Daihatsu TERIOS J100 Maintenance Manual page 10

MA–10
(4) Start the engine and wait for a little while until the engine
stops.
(5) Turn off the ignition switch.
(6) Jack-up the vehicle and support it with safety stands.
(Refer to the GI section.)
(7) Detach the fuel hose clips.
WARNING:
·
Never reuse the used hose clips. Failure to observe
this warning may lead to fire.
(8) Disconnect the fuel hoses from the fuel filter and plug the
disconnected hoses and fuel pipes of the fuel filter with a
suitable plug or the like.
CAUTION:
·
Quite a large amount of fuel will flow out during fuel
hose disconnection. Therefore, be sure to plug the dis-
connected hose and pipes properly.
(9) Remove the fuel filter from the fuel filter clamp.
Installation
(1) Install the fuel filter to the fuel filter clamp as shown.
CAUTION:
·
Be sure to install the fuel filter in such direction that the
"IN" mark of fuel filter faces to fuel pump side and
"OUT" mark faces to fuel pump side.
·
Failure to observe this caution may lead to fuel filter
malfunction.
(2) Insert new hose clips to the fuel hoses.
(3) Connect the fuel hoses to the fuel filter until the fuel hose
end comes in contact with the fuel filter body .
(4) Place the new fuel hose clips at each point between the
pipe end and the spool. Then remove the clip holder to
secure the fuel hoses.
CAUTION :
·
Never reuse the used hose clips.
(5) Install the fuel filler cap.
(6) Checking of fuel leakage
Perform the inspection described in the "Inspection of fuel
line and connection".
6. Inspection of charcoal canister
(1) Removal of charcoal canister
q Detach the hose bands from the hoses connected
to the charcoal canister.
CAUTION:
·
Never reuse the removed hose bands.
w Disconnect the rubber hoses from the upper side
of the charcoal canister.
NOTE:
·
Prior to the disconnection of the rubber hoses, put a
tag on each of the rubber hoses so that they may be
reconnected correctly to the original position.
Engine side
Fuel pump side
Charcoal canister
JMA00017-00012
JMA00018-00013
JMA00019-00014