Daily Inspection - TOHATSU MFS 6BZ Owner's Manual

62
INSPECTION AND MAINTENANCE
ENOM00551-0

1. Daily Inspection

Perform the following checks before
and after use.
Item
Fuel System
Fuel Tank Cap
Engine Oil
Electrical
Equipment
Throttle Sys-
tem
Recoil Starter
10
Clutch and
Propeller Sys-
tem
Installation of
Motor
Cooling Water
Tools and
Spares
Steering
Devices
Other parts
Points to Check
• Check the amount of fuel in the tank.
• Check for debris or water in the fuel filters.
• Check the rubber hoses for fuel leakage.
• Check for crack, leakage, damage in the fuel tank cap.
• Check for crack, damage in the gasket.
• Check for leakage at full close.
• Check the oil level.
• Check that the main switch functions normally.
• Check that the battery electrolyte level and specific gravity
are normal.
• Check for loose connections on the battery terminal.
• Check that the stop switch functions normally and make sure
the lock plate is there.
• Check cords for loose connections and damage.
• Check the spark plugs for dirt, wear and carbon build-up.
• Check carburetor linkage is working normally when turning
the throttle grip.
• Check the rope for wear and chafing.
• Check the ratchet engagement.
• Check that clutch engages correctly when operating the shift
lever.
• Visually Check propeller for bent or damaged blades.
• Check the propeller nut is tightened and the split pin is
present.
• Check all the bolts attaching the motor to the boat.
• Check the thrust rod installation.
• Check that cooling water is discharged from the cooling
water check port after the engine has started.
• Check that there are tools and spare parts for replacing
spark plugs, the propeller, etc.
• Check that you have the spare rope.
• Check the operation of the steering handle.
• Check if the anode is securely installed.
• Check the anode for corrosion and deformation.
ENOW00078-1
WARNING
Do not use outboard motor if any abnormal-
ity is found during pre-operation check oth-
erwise it could result in severe damage to
the motor or severe personal injury.
Remedy
Replenish
Clean or Replace
Replace
Replace
Replace
Replace
Fill to the upper level
mark on dipstick
Replace
Replenish or recharge
Retighten
Remedy or replace
Correct or replace
Clean or replace
Correct
Replace
Correct or replace
Adjust
Replace
Tighten
Repair
Repair
Repair if necessary
Replace