Maintenance Under Severe Usage Conditions - Hyundai 2003 Santa Fe Owner's Manual

5- 6
VEHICLE MAINTENANCE REQUIREMENTS
F040A02O-AAT

MAINTENANCE UNDER SEVERE USAGE CONDITIONS

The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the chart below for the appropriate
maintenance intervals.
R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if necessary
MAINTENANCE ITEM
ENGINE OIL AND FILTER
AIR CLEANER FILTER
SPARK PLUGS
BRAKE PADS, CALIPERS AND ROTORS
REAR BRAKE DRUMS/LININGS/PADS, PARKING BRAKE
STEERING GEAR BOX, LINKAGE & BOOTS/
LOWER ARM BALL JOINT
DRIVESHAFTS AND BOOTS
MANUAL TRANSAXLE OIL
AUTOMATIC TRANSAXLE FLUID AND FILTER
1
TRANSFER CASE OIL (4WD) *
1
REAR AXLE OIL (4WD) *
SEVERE DRIVING CONDITIONS
A - Repeated short distance driving
B - Extensive idling
C - Driving in dusty, rough roads
D - Driving in areas using salt or other corrosive materials or in
very cold weather
E - Driving in sandy areas
*1. Transfer case Oil and Rear Axle Oil should be changed anytime they have been submerged in water.
MAINTENANCE
OPERATION
With LSD
Without LSD
MAINTENANCE
INTERVALS
R EVERY 3,000 MILES (4,800 KM) OR 3 MONTHS
R MORE FREQUENTLY
R MORE FREQUENTLY
I MORE FREQUENTLY
I MORE FREQUENTLY
I MORE FREQUENTLY
I EVERY 7,500 MILES (12,000 KM) OR 6 MONTHS
R EVERY 60,000 MILES (96,000 KM)
R EVERY 30,000 MILES (48,000 KM)
R EVERY 25,000 MILES (40,000 KM)
EVERY 25,000 MILES (40,000 KM)
R
EVERY 50,000 MILES (80,000 KM)
F - More than 50% driving in heavy city traffic during hot weather
above 90°F (32°C)
G - Driving in mountainous areas
H - Towing a trailer
I - Driving as a patrol car, taxi, other commercial use and vehicle towing
J - Driving over 100 mph
DRIVING
CONDITION
A, B, C, F, H
C, E
B, H
C, D, G, H
C, D, G, H
C, D, E, F, G
C, E, F
A, C, D, E, F, G, H, I, J
A, C, E, F, G, H, I
C, E, G, I
C, E, G, I