Astria Fireplaces BerlinLights43ZEN Installation And Operation Instructions Manual

Stainless outdoor linear fireplace

Advertisement

P/N 126776-01 Rev. K 11/2019
Ce manuel est disponible en francais,
simplement en faire la demande. Numéro
de la pièce 126776-03.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
DANGER
CARBON MONOXIDE WARNING
• This appliance can produce carbon
monoxide which has no odor.
• Using it in an enclosed space can kill
you.
• Never use this appliance in an en-
closed space such as a camper, tent,
car or home.
WARNING: Do not store gasoline or other flammable vapors and liquids in the vicinity of this or any other appli-
ance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing prop-
erty damage, personal injury, or loss of life
DANGER:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result
in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
PFS
®
C
US
Report No. F12-052
P126776-01
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
WHEN USED AS AN OUTDOOR APPLIANCE
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open flame.
• If odor continues, leave the area immediately.
• After leaving the area, call your gas supplier or fire department.
Failure to follow these instructions could result in fire or explosion, which
could cause property damage, personal injury, or death.
WARNING: For Outdoor Use Only.
Installation and service must be performed by a qualified installer, service
agency, or the gas supplier.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Installation and Operation Instructions
Stainless Outdoor Linear Fireplace
Models
BerlinLights43ZEN
AVERTISSEMENT
RISQUED'INDENDIE OU D'EXPLOSION
Le non-respect Des avertissements de sécurité pourrait
d'entraîner des blessures graves, la mort ou des dommages
matériels.
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bâtiment où vous trouvez.
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de gaz depuis un
voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz, appelez
le service des incindies.
L'installation et l'entretien doivent être assurés par un instal-
lateur ou un service d'entretien qualifié ou par le fournisseur
de gaz.
BerlinLights43ZEP

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the BerlinLights43ZEN and is the answer not in the manual?

Questions and answers

Summary of Contents for Astria Fireplaces BerlinLights43ZEN

  • Page 1 Installation and Operation Instructions Stainless Outdoor Linear Fireplace ® Report No. F12-052 Models P/N 126776-01 Rev. K 11/2019 BerlinLights43ZEN BerlinLights43ZEP Ce manuel est disponible en francais, simplement en faire la demande. Numéro de la pièce 126776-03. P126776-01 INSTALLER: Leave this manual with the appliance.
  • Page 2: Table Of Contents

    Thank you for your purchase. We appreciate your TABLE OF CONTENTS business! Safety ..................... 2 Please carefully read and follow all instructions in this manual. Pay Local Codes ................... 3 special attention to all warnings and safety information. Requirements for the Commonwealth of Massachusetts....3 Following these safety, care, and operation instructions will help Product Identification ..............
  • Page 3: Requirements For The Commonwealth Of Massachusetts

    SAFETY Continued Children and adults should be alerted to the hazards 1. WARNING: This appliance is only for use with the type of gas of high surface temperatures and should stay away to indicated on the rating plate. This appliance is not convertible for use with other gases.
  • Page 4: Local Codes

    PRODUCT IDENTIFICATION LOCAL CODES Install and use fireplace with care. Follow all local codes. In the ab- sence of local codes, use the latest edition of The National Fuel Gas Code ANSI Z223.1/NFPA 54*; Natural Gas and Propane Installation Top Spacers Code, CSA B149.1;...
  • Page 5: Installation

    INSTALLATION Carefully follow the instructions below. This will ensure safe instal- CAUTION: This fireplace creates warm air cur- lation. rents. These currents move heat to wall surfaces next CLEARANCES to fireplace. Installing fireplace next to vinyl or cloth Minimum clearances to combustibles for the fireplace are as follows: wall coverings or operating fireplace where impurities *Back and sides 1"...
  • Page 6 INSTALLATION Continued 17-1/2” MOUNTED INSIDE OF (445 mm) FOR ONE SIDED NAILING FLANGE APPLICATION, STUDS (FLAT) 17-1/2” ARE NOT MOUNTED MOUNTED INSIDE OF (445 mm) FOR ONE SIDED TO THE REAR NAILING FLANGE APPLICATION, STUDS OF NAILING FLANGES Concrete (FLAT) ARE NOT MOUNTED Board TO THE REAR...
  • Page 7 INSTALLATION Continued " (445 mm) " " (298 mm) (419 mm) " (16 mm) " (210 mm) " (753 mm) " " (753 mm) (416 mm) " (181 mm) 1" " (1121 mm) (26 mm) 47" (1194 mm) 52" (1321 mm) "...
  • Page 8 INSTALLATION Continued Mantel Clearances for Built-In Installation CHECK GAS TYPE Use proper gas type for the fireplace unit you are installing. If you have If placing mantel above built-in fireplace, you must meet minimum conflicting gas types, do not install fireplace. See retailer where you clearance between mantel shelf and top of fireplace opening.
  • Page 9 INSTALLATION Continued cleaning. Install in piping system between fuel supply and fireplace. CAUTION: Use only new, black iron or steel pipe. Locate sediment trap where trapped matter is not likely to freeze. A Internally-tinned copper tubing may be used in certain sediment trap traps moisture and contaminants.
  • Page 10 INSTALLATION Continued CHECKING GAS CONNECTIONS Open Equipment WARNING: Test all gas piping and connections, Shutoff Valve internal and external to unit, for leaks after installing or servicing. Correct all leaks at once. WARNING: Never use an open flame to check for Closed a leak.
  • Page 11 INSTALLATION Continued FINISHING FIREPLACE FOR INSTALLATION UPGRADING BERLINLIGHTS43 TO SEE-THRU APPLICATION The BerlinLights43 series fireplace come with the rear panel semi- Removing Rear Panel installed. If you will be using the fireplace for a one sided regular 1. In the rear of the fireplace, locate screws at top of rear panel and application, you will need to finish the installation of the rear panel.
  • Page 12 INSTALLATION Continued Removing False Door Installing Access Door Retaining Brackets 1. In the rear of the fireplace, Unlock 3 door latches on top of 1. Screw access door retaining brackets into the inner side face using firebox using your fingers or the latch opener provided. 2 screws on both the left and right side as shown in Figure 20.
  • Page 13 INSTALLATION Continued Installing Access Door 5. Light switch is located on the right hand side as shown in Figure 24. 6. ON/OFF switch is located on the left hand side as shown in Figure 24. 1. Place access door in front of fireplace opening with the slanted side facing forward.
  • Page 14 INSTALLATION Continued • Pushing and holding the LEARN button for 6 seconds will result DRAFT SHIELD KIT INSTALLATION (F1031) in clearing the transmitter security code from the module's WARNING: Do not change or substitute glass memory. The module will make three long beeps in succession when it has been cleared.
  • Page 15: Operation

    OPERATION 2. Make sure equipment shutoff valve is fully open. FOR YOUR SAFETY 3. Turn safety shutoff switch to the OFF position. READ BEFORE LIGHTING 4. Remove access cover. 5. Turn equipment shutoff valve clockwise to the OFF position WARNING: If you do not follow these instructions (see Figure 29).
  • Page 16: Cleaning And Maintenance

    CLEANING AND MAINTENANCE Burner Ports/Slots WARNING: Turn off fireplace and let cool before cleaning. CAUTION: You must keep control areas, burner and circulating air passageways of fireplace clean. Inspect these areas of fireplace before each use. Have Venturi fireplace inspected yearly by a qualified service person. Air Shutter WARNING: Failure to keep the primary air Figure 30 - Injector Holder On Outlet Burner Tube...
  • Page 17: Wiring Diagram

    WIRING DIAGRAM 126776-01K Astria.us.com...
  • Page 18: Troubleshooting

    TROUBLESHOOTING WARNING: Turn off appliance and let cool before servicing. Only a qualified service person should service and repair appliance. NOTE: All troubleshooting items are listed in order of operation. Remote /Igniter has a special feature. It will allow heat from the burner to dry the probe and burner assembly due to excess moisture, caused by rain, humidity or condensation.
  • Page 19 TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Delayed ignition of burner 1. Manifold pressure is too low 1. Contact local natural or propane/LP gas company 2. Burner orifice clogged 2. Clean burner (see Cleaning and Main- tenance, Page 19) or replace burner orifice(s) Burner backfiring during combustion 1.
  • Page 20 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Leave the building immediately •...
  • Page 21: Parts

    PARTS MODELS BERLINLIGHTS43ZEN AND BERLINLIGHTS43ZEP WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifi- cally approved with this heater may result in property damage or personal injury. 126776-01K Astria.us.com...
  • Page 22 Page 25 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not ap- proved by IHP. Use of non-approved parts can result in poor performance and safety hazards. BerlinLights43ZEN BerlinLights43ZEP CATALOG NO. DESCRIPTION QTY.
  • Page 23 PARTS MODELS BERLINLIGHTS43ZEN AND BERLINLIGHTS43ZEP 126776-01K Astria.us.com...
  • Page 24 PARTS MODELS BERLINLIGHTS43ZEN AND BERLINLIGHTS43ZEP This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 25 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not ap- proved by IHP.
  • Page 25: Specifications

    SPECIFICATIONS ACCESSORIES BerlinLights43ZEN Purchase these accessories from your local dealer. If they can • Rating (Variable): 25/39,000 Btu/Hr not supply these accessories contact IHP at Astria.us.com for • Gas Type: Natural Gas information. • Ignition: Electronic • Pressure Manifold Setting: 3.5" W.C.
  • Page 26 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ Astria.us.com 126776-01K...
  • Page 27: Warranty

    Innovative Hearth Products Astria Brand Gas Fireplace ® Limited Lifetime Warranty THE WARRANTY Innovative Hearth Products ("IHP") Limited Lifetime Warranty warrants your Astria brand gas fireplace ("Product") to be free from defects in materials and workmanship ® at the time of manufacture. The product body, firebox and barrier carry the Limited Lifetime Warranty. Ceramic glass carries the Limited Lifetime Warranty against thermal breakage only.
  • Page 28 Astria.us.com Record the following important information about your appliance: Appliance model number Appliance serial number Date appliance was Installed Type of gas appliance uses Dealer name Innovative Hearth Products (IHP) reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.

This manual is also suitable for:

Berlinlights43zep

Table of Contents