Download
Share
Print this page
Husqvarna LP 6505 Operator's Manual
  1. Manuals
  2. Brands
  3. Husqvarna Manuals
  4. Construction Equipment
  5. LP 6505
  6. Operator's manual

Husqvarna LP 6505 Operator's Manual

Hide thumbs

Advertisement

Quick Links

LP 6505, LP 7505
EN
Operator's manual
2-24

Advertisement

loading

Related Manuals for Husqvarna LP 6505

Summary of Contents for Husqvarna LP 6505

  • Page 1 LP 6505, LP 7505 Operator's manual 2-24...

  • Page 2: Table Of Contents

    Contents Introduction..............2 Transportation, storage and disposal......19 Safety................4 Technical data.............. 21 Operation................ 9 EC Declaration of Conformity........24 Maintenance..............12 Introduction Product overview 1. Vibration control, ON/OFF 15. Air filter 2. Control for forward and rearward movement 16. Engine oil filter 3.
  • Page 3 Control panel overview Use protective boots. Hydraulic oil level. XXXXXXX Hydraulic oil filter. Electrical start. The battery charges. 1. Operation indicator. This LED comes on when the engine is on. 2. Error indicator for battery charge. This LED comes Hour meter. on if the battery does not charge correctly.

  • Page 4: Safety

    Note: Other symbols/decals on the product refer to special certification requirements for some markets. Type plate Lifting point on the safety frame. Tie-down bracket. Water nozzle. 1. Product type 2. Product number 3. Product weight Water tank. 4. Serial number 5.
  • Page 5 • Do not let a person operate the product unless they • Before you go away from the product, stop the read and understand the contents of the operator's engine and make sure that there is no risk of manual. accidental start.
  • Page 6 • Keep your hands on the handle or handles only. • Do not use a combustion engine product indoors or Keep all other body parts away from the product. in areas that do not have sufficient airflow. • Stop the product immediately if strong vibrations •...
  • Page 7 • Do a check of the safety devices regularly. If the safety devices are defective, speak to your Husqvarna service agent. Muffler The muffler keeps the noise levels to a minimum and sends the exhaust fumes away from the operator.
  • Page 8 WARNING: Read the warning instructions has a deformation or is damaged, speak to that follow before you use the product. an approved Husqvarna service agent. • There is a risk that the product falls when you operate it near an edge. Always keep a minimum of ⅔...

  • Page 9: Operation

    • Only do the maintenance as given in this operator's • After maintenance, do a check of the vibration level manual. Let an approved service center do all other in the product. If it is not correct, speak to an servicing.
  • Page 10 1. Make sure that the control for forward and rearward 5. Remove the start handle from the transport position movement (A) is in the neutral position. (A) and put it in the connection for the start handle (B). 2. Make sure that the vibration control (B) is in the OFF position.
  • Page 11 3. Set the throttle control to idle speed. 7. Set the throttle control to full throttle. 4. Turn the ignition key to the ignition position (A). The To operate the product indicators for battery charge and oil pressure come Always operate the product with the throttle control set to full throttle.

  • Page 12: Maintenance

    2. Set the throttle control to idle speed. 5. If the engine has an electrical start, do also these steps: a) Turn the ignition key to the stop position (A). 3. Let the engine operate at idle speed for 2–3 minutes. 4.
  • Page 13 General product maintenance Before use, Weekly, Monthly, Yearly, each each 10 h each 100 h each 250 h 500 h Examine the safety straps for damage. Replace if it is necessary. Examine the vibration damping units for damage. Make sure that the scrapers do not touch the drums. Ad- just the clearance if it is necessary.
  • Page 14 3. Remove the oil drain plug (A) and remove the end the product. plug from the oil drain hose (B). a) LP 6505: b) LP 7505: 2. Examine the screws and nuts on the safety straps. 3. Replace damaged safety straps.
  • Page 15 To drain the water separator a) LP 6505: 1. Remove the drain plug for the water separator. 2. Drain until there is only clean fuel in the bowl. b) LP 7505: 3. Install the drain plug. 4. Discard the water as chemical waste. Refer to Disposal on page 20 .
  • Page 16 To clean or replace the air filter a) For model LP 6505, make sure that the container is a minimum of 0.6 l/qts. WARNING: Use approved respiratory b) For model LP 7505, make sure that the container protection when you clean or replace the air is a minimum of 0.9 l/qts.
  • Page 17 We recommend a 2-stage charger with constant voltage that automatically decreases to trickle charging when the battery is fully charged. Speak to your Husqvarna dealer for information about the correct battery charger. • Do a trickle charging 1-2 times during the winter season when the product is in storage.
  • Page 18 To replace the hydraulic oil filter 2. Use an oil drain pump to drain the hydraulic oil from the hydraulic oil tank. 1. Clean the area around the cover (A) for the hydraulic 3. Clean the opening of the hydraulic oil tank. oil filter.

  • Page 19: Transportation, Storage And Disposal

    5. Install the spacer (C) to a new hydraulic oil filter (D). 7. Install the cover for the hydraulic oil filter. Make sure that the cover is installed correctly in the notch. 6. Examine the O-ring (E). Replace it if it is damaged. 8.
  • Page 20 • Do not discard the battery as domestic waste. • Send the battery to a Husqvarna service agent or discard it at a disposal location for used batteries. WARNING: Do not use metal hooks, chains or other lifting equipment with...

  • Page 21: Technical Data

    Technical data Technical data LP 6505 LP 7505 Net weight, manual start, kg/lb 716/1579 952/2099 Net weight, electrical start, kg/lb 736/1623 972/2143 Operation weight (EN500, incl. oil, ½ fuel), man- 745/1642 981/2163 ual start, kg/lb Operation weight (EN500, incl. oil, ½ fuel), elec-...
  • Page 22 Noise and vibration emissions LP 6505 LP 7505 Sound power level, measured dB (A) Sound power level, guaranteed L dB (A) Sound pressure level at the operator's ear, L , dB (A) Vibration level, a , m/s Noise and vibration declaration...
  • Page 23 Product dimensions Pos. Description LP 6505 LP 7505 Handle height, operation position, mm/in. 1215/47.8 1260/49.6 Length with handle folded, handle included, mm/in. 1395/54.9 1395/54.9 Drum diameter, mm/in. 400/15.7 400/15.7 Distance between front and rear drum axles, mm/in. 520/20.5 520/20.5 Length with handle folded, handle not included, mm/in.

  • Page 24: Ec Declaration Of Conformity

    EC Declaration of Conformity EC Declaration of Conformity We, Husqvarna AB, SE-561 82 Huskvarna, Sweden, tel: +46-36-146500, declare on our sole responsibility that the product: Description Drum Roller Compaction Machine Brand Husqvarna Type/Model LP 6505, LP 7505 Identification Serial numbers dating from 2019 and onwards...
  • Page 25 1364 - 001 - 25.03.2020...
  • Page 26 1364 - 001 - 25.03.2020...
  • Page 27 1364 - 001 - 25.03.2020...
  • Page 28 www.husqvarnacp.com Original instructions 1140346-26 2020-04-03...

This manual is also suitable for:

Lp 7505