Table of Contents
Related Manuals for Groen TDH/C Series
Summary of Contents for Groen TDH/C Series
- Page 1 SPARE PARTS DIAGRAM FOR Steam Jacketed Kettle TDH/C First Choice Group Blakeney Way, Kingswood Lakeside Cannock, Staffs, WS11 8LD TEL: 01543 577778 FAX: 01543504141 Email: enquires@firstchoice-cs.co.uk Web: www.firstchoice-cs.co.uk...
- Page 2 ? ? IMPORTANT INFORMATION IMPORTANT INFORMATION ? ? KEEP FOR OPERATOR KEEP FOR OPERATOR ? ? IMPORTANT INFORMATION IMPORTANT INFORMATION? OPERATOR MANUAL OM-TDH/C Part Number 121049 DOMESTIC Model: TDH/C Steam Jacketed Kettle Self-contained Gas heated Table Top Mounted Crank-Tilting THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ, UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND WARNINGS CONTAINED IN THIS MANUAL.
-
Page 3: Important Operator Warnings
SUPPLY AND CLOSE THE MAIN GAS VALVE. ALLOW FIVE MINUTES FOR GAS TO VENT. CAUTION: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN OR AUTHORIZED DISTRIBUTORS CAN CAUSE INJURY TO THE OPERATOR AND DAMAGE TO THE EQUIPMENT AND WILL VOID ALL WARRANTIES. -
Page 4: Table Of Contents
OM-TDH/C Table of Contents IMPORTANT OPERATOR WARNINGS ......... . 2 EQUIPMENT DESCRIPTION . -
Page 5: Equipment Description
OM-TDH/C Equipment Description Groen Model TDH/C is a stainless steel, steam- Controls for the unit include a crank tilt handwheel, jacketed, table top mounted, crank-tilting kettle with thermostat, pressure gauge, safety valve, low water a self-contained, gas heated steam source. The... -
Page 6: Inspection & Unpacking
OM-TDH/C Inspection & Unpacking WARNING THIS UNIT MUST BE INSTALLED BY PERSONNEL WHO ARE QUALIFIED TO WORK WITH ELECTRICITY AND PLUMBING. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT. THE UNIT MUST BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES. The unit arrives completely assembled. -
Page 7: Installation & Initial Start-Up
DO NOT block any air intake spacings to the combustion chamber or 2. Groen recommends installation of the unit under a obstruct air flow. vent hood. The base must be fastened to the working surface. - Page 8 If the unit does not operate as designed, CAUTIONS, SAFETY INSTRUCTIONS contact authorized Groen Service Agent. CONTAINED IN THIS MANUAL. After the kettle has been installed, the installer should test to ensure that it is operating correctly. 1. Remove literature and packing materials from inside and outside of the unit.
-
Page 9: Operation
OM-TDH/C Operation WARNING ANY POTENTIAL USER OF THE EQUIPMENT MUST BE TRAINED IN SAFE AND CORRECT OPERATING PROCEDURES A. Controls 1. To Start Kettle Operator controls for the TDH/C kettle are: a. CHECK THE WATER LEVEL IN THE JACKET EVERY DAY. The level should 1. - Page 10 OM-TDH/C 2. To Stop Kettle Heating CAUTION DO NOT OVERFILL THE KETTLE WHEN a. Turn the thermostat dial to OFF. COOKING, HOLDING OR CLEANING. KEEP LIQUIDS 2-3” (5-8 cm) BELOW THE KETTLE b. Turn the toggle switch OFF. RIM TO ALLOW CLEARANCE FOR STIRRING, BOILING PRODUCT AND SAFE TRANSFER.
- Page 11 OM-TDH/C 2. Basket Insert a. An optional kettle basket insert can assist in cooking water-boiled products including eggs, potatoes, vegetables, shell fish, pasta and rice. The nylon mesh liner must be used when cooking product smaller than WARNING the mesh size of the basket, which is AVOID DIRECT CONTACT...
-
Page 12: Cleaning
OM-TDH/C Cleaning Suggested Cleaning Supplies: a. Cleaner, such as Klenzade HC-10 or HC-32 from ECOLAB, Inc. b. Kettle brushes in good condition. c. Sanitizer such as Klenzade XY-12. d. Film remover such as Klenzade LC CAUTION MOST CLEANERS ARE HARMFUL TO THE SKIN, Precautions EYES, MUCOUS MEMBRANES AND CLOTHING. -
Page 13: Maintenance
Obtain advice on the best sanitizing agent from your supplier of sanitizing products. Maintenance NOTICE: Contact Groen or an authorized Groen Service Agent when repairs are required. Service Log is provided at the rear of this manual. valve lever for about one second. Repeat... - Page 14 OM-TDH/C air escape from the jacket. Continue FAILURE CHECK SAFETY VALVE adding water until the water level rises to OPERATION PERIODICALLY COULD RESULT the center of the round sight glass. IN PERSONAL INJURY AND/OR DAMAGE TO EQUIPMENT. c. Close the gate valve. WHEN TESTING, AVOID ANY EXPOSURE TO d.
-
Page 15: Sequence Of Operation
Troubleshooting Your Groen kettle is designed to operate smoothly and efficiently if properly maintained. However, the following is a list of checks to make in the event of a problem. Wiring diagrams are furnished inside the service panel and in this manual. - Page 16 OM-TDH/C SYMPTOM WHAT TO CHECK Y Y indicates items which must be performed by an authorized technician. Safety Valve pops open Auth c. For defective thermostat. The thermostat should click when dial is Service rotated above and below kettle temperature. If defective, replace.Y Rep Only d.
- Page 17 OM-TDH/C Parts List To order parts, contact your Groen Certified Service Agency. Supply the model designation, part description, part number, quantity, and, where applicable, voltage and phase.
- Page 18 OM-TDH/C Parts List To order parts, contact your Groen Certified Service Agency. Supply the model designation, part description, part number, quantity, and, where applicable, voltage and phase. Description Part No. Description Part No. Description Part No. Weldment, TDH-40 122376 Assembly, Electrical Panel - TDH...
- Page 19 OM-TDH/C Parts List To order parts, contact your Groen Certified Service Agency. Supply the model designation, part description, part number, quantity, and, where applicable, voltage and phase. 15 16 12 14 17 13...
-
Page 20: Parts Lists
OM-TDH/C Parts List To order parts, contact your Groen Certified Service Agency. Supply the model designation, part description, part number, quantity, and, where applicable, voltage and phase. Description Part No. Description Part No. Assy, Elec. Mounting Bracket 124727 Screw, 6-32 x 3/8 lg self-tapping rnd head... -
Page 21: Schematic
OM-TDH/C Schematic... -
Page 22: Service Log
OM-TDH/C Service Log Model No. __________________________________ Purchased From _____________________________ Serial No. __________________________________ Location ____________________________________ Date Purchased _____________________________ Date Installed _______________________________ Purchase Order No. __________________________ For Service Call _____________________________ Date Service Performed Performed By... -
Page 23: References
OM-TDH/C References KLENZADE SALES CENTER ECOLAB. Inc. 370 Wabasha St. Paul, Minnesota 55102 800/352-5326 or 612/293-2233 NATIONAL FIRE PROTECTION ASSOCIATION 60 Battery March Park Quincy, Massachusetts 02269 NFPA/54 Installation of Gas Appliances & Gas Piping NFPA/70 The National Electrical Code NATIONAL SANITATION FOUNDATION 3475 Plymouth Rd. -
Page 24: Warranty
Groen Foodservice Equipment ("Groen Equipment") has been skillfully manufactured, carefully inspected and packaged to meet rigid standards of excellence. Groen warrants its Equipment to be free from defects in material and workmanship for (12) twelve months with the following conditions and subject to the following limitations. - Page 25 OM-TDH/C 1055 Mendell Davis Drive (Revised 4/99) Jackson, MS 39272 Part Number 121049 Phone 601 372-3903 Fax 601 373-9587...
Need help?
Do you have a question about the TDH/C Series and is the answer not in the manual?
Questions and answers