Fd^e '(3 K@L 16, _B]FdWe @EC$ ,G2/ 1"2 9#**2/$4 <2+)/2 )$#(0 KCL $#E BA3 $#(M2/$ 6"2/2%9#**2/$%'(3%0)$$21$%'/2%*,+'1234 F4 =($1'** ' @B]Fd^e "#0"...
Step 29 Install Doors If your door opening is out of square, the space around the doors will not be even. You can remove and re-position the side trim to make allowances for this. The side trim does not have to be flush with the frame of the door opening. You can move the trim in or out to make the door spacing equal.
Page 26
Step 30 Install Windows B4 Z--*.%+')*M#(0%'/,)(3%1"2%6#(3,6%,-2(#(0%829,/2%#($1'**#(0%1"2%6#(3,6$4 @4 =($2/1 6#(3,6 #( ,-2(#(04 P,*3 1"2 6#(3,6 #( -*'+2 )$#(0 ' 926 ('#*$4 Note; the front flange projects past the window frame creating a slot for the trim4 5$2 ('#*$ 6#1" ' 9*'1 "2'3%$,%1"2%1/#&%+'(%82%#($2/123%#(%1"2%$*,14%c'#*$%)$23%1,%#($1'**%$"#(0*2$%6,/M%62**4 F4 =($2/1 BEF 1/#&...
Page 27
R'+M#(0 Q#$1 a2$1%j#/0#(#'%BCD%a#32%E%F@D%;)#*3#(0%i#1 Qty. Material Shipped on 'A' Pallet Qty. Material Shipped on 'B' Pallet R/2]8)#*1%V'8*2%U/'&2$ @B]Fd^e E% @C !/)$$%]%!,-%?,/3 E WB]Fd^e R/2]8)#*1%V'8*2%U/'&2$ Bf]Bd^e E ^ V'8*2%HG2/"'(0 E WB]Fd^e R/2]8)#*1%@E^%S,,/%P2'32/ @E^ F_]Bd@e F V'8*2%a'**%<1)3$ E C^]Bd@e R/2]8)#*1%@E^%a34%P2'32/ ^ V'8*2%!/#& !/)$$%]%Q20$ E _B]FdWe %%% ^ V'8*2%!/#&...
Page 28
Qty. Stair Material Shipped on 'B' pallet Qty. Material Shipped by Local Supplier @ B]Fd^e%<#E%<12-%<1/#(02/$ BB]_dWe E _I]IdWe R/2]+)1%a'**%<1)3$ a'**%R*'12$%K1/2'123L @ B]Fd^e%U#G2%%<12-%<1/#(02/$ BB]_dW E CF]Bd@e BB <1'#/%!/2'3$ BA]Bd@e E a'**%-*'12$%K1/2'123L a'**%-*'12$%K1/2'123L f a4R4%:#$2/$ _]Bd^e U/'&#(0%Q)&82/ @ a4R4%:#$2/$% C]Bd@e B Q'(3#(0%T'12/#'* @EB@ U/'&#(0%Q)&82/ U/'&#(0%Q)&82/...
Need help?
Do you have a question about the The Virginia and is the answer not in the manual?
Questions and answers