Checking Motor Continuity; Sales Demo Mode - Whirlpool CALYPSO WashMotion GVW9959K-0 User Manual

Sales Demo Mode

The Sales Demo mode is activated by pressing:
within five (5) seconds. "Sd" should be displayed in the seven-segment display when activated and the
following cycle should progress. The STOP/CANCEL key can be used to return to standby mode at
any time during the cycle. No options are active during this cycle.
If the lid is opened during this cycle, the Peekaboo function will be active. This cycle should not require
the lid switch to be opened afterwards to run another cycle, (i.e. no "LS" check).
PHASE STEP DESCRIPTIO N O F
SEQ UENCE
DIAG NO STIC 1 NUTATE 150
2 SPIN 60
3 NUTATE 150
4 NUTATE 225
5 NUTATE 250
6 NUTATE 275
7 NUTATE 300
8 SPIN 800
RETURN TO STANDBY
CHECKING DRIVE AND PUMP MOTOR CONTINUITY
The pump and drive motors can be checked
for continuity. Disconnect power from the
washer and remove the front cabinet panel.
1. Disconnect the wiring harness plugs
from the drive and pump motor termi-
nal connectors.
2. Using the color codes shown in Fig.
4-4, and the resistance chart below.
Check for proper winding resistances.
RESISTANCE CHART
WINDING
COMPONENT
Drive Motor
RD to BK
YL to WH
RD to YL
Pump Motor
RD to WH
YL to WH
RD to YL
SOAK - WATER TEMP - SOAK - WATER TEMP
NOTES W ATER
TEM P
O FF
O FF
O FF
O FF
O FF
O FF
O FF
O FF
O FF
Drive
Motor
Connector
Green/
Black
Yellow
White
Black
RESISTANCE
VALUE
2 - 4 ohms
2 - 4 ohms
5 - 7 ohms
10 - 12 ohms
10 - 12 ohms
20 - 25 ohms
DISPENSER COM M ENT PUM P
M O TO R
ACTIO N
O FF
O FF
O FF
O FF
O FF
O FF
O FF
O FF
O FF
Red
NOTE: Color codes shown in Fig. 4-4 are for wires from
the motors to the connectors. Color codes for wires to
the wiring harness plugs are different.
See Section Five: TECH TIPS for complete
Wiring Diagram.
54
DRIVE DRIVE DURATIO N
M O TO R M O TO R
ACTIO N SPEED
O FF NUTATE 150
O FF SPIN 60
O FF NUTATE 150
O FF NUTATE 225
O FF NUTATE 250
O FF NUTATE 275
O FF NUTATE 300
O FF SPIN 800
O FF O FF
Pump
Motor
Connector
White
Red
Yellow
Green
Fig. 4-4
(SEC)
8
15
5
5
5
5
5
60
1:48