Daily Inspection - TOHATSU MFS 6A3Z Original Instructions Manual

MFS6-8-99A3_EUR_EN_141114N.book 60 ページ ２０１４年１２月１３日 土曜日 午後５時４９分
60
INSPECTION AND MAINTENANCE
ENOM00551-0

1. Daily Inspection

Perform the following checks before and
after use.
Item
• Check the amount of fuel in the tank.
Fuel System • Check for debris or water in the fuel filters.
• Check the rubber hoses for fuel leakage.
• Check for crack, leakage, damage in the fuel tank cap.
• Check for crack, damage in the gasket and tether.
Fuel Tank Cap
• Check for leakage at full close.
• Check for ratchet performance.
• Check the oil level.
Engine Oil
• Check that the main switch functions normally.
• Check that the battery electrolyte level and specific gravity are
• Check for loose connections on the battery terminal.
Electrical
Equipment
• Check that the stop switch functions normally and make sure
• Check cords for loose connections and damage.
• Check the spark plugs for dirt, wear and carbon build-up.
• Check carburetor linkage is working normally when turning the
Throttle Sys-
tem
• Check the rope for wear and chafing.
10
Recoil Starter
• Check the ratchet engagement.
• Check that clutch engages correctly when operating the shift
Clutch and
Propeller Sys-
• Visually Check propeller for bent or damaged blades.
tem
• Check the propeller nut is tightened and the split pin is present.
• Check all the bolts attaching the motor to the boat.
Installation of
Motor
• Check the thrust rod installation.
• Check that cooling water is discharged from the cooling water
Cooling Water
• Check that there are tools and spare parts for replacing spark
Tools and
Spares
• Check that you have the spare rope.
Steering • Check the operation of the steering handle.
Devices
• Check if the anode is securely installed.
Other parts
• Check the anode for corrosion and deformation.
Points to Check
normal.
the lock plate is there.
throttle grip.
lever.
check port after the engine has started.
plugs, the propeller, etc.
ENOW00078-0
WARNING
Do not use outboard motor if any abnor-
mality is found during pre-operation check
or it could result in severe damage to the
motor or severe personal injury.
Replenish
Clean or Replace
Replace
Replace
Replace
Replace
Replace
Fill to the upper level mark
on dipstick
Replace
Replenish or recharge
Retighten
Remedy or replace
Correct or replace
Clean or replace
Correct
Replace
Correct or replace
Adjust
Replace
Tighten
Repair
Repair
Repair if necessary
Replace
Remedy