Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Generac Power Systems Trimmer/Mower
Summary of Contents for Generac Power Systems Trimmer/Mower
- Page 1 Owner’s Manual Trimmer/Mower™ 005813 MODEL NUMBER: _________________________ SERIAL NUMBER: _________________________ DATE PURCHASED:________________________ Register your Generac product at: WWW.GENERAC.COM 1-888-GENERAC (888-436-3722) SAVE THIS MANUAL FOR FUTURE REFERENCE...
- Page 2 WARNING CANCER AND REPRODUCTIVE HARM www.P65Warnings.ca.gov. (000393a) Owner’s Manual for Trimmer/Mower™...
-
Page 3: Table Of Contents
Section 2: General Information and Setup Replacing Wheels ............15 Troubleshooting ............16 Emissions ..............5 Remove Contents from Carton ........6 Installing Wheels ............6 Adjusting Trimmer/Mower......Handlebar 6 Installing Cutting Cords ..........6 Cutting Cord Tips ............6 Attaching Cord Caddy ..........7 Adding Oil ..............7 Adding Fuel ..............8 High Altitude Replacement Kit ........8... - Page 4 This page intentionally left blank. Owner’s Manual for Trimmer/Mower™...
-
Page 5: Section 1: Safety Rules & General Information Introduction
Section 1: Safety Rules & General Information Introduction DANGER Thank you for purchasing a Generac Power Systems Inc. product. This unit has been designed to provide high Indicates a hazardous situation which, if not avoided, performance, efficient operation, and years of use when will result in death or serious injury. -
Page 6: General Hazards
(000281) WARNING Risk of injury. Do not operate or service this machine if not fully alert. Fatigue can impair the ability to service this equipment and could result in death or serious injury. (000215) Owner’s Manual for Trimmer/Mower™... -
Page 7: Fire Hazards
(000249) WARNING Fire hazard. Do not obstruct cooling and ventilating airflow around the generator. Inadequate ventilation could result in fire hazard, possible equipment damage, death or serious injury. (000217) Owner’s Manual for Trimmer/Mower™... -
Page 8: Safety And Operating Decals
This unit features numerous safety and operating decals. These decals provide important operating instructions and warn of dangers and hazards. Replace damaged or missing safety and operating decals immediately. 006002 006705 006703 006701 006704 MUST ADD OIL ! 006706 006009 005999 Owner’s Manual for Trimmer/Mower™... -
Page 9: Section 2: General Information And Setup
It is important to TrimSafe Guard Kit follow the maintenance specifications in the manual to ensure that the engine complies with the applicable emis- sions standards for the duration of the product’s life. Owner’s Manual for Trimmer/Mower™... -
Page 10: Remove Contents From Carton
Remove any cord broken off flush at the line plate with needle nose pliers. 00952 • Do not add additional cords to the head. Adding addi- Figure 2-3. Lower Handlebar Bolts tional cords creates drag and may cause wrapping. Owner’s Manual for Trimmer/Mower™... -
Page 11: Attaching Cord Caddy
Oil must be added prior to operation. 1. Place unit on a firm, level surface, and verify engine is cooled. 2. See Figure 2-7. Remove oil dipstick/ fill cap (A) and wipe dipstick clean. 005958 Figure 2-7. Oil Fill and Dipstick Location Owner’s Manual for Trimmer/Mower™... -
Page 12: Adding Fuel
4. Fill tank with fresh, unleaded gas (with a minimum 85 octane rating) to 0.25 in (6.4 mm) from the bot- tom of the fill neck to allow for fuel expansion. 5. Install fuel fill cap. NOTE: Allow spilled fuel to evaporate before starting unit. Owner’s Manual for Trimmer/Mower™... -
Page 13: Section 3: Operation
Do not overfill. maintenance. 1. See Figure 1. Check engine oil level (A). See Attaching Cord Caddy for more information. 005958 005958 Figure 3-1. Oil and Fuel Fill 2. Check fuel level (B). Owner’s Manual for Trimmer/Mower™... -
Page 14: Starting The Unit
Do not lift the handlebar while operating the unit. Lifting the handlebar uses more energy, slows cut- ting speed, and produces an unsatisfactory cut. • The Trimmer/Mower‘™ can be used to trim or mow wet material. 005960 Figure 3-2. Primer Bulb •... -
Page 15: Section 4: Maintenance And Troubleshooting
Replace engine air filter cartridge and foam pre-filter if equipped Remove trimmer guard and clean out any collected debris Replace spark plug * Cleaning the top of the engine during use is critical for proper air flow. Owner’s Manual for Trimmer/Mower™... -
Page 16: Replacing Quick-Lock Head
(B), the quick lock with adapter (C), fol- lock (B) and adapter (C) onto the shaft lowed by the second spacer (B) onto shaft. 006359 Figure 4-4. Middle Cutting Height Setting 006356 Figure 4-2. Cord Head Assembly Owner’s Manual for Trimmer/Mower™... -
Page 17: Maintaining Cord Head
4-9. Assemble the plate and verify the plates align properly. The four screw holes on top must align and cutouts (I) should align from plate to 006359 plate on the sides. Figure 4-6. Cord Head Disassembly 006363 Figure 4-9. Plate Assembly Owner’s Manual for Trimmer/Mower™... -
Page 18: Replacing Trimmer Belt
Figure 4-11. Remove trimmer cords from head assembly. 3. Remove four trimmer guard bolts and flat washers (B) with a 3/8" wrench. Remove trimmer guard. 005958 Figure 4-13. Air Filter Replacement 006622 Figure 4-11. Trimmer Guard Owner’s Manual for Trimmer/Mower™... -
Page 19: Changing Engine Oil
5. Tighten the locknut with the wheel on the ground. Figure 4-15. Oil Range 9. If oil is low add a few ounces of oil at a time. Check dipstick frequently to prevent overfill. Do not overfill 10. Install oil fill cap/dipstick and hand-tighten. Owner’s Manual for Trimmer/Mower™... -
Page 20: Troubleshooting
Try to turn engine pulley by hand and with spark plug removed. If engine pulley turns the recoil is broken or jammed. Owner’s Manual for Trimmer/Mower™... - Page 21 Cords striking a stone, chain-link fence, or other obstacle. Approach hard obsta- cles slowly and avoid contact. Avoid pushing the trimmer head down into the ground. The trimmer/mower works ® best with the Mow-Ball resting easily on the ground or slightly raised.
- Page 22 Maintenance and Troubleshooting This page intentionally left blank. Owner’s Manual for Trimmer/Mower™...
- Page 24 ©2018 Generac Power Systems, Inc. Generac Power Systems, Inc. All rights reserved S45 W29290 Hwy. 59 Specifications are subject to change without notice. Waukesha, WI 53189 No reproduction allowed in any form without prior written 1-888-GENERAC (1-888-436-3722) consent from Generac Power Systems, Inc. www.generac.com...