Page 1 5075 Kimberly Way 813 Hope Court 2020 Owners Manual 2020 Owners Manual Loudon, TN 37774 Albury, N.S.W. 2640 (865) 458-5478 (02) 6040-1174...
Page 2 Operating, service and maintaining a recreational marine vessel can expose you to chemicals including engine exhaust, carbon monoxide, phthalates, and lead, which are known to the State of California to cause cancer and birth defects or other reproductive harm. To minimize exposure, avoid breathing exhaust, service your vessel in a well-ventilated area and wear gloves or wash your hands frequently when servicing this vessel.
Page 3 Congratulations on your purchase of a new high-performance recreational tow boat! Your Malibu Boat (“Malibu”) boat by Malibu Boats LLC has been constructed to meet and/or exceed all U.S. Coast Guard (USCG) and National Marine Manufacturers Association (NMMA) requirements applicable at the time of its manufacture. However, it is still your responsibility as the boat owner to ensure the boat is operated in a safe manner and is properly maintained.
Page 5 about your new boat Malibu is proud to provide you with the most exciting, cutting-edge technology available in the towing-boat industry. The boat you have purchased represents the state of the art at the time of manufacture. As you may expect from the industry’s leader since 1982, Malibu expands and innovates continually.
Page 6: Table Of Contents
Visibility of the Operator ..........................22 Boating Under the Influence ........................23 Product Misuse..............................23 Reporting Accidents............................23 Rendering Assistance ...........................24 Hazardous Conditions ..........................24 Environmental Concerns ..........................25 On Product Warning Labels ........................27 Warning Labels and Locations ........................27 2020 Malibu Boats LLC • Owner’s Manual • Page iv...
Page 7 Medical Emergency ............................48 Operation Failure ............................48 Towing ................................48 Quick Reference Guide Response TXi ..............................52 Wakesetter 20VTX ............................54 Wakesetter 21MLX ............................56 Wakesetter 21VLX ............................58 Wakesetter 22LSV ............................60 Wakesetter 23LSV ............................62 Wakesetter 25LSV ............................64 2020 Malibu Boats LLC • Owner’s Manual • Page v...
Page 8 TXi Standard Gauges and Screen ......................91 Gauges ................................91 Keypad ................................92 Center Screen ..............................92 Cruise Screen ..............................92 Engine Screen ..............................92 Depth Screen ..............................92 Alerts ...................................93 Warnings ................................93 Lights Menu ..............................93 2020 Malibu Boats LLC • Owner’s Manual • Page vi...
Page 9 Port Rear Breaker Board ..........................117 Surf Band ................................ 118 Alarms ................................118 Malibu Monsoon Engines, Transmissions & V-Drives Malibu Monsoon Engines, Transmissions & V-Drives ..............122 Safety ................................122 2020 Malibu Boats LLC • Owner’s Manual • Page vii...
Page 10 Emergency Engine Stop Switch ......................145 Lighting................................146 Tie-Ups ................................147 Horn ................................. 149 Mirror ................................149 Ladder ................................149 Fuel Fill ................................150 Interior Performance ........................... 151 Steering Wheel ............................. 151 Shifter/Throttle ............................. 152 2020 Malibu Boats LLC • Owner’s Manual • Page viii...
Page 11 Shower ................................177 Flush Kit ................................178 Swim Board and Ladders .......................... 179 Salt Water Series ............................180 Trailers Reporting Safety Defects .......................... 184 Legal Requirements for Towing ......................184 2020 Malibu Boats LLC • Owner’s Manual • Page ix...
Page 12 Towing Advice ..............................207 Prior to Towing ............................. 207 Pre-Tow Check List ............................207 Underway ............................... 207 Launching and Re-Loading the Boat from the Trailer ..............208 Cleaning, Maintenance and Storage ....................211 2020 Malibu Boats LLC• Owner’s Manual • Page x...
Page 13 Flush Kit ................................240 Corrosion in Fresh Water ........................... 241 Routine Maintenance ..........................241 Before Starting the Engine ........................243 Check Coolant Level ........................... 243 Inspect the Sea Strainer ..........................243 2020 Malibu Boats LLC • Owner’s Manual • Page xi...
Page 14 Winterizing Boats Equipped with Optional Flush Kit ..............258 Extended Storage and Winterization ....................260 Maintenance Schedule..........................263 Warranty Malibu Boats LLC Limited Warranty ......................266 Warranty Transfer............................278 California and U.S. EPA Emission Control Warranty Statement ............279 2020 Malibu Boats LLC• Owner’s Manual • Page xii...
Page 15 Troubleshooting the Boat ....................... 281 Troubleshooting the Trailer ......................284 Service Log ..............................286 Index .................................. 288 2020 Malibu Boats LLC• Owner’s Manual • Page xiii...
Page 16: Safety
Safety...
Page 18: Embracing Safety
These incidents are mostly caused by operator inattention, operator inexperience, reckless operation, alcohol/drug use, excessive speed, passenger or towed person behavior, and violation of navigation rules. 2020 Malibu Boats LLC • Owner’s Manual • Page 4...
Page 19: Pre-Operation Check List-Before Leaving The Dock
• If gasoline vapors persist after running the blower, DO NOT attempt to start the engine. Likely, there is a gasoline leak that is creating the excessive vapor. • Always operate blower below cruising speed and after stopping the boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 5...
Page 20: Precautions While Underway
• Not go under the boat cover with the engine running or shortly after the engine has been running because CARBON MONOXIDE may remain under the cover. Remove cover to ventilate the area. Failure to follow these precautions may result in severe injury or death to you and/or others. 2020 Malibu Boats LLC • Owner’s Manual • Page 6...
Page 21 • NEVER allow any type of spark or open flame on board. It may result in fire or explosion. • Avoid grounding the boat: Be familiar with local conditions and water depth. If you are uncertain, then 2020 Malibu Boats LLC • Owner’s Manual • Page 7...
Page 22: Safety While Maintaining The Vessel
• Only lift the boat from approved lift points, which are identified in later parts of this owner’s manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 8...
Page 23: Owner Responsibility And Boating Education
Improper operation or trailering of the boat may also damage the boat. The operator and the boat owner assume all risks for themselves, their 2020 Malibu Boats LLC • Owner’s Manual • Page 9...
Page 24: Registration
(if different than the owner). Common sense dictates that you carry adequate personal liability and property damage insurance on your boat, just as you would on your automobile. Many states have laws 2020 Malibu Boats LLC • Owner’s Manual • Page 10...
Page 25: Boating Safety Education Opportunities
In addition to the USCG regulations, other local and/or international law enforcement agencies may have similar requirements. You should check with your local marine law enforcement agency regarding any such requirements before boating. 2020 Malibu Boats LLC • Owner’s Manual • Page 11...
Page 26: Safety And Required Equipment
Emergency Safety Lanyard system as failure to do so can cause death or serious injury. DO NOT operate the boat if the Emergency Safety Lanyard system does not function properly. 2020 Malibu Boats LLC • Owner’s Manual • Page 12...
Page 27: Personal Flotation Devices
It is less bulky and less expensive than Type II a Type I, and many will turn an unconscious person face up in the water. 2020 Malibu Boats LLC • Owner’s Manual • Page 13...
Page 28: Fire Extinguisher
26 feet in length. Check periodically to ensure that the extinguisher is in working condition and fully charged. Check local, state and federal agencies as to laws and regulations. 2020 Malibu Boats LLC • Owner’s Manual • Page 14...
Page 29: Horn Or Whistle
We recommend the following equipment: • First aid kit and manual • Anchor with at least 75 feet (23 meters) of line • Mooring lines and fenders • Bailing device (bucket, hand pump) 2020 Malibu Boats LLC • Owner’s Manual • Page 15...
Page 30 A non-electric horn or whistle • Extra engine oil • Tool kit • Spare propeller and mounting hardware • Spare fuses • Spare keys • Sunglasses and sun block lotion 2020 Malibu Boats LLC • Owner’s Manual • Page 16...
Page 31: General Boating Safety Topics
DO NOT allow objects, arms or legs, or any other body parts to hang over the  bow or gunnels. Stay within the boat. Passengers should not sit in locations that obstruct the operator’s visibility.  2020 Malibu Boats LLC • Owner’s Manual • Page 17...
Page 32: Carbon Monoxide Safety
• In the event that someone exhibits the symptoms of carbon monoxide exposure (nausea, headache, dizziness, or drowsiness), have them breathe fresh air and, if necessary, immediately seek medical attention. 2020 Malibu Boats LLC • Owner’s Manual • Page 18...
Page 33 Hazardous boating situations involving carbon monoxide include: Blockage of boat exhaust by obstruction. Exhaust traveling along obstruction. Operating at slow speed or while dead in the water. Operating with high bow angle. 2020 Malibu Boats LLC • Owner’s Manual • Page 19...
Page 34 Washington, DC 20593-7581 (ww.uscgboating.org/safety/carbon_monoxide.aspx) NMMA 231 S. LaSalle St., Suite 2050 Chicago, IL 60604 312-946-6200 www.nmma.org American Boat & Yacht Council, Inc. 613 Third Street, Suite 10, Annapolis, MD 21403 410-956-4460 www.abycinc.org 2020 Malibu Boats LLC • Owner’s Manual • Page 20...
Page 35: Proper Loading
When loading your boat, give attention to the effect that the load distribution has on the boat’s trim angle. Trim angle is the technical term for the up or down pitch angle of your boat (also known as the “bow up” or “bow 2020 Malibu Boats LLC • Owner’s Manual • Page 21...
Page 36: Visibility Of The Operator
Rules of the Road. Be alert and keep a visual check for other boats in and around your intended path. Do not turn or maneuver your 2020 Malibu Boats LLC • Owner’s Manual • Page 22...
Page 37: Boating Under The Influence
$500 is incurred, or there is a complete loss of the boat. In these situations, a formal report must generally be filed within 10 days. If any of these events occur, seek further assistance from local 2020 Malibu Boats LLC • Owner’s Manual • Page 23...
Page 38: Rendering Assistance
Whenever possible familiarize yourself with navigation charts, depth charts, and waterway maps before you go boating. The following information outlines some of the most common hazards which may be encountered: 2020 Malibu Boats LLC • Owner’s Manual • Page 24...
Page 39: Environmental Concerns
Check local, state, country agencies as to laws and regulations. 2020 Malibu Boats LLC • Owner’s Manual • Page 25...
Page 40 DO NOT use products which contain phosphates, chlorine, solvents, non-biodegradable or petroleum based products. Refer to the Care and Maintenance section in this manual for more information. 2020 Malibu Boats LLC • Owner’s Manual • Page 26...
Page 41: On Product Warning Labels
READ AND ADHERE TO ALL WARNING PLATES AND LABELS from bow to stern, including those that are installed inside the engine compartment, lockers, and underneath seating. 2020 Malibu Boats LLC • Owner’s Manual • Page 27...
Page 42 Wakesetter Label Locations 2020 Malibu Boats LLC • Owner’s Manual • Page 28...
Page 43 BOAT SHOULD BE PERFORMED ONLY BY MALIBU TRAINED CERTIFIED TECHNICIANS USING IDENTICAL FUEL SYSTEM COMPONENTS.” FUEL CAP DECALS DECK SEAT DECAL TRANSOM DECALS WHERE EQUIPPED - (MODEL SPECIFIC) NOTICE ENSURE CAP IS TIGHT FOR PROPER COOLING SYSTEM PERFORMANCE 2020 Malibu Boats LLC • Owner’s Manual • Page 29...
Page 44 Response TXi Label Locations 2020 Malibu Boats LLC • Owner’s Manual • Page 30...
Page 45: Basic Rules Of The Road
When you maintain your direction and speed, the other vessel will be able to determine how best to avoid you. 2020 Malibu Boats LLC • Owner’s Manual • Page 31...
Page 46: Burdened Vessel
(port-to-port). However, if both boats are clearly on each other’s right (starboard) side then, each vessel should sound two short blasts and pass on their right sides (starboard-to-starboard). 2020 Malibu Boats LLC • Owner’s Manual • Page 32...
Page 47: Overtaking
The type of hazard/warning buoys and markers depends on the area of jurisdiction. Check with local boating authorities. USWMS System In the USWMS Lateral System, well-defined channels are marked with red and black buoys, and the boat should pass between them. 2020 Malibu Boats LLC • Owner’s Manual • Page 33...
Page 48 Mooring to a navigation buoy, regulatory markers or lateral markers is illegal. lighted buoy can buoy mooring buoy white with blue unlighted bell buoy spar buoy nun buoy band may show white reflector or light 2020 Malibu Boats LLC • Owner’s Manual • Page 34...
Page 49 It is a good idea to ask local authorities if there are hazardous areas and how they are marked. Boaters must also recognize the flag designs, which indicate that skin divers are present and keep well clear of the area. Divers underwater cannot be seen. Stay well away from boats or floats displaying Diver Flags. Watch for swimmers. Swimming areas may not be marked. Steer clear from the area and remain alert. sKin diver warning flag swim area warning buoy 2020 Malibu Boats LLC • Owner’s Manual • Page 35...
Page 50: Night Running
For most applications on recreational boats the following navigation light patterns are applicable. (NOTE: Information is included here that does not apply to Malibu boats. However, the information is included here to assist Malibu operators in being aware of the navigational lights that may appear on other vessels you may encounter.)
Page 51 (flashlight) prescribed for a power-driven boat. showing a white light to be displayed in sufficient time to prevent collision (see Figure 2020 Malibu Boats LLC • Owner’s Manual • Page 37...
Page 52: Watersports Safety
DO NOT participate in watersports during inclement weather or on rough water. • Never water ski, wakeboard or participate in other towed watersports directly in front of other boats who may run over you if you fall. 2020 Malibu Boats LLC • Owner’s Manual • Page 38...
Page 53: Hand Signals
Return safely to pick up towed persons or persons in the water. Keep the individual in view, approach slowly (preferably on the driver’s side), and shut off the engine when close to an individual in the water. DO NOT back up or operate the boat in reverse to a person in the water. 2020 Malibu Boats LLC • Owner’s Manual • Page 39...
Page 54: Additional Precautions For Towed Skier/Rider
DO NOT jump from a boat that is moving at any speed, nor enter or exit the water when the engine is running. DO NOT “back up” to anyone in the water, they will be in danger of hitting the spinning propeller which can • cause severe injury or death. 2020 Malibu Boats LLC • Owner’s Manual • Page 40...
Page 55 Around marina docks where electrical current is present (such as shore power connections) it is unsafe to swim as stray electrical currents may exist, which can cause you to drown. 2020 Malibu Boats LLC • Owner’s Manual • Page 41...
Page 56: Tow Line Guidelines
Know the federal, state and local laws that apply to your area. • If you are not familiar with a waterway, ask someone who is knowledgeable to tell you about any hidden 2020 Malibu Boats LLC • Owner’s Manual • Page 42...
Page 57 Make sure the engine is properly tuned and running well. An improperly tuned engine produces excessive exhaust and CO. • If you smell engine exhaust do not stay in that position. • Go to the United States Coast Guard’s website: (www.uscgboating.org) for more information on how to help protect yourself and others from the dangers of CO. 2020 Malibu Boats LLC • Owner’s Manual • Page 43...
Page 58 The Warnings and practices in the Watersports Safety Code represent common risks encountered by users. The code does not cover all instances of risk or danger. Please use common sense and good judgment. 2020 Malibu Boats LLC • Owner’s Manual • Page 44...
Page 59: Emergency Procedures
Gasoline will float on top of water and can burn. If the boat is abandoned, swim upwind, far enough to avoid fuel that can spread over the surface of the water. 2020 Malibu Boats LLC • Owner’s Manual • Page 45...
Page 60: Swamping And Flooding
Assess the hull for damage. • Activate the bilge pump(s) to reduce any flooding. • Try to operate the boat to keep the damaged area above water. • If necessary, call or signal for assistance. STAY WITH THE BOAT! • 2020 Malibu Boats LLC • Owner’s Manual • Page 46...
Page 61: Grounding
• Keep the victim on the helm side of the vessel so as to keep the victim constantly in your sight. • When almost alongside, shut off the engine. • Assist the person into the boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 47...
Page 62: Drowning
Keep slack out of the tow line, but if it occurs proceed slowly to again take up the strain on the line and avoid sudden jerks in the line. 2020 Malibu Boats LLC • Owner’s Manual • Page 48...
Page 63 Keep hands and feet clear of the other boat. Do not get caught, or pinched between the two boats as severe injury could occur. • Never hold a towline after it is pulled taut. 2020 Malibu Boats LLC • Owner’s Manual • Page 49...
Page 64 A t p r e s s t i m e , u p - t o - d a t e o v e r h e a d i m a g e s o f t h e b o a t s w e r e n o t a v a i l a b l e .
Page 65: Quick Reference Guide
Quick Reference Guide W e i g h t c a p a c i t i e s s h o w n r e f l e c t t h e b e s t - a v a i l a b l e i n f o r m a t i o n a t p r e s s t i m e .
Page 66 17 - back up camera — where equipped stern above swim board 18 - engine exhaust & port starboard beneath swim board 19 - aft drain plug stern below swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 52...
Page 67: Response Txi
........5 people total, closed bow 987 lbs., open bow; including people; 705 lbs., closed bow; including people 350 lbs., maximum in bow Response TXi (Available also as Malibu Open Edition; open or closed bow) 2020 Malibu Boats LLC • Owner’s Manual • Page 53...
Page 68 39 - back up camera — ladder where equipped center transom wedge plate 40 - swim board surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 54...
Page 69: Wakesetter 20Vtx
......27”/0.7 m draft ......39 gal/148 l fuel ....T-cut diamond hull type ......11 people total (2 in bow) capacity 1,551 lbs., including people 350 lbs., maximum in bow Wakesetter 20VTX 2020 Malibu Boats LLC • Owner’s Manual • Page 55...
Page 70 33 - swim board center transom 15 - under swim board underwater lights ladder wedge plate surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 56...
Page 71: Wakesetter 21Mlx
......27”/0.7 m draft ......48 gal/182 l fuel ....Wake Plus hull type ......14 people total (3 in bow) capacity 1,974 lbs., including people 500 lbs., maximum in bow Wakesetter 21MLX 2020 Malibu Boats LLC • Owner’s Manual • Page 57...
Page 72 33 - swim board center transom 15 - under swim board underwater lights ladder wedge plate surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 58...
Page 73: Wakesetter 21Vlx
......27”/0.7 m draft ......48 gal/182 l fuel ....Wake Plus Diamond hull type ......13 people total (3 in bow) capacity 1,833 lbs., including people 500 lbs., maximum in bow Wakesetter 21VLX 2020 Malibu Boats LLC • Owner’s Manual • Page 59...
Page 74 — where equipped center transom ladder 41 - wedge plate swim board surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 60...
Page 75: Wakesetter 22Lsv
......14 people total (3 in bow) capacity 1,974 lbs., including people 500 lbs., maximum in bow Wakesetter 22LSV 2020 Axis Wake Research • Owner’s Manual • Page 13 2020 Malibu Boats LLC • Owner’s Manual • Page 61...
Page 76 — where equipped center transom ladder 41 - wedge plate swim board surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 62...
Page 77: Wakesetter 23Lsv
......15 people total (3 in bow) capacity 2,115 lbs., including people 500 lbs., maximum in bow Wakesetter 23LSV 2020 Axis Wake Research • Owner’s Manual • Page 13 2020 Malibu Boats LLC • Owner’s Manual • Page 63...
Page 78 — where equipped center transom ladder 41 - wedge plate swim board surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 64...
Page 79: Wakesetter 25Lsv
......18 people total (3 in bow) capacity 2,538 lbs., including people 500 lbs., maximum in bow Wakesetter 25LSV 2020 Axis Wake Research • Owner’s Manual • Page 13 2020 Malibu Boats LLC • Owner’s Manual • Page 65...
Page 80 16 - under swim board 40 - swim board underwater lights ladder wedge plate surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 66...
Page 81: Wakesetter 22Mxz
......27”/0.7 m draft ......48 gal/181 l fuel ....Wake Plus hull type ......15 people total (4 in bow) capacity 2,115 lbs., including people 600 lbs., maximum in bow Wakesetter 22MXZ 2020 Malibu Boats LLC • Owner’s Manual • Page 67...
Page 82 16 - under swim board 40 - swim board underwater lights ladder wedge plate surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 68...
Page 83: Wakesetter 23Mxz
......TBD draft ......58 gal/220 l fuel ....Wake Plus hull type ...... 16 people total ( in bow) capacity 2,256 lbs., including people 600 lbs., maximum in bow Wakesetter 23MXZ 2020 Malibu Boats LLC • Owner’s Manual • Page 69...
Page 84 16 - under swim board 40 - swim board underwater lights ladder wedge plate surf gate power wedge — where equipped all are located beneath the swim board 2020 Malibu Boats LLC • Owner’s Manual • Page 70...
Page 85: Wakesetter 24Mxz
......32”/0.8 m draft ......77 gal/291 l fuel ....Wake Plus hull type ......18 people total (4 in bow) capacity 2,538 lbs., including people 600 lbs., maximum in bow Wakesetter 24MXZ 2020 Malibu Boats LLC • Owner’s Manual • Page 71...
Page 86: Recommended Seating
At no time should all passengers ride in the bow as it can cause a loss of stability and maneuverability. Never allow riders on the sun deck while the boat is in motion. 20VTX 21MLX 21VLX 2020 Malibu Boats LLC • Owner’s Manual • Page 72...
Page 87 Adhere to the load capacity plate restrictions and always account for persons, gear and all non-factory-installed ballast or other equipment. 25LSV 22LSV 23LSV 24MXZ 22MXZ 23MXZ 2020 Malibu Boats LLC • Owner’s Manual • Page 73...
Page 88: Dashes And Video Screens
Dashes and Video Screens...
Page 90: Malibu Operating System
Upon successful entry of the ENGINE START CODE, the driver will press the ENGINE START/STOP button, and the engine will begin to crank and start. 2020 Malibu Boats LLC • Owner’s Manual • Page 76...
Page 91: 12" Center Display
DOCKING button a second time. A notice will appear to let the operator know that the Docking Mode is active. When this notice is closed, the screen will show the docking camera feed (where equipped). 2020 Malibu Boats LLC • Owner’s Manual • Page 77...
Page 92: Night Mode
When an error occurs with a Surf Gate switch, the surf position that controls that Surf Gate will be LOCKED OUT. 2020 Malibu Boats LLC • Owner’s Manual • Page 78...
Page 93: Power Wedge Control
1—Touch the EDIT button to the right of the desired PRESET position. 2—Enter the NAME of the Preset, using the keyboard pop-up. Press the DONE key to close the keyboard, and then press NEXT. 2020 Malibu Boats LLC • Owner’s Manual • Page 79...
Page 94 Cancel a Preset Turn the speed control OFF to CANCEL a preset by touching the SPEED CONTROL button. The Power Wedge, Surf Gate and ballast will stay in the current position. 2020 Malibu Boats LLC • Owner’s Manual • Page 80...
Page 95: Media Screen
2—VIDEO.mp4 / .avi / .flv / .jpeg / .mpv / .png / .wmv 3—IMAGE.pdf Reverse Docking With the BACKUP CAMERA option and/or DOCKING CAMERA options turned ON in the SETTINGS MENU, the buttons for the camera feeds will be selectable. 2020 Malibu Boats LLC • Owner’s Manual • Page 81...
Page 96: Speed Control
(2) seconds, the engine will begin to govern itself to move back to the desired speed. 5—Moving the throttle back to the neutral position will disengage the speed control. 2020 Malibu Boats LLC • Owner’s Manual • Page 82...
Page 97: Call Alerts
1—Stereo Screen 2—Lighting Screen 3—Controls Screen 4—Android Apps Screen 5—Stereo Power ON/OFF 6—Volume Level 7—Mute Sound 8—Settings Menu Controls Screen 1—Forward Bilge 2—Heater 3—Seat Heater 4—Rear Bilge 5—Shower 6—All Off 2020 Malibu Boats LLC • Owner’s Manual • Page 83...
Page 98: Stereo Screen
2—AM Radio 3—SXM Satellite Radio 4—Bluetooth 5—Weather 6—USB Input 7—Auxiliary Input 8—Android Music AM/FM Radio 1—Source Select 2—Seek Fwd/Back 3—Global Favorites List Next Page 4—Equalization Adjustment 5—Tune Fwd/Back 6—Mixer Page 2020 Malibu Boats LLC • Owner’s Manual • Page 84...
Page 99 Unlock a Channel: Touch DIRECT to enter a channel number directly. Enter the channel number on the keypad and press ENTER to input. Enter the passcode on the keypad to unlock the channel. 2020 Malibu Boats LLC • Owner’s Manual • Page 85...
Page 100: Advanced Lighting Controls
Advanced Lighting Controls 1—RGB Lighting Control 2—Navigation Lights 3—Anchor Lights 4—Interior Lights 5—Storage Lights 6—Docking Lights 7—Underwater Lights 8—Tower Lights 9—All Lights Off 2020 Malibu Boats LLC • Owner’s Manual • Page 86...
Page 101 Jump Mode: Touch JUMP to have the lighting cycle through multiple colors. Select between four (4) or seven (7) buttons. Touch the BRIGHTNESS sliders to control the brightness level of the lighting, and the SPEED slider for the rate of cycling. 2020 Malibu Boats LLC • Owner’s Manual • Page 87...
Page 102: Android Apps
12” screen. This status bar shows the user the progress of the software update. After the software update is complete the system will reboot into the application. 2020 Malibu Boats LLC • Owner’s Manual • Page 88...
Page 103: Backlighting
Surf Gate/Transfer Settings: Touch SURF GATE to SERVICE, or toggle the audible indicators for Surf Gate switching ON/OFF. Radio Configuration: Touch RADIO CONFIGURATION to set the radio region and to adjust the volume of the SURF TONE through the tower speakers. 2020 Malibu Boats LLC • Owner’s Manual • Page 89...
Page 104: Diagnostics
Moving the joystick UP will INCREASE the CRUISE SET SPEED. Moving the joystick DOWN will DECREASE the CRUISE SET SPEED. Pushing the joystick IN will PLAY/PAUSE the audio, depending on the active audio source. 2020 Malibu Boats LLC • Owner’s Manual • Page 90...
Page 105: Txi Standard Gauges And Screen
Note that movement of the boat can affect the reading, especially as fuel levels lower. Be certain to read the Fueling information in the Get Ready section of this Owner’s Manual before operating the boat for important information. 2020 Malibu Boats LLC • Owner’s Manual • Page 91...
Page 106: Keypad
CRUISE MODE is activated. More throttle is needed to reach SET SPEED. SET SPEED has been achieved and the boat can now automatically maintain consistent speed. Engine Screen With ZeroOff Gauge Depth Screen 2020 Malibu Boats LLC • Owner’s Manual • Page 92...
Page 107: Alerts
Turn OFF or ON interior, navigation and anchor lights on the boat in the LIGHTS menu. Controls Menu Turn OFF or ON the bilge, blower, heater and heated seats in the CONTROLS menu. 2020 Malibu Boats LLC • Owner’s Manual • Page 93...
Page 108: Settings Menu
Adjust the brightness of the LCD display. Allows for offset of DISPLAYED AIR TEMPERATURE. SHALLOW ALARM Adjust the depth of the SHALLOW ALARM. LAKE TEMP CALIBRATION Allows for offset of DISPLAYED LAKE TEMPERATURE. 2020 Malibu Boats LLC • Owner’s Manual • Page 94...
Page 109: Video Screens
10. Source Select 3. Speed Up/Down 11. Seek/Track 4. Power On/Off 12. Mute On/Off 5. Stereo Screen 13. Volume Adjust 6. Media Screen 14. Auto Volume 7. Controls Screen 8. Maps Screen 2020 Malibu Boats LLC • Owner’s Manual • Page 95...
Page 110: Night Mode
Touch the STEREO button for direct access to certain audio controls including AM/FM stereo channels, Satellite, USB, Bluetooth wireless, auxiliary and SD car input ports. FM Radio 5. USB 1 Satellite Radio 6. Auxiliary input Bluetooth 7. Weather AM Radio 2020 Malibu Boats LLC • Owner’s Manual • Page 96...
Page 111 It is controlled with the AUTO VOLUME adjustment slide. Equalization Touch EQ to adjust the loudness, bass, treble, fade, balance, sub, iVol, and USA or European tuning. 2020 Malibu Boats LLC • Owner’s Manual • Page 97...
Page 112: Media Screen
VIEW available SETTINGS CHOICES. Touch the RED X button to EXIT the setting screen. Changes will automatically be saved upon leaving the SETTINGS screen. 2020 Malibu Boats LLC • Owner’s Manual • Page 98...
Page 113 Use a portable GPS such as a smartphone app or navigation product to determine ACTUAL SPEED and adjust the speed displayed. Units Touch UNITS to choose from ENGLISH to METRIC unit. 2020 Malibu Boats LLC • Owner’s Manual • Page 99...
Page 114 SERVICE notices will appear at each key cycle when the service hour interval has been reached, and it must be cleared by the user. Alarms Touch ALARMS to view all ACTIVE and INACTIVE engine alarms. 2020 Malibu Boats LLC • Owner’s Manual • Page 100...
Page 115: Maps Screen
NORTH is always at the top when NORTH is selected. The BEARING is always pointing to the top of the screen and in the direction the boat is traveling when BEARING is selected. 2020 Malibu Boats LLC • Owner’s Manual • Page 101...
Page 116 NEW COURSE allows the user to build a future course of NEW user- created waypoints. To begin, touch COURSE and then NEW for a NEW COURSE. Touch SELECT WAYPOINT LOCATION, and then position the cursor on the map for the first waypoint. 2020 Malibu Boats LLC • Owner’s Manual • Page 102...
Page 117 Touch the COURSE, then SELECT button to PICK, UNPICK or DELETE a course. Picking a course will display the course on the map. Multiple courses can be displayed on the map. 2020 Malibu Boats LLC • Owner’s Manual • Page 103...
Page 118: 3-In-1 Event Screen
Number of detectable satellites • Type of satellite signal • ZeroOff GPS Speed Control switch ® • Set speed increase/decrease touch points • Pull-out section for ski options • Pop-up screen for slalom settings 2020 Malibu Boats LLC • Owner’s Manual • Page 104...
Page 119: Gps Information
The unit is named for the three events that can be monitored: Slalom, Jump, and Trick. Touch the right arrow and the screen will shift to show the following Change Event options: 2020 Malibu Boats LLC • Owner’s Manual • Page 105...
Page 120 Select the volume for High and Low speed by utilizing the up and down arrows. Touch Back to return to the Slalom Settings screen. Timing Recap The timing recap will display the buoy times for the last two course runs. Touch Exit to return to the Home screen. 2020 Malibu Boats LLC • Owner’s Manual • Page 106...
Page 121 Touch each number to view and select an alternative number. Your authorized Malibu dealer can help you determine the strength number that is best for your boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 107...
Page 122 (if previously mapped) Course. The following screen will appear: Touch the preferred course type, and the highlighting will be bright white (as shown for Slalom - 6 Buoy in the image). 2020 Malibu Boats LLC • Owner’s Manual • Page 108...
Page 123: Auto Detect
Touching Continue will display a keyboard for the user to name the course that was just mapped. Auto Detect Zero Off auto-detects previously mapped courses within a 1-km radius of the boat. When an auto-detected course should be over-ridden, simply touch Auto Detect to turn it off. Auto detect will be re-enabled any time the user changes modes between slalom, jump or trick. 2020 Malibu Boats LLC • Owner’s Manual • Page 109...
Page 124: Pull Type
Check that the display supply wires are connected properly to the battery. Verify that the battery is charged properly. Check the battery for efficient starter current. Display has no backlight. Contact your authorized Malibu dealer for assistance. 2020 Malibu Boats LLC • Owner’s Manual • Page 110...
Page 125: Basic Electrical Components
There is also a Primary and Second- ary fuse box power module under the dash that contains fuses. Each box has a labeled/detailed picture of location, fuse size, and which circuit it protects. 2020 Malibu Boats LLC • Owner’s Manual • Page 111...
Page 126: Electrical Harnesses And Wiring
Malibu boats are equipped with one of the systems explained below: Null Battery System. The most basic electrical supply system, this set-up allows for a single battery. There will be two battery cables, one positive (+) and one negative (-).
Page 127 If a battery(ies) requires a jump start, do not allow the alternator to recharge it/them as it can lead to the alternator failing much more quickly than it would normally. Such damage would not be covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 113...
Page 128 The posts on a battery are marked negative (-) and positive (+), one of each on top and separate by some space. The battery cables are color-coded, black for negative and red for positive. 2020 Malibu Boats LLC • Owner’s Manual • Page 114...
Page 129: Battery Maintenance
The charger plugs into a socket under the observer’s seat. It can be left in place without boiling electrolytes in the battery. If the charger ever appears to be malfunctioning, take the boat and charger to an authorized Malibu dealer for troubleshooting. 2020 Malibu Boats LLC • Owner’s Manual • Page 115...
Page 130: Engine Sensors
Some alarms could be for malfunctions that could also put individuals on- board in potential harm. 2020 Malibu Boats LLC • Owner’s Manual • Page 116...
Page 131: Other Electrical Components
The black board contains four (4) breakers. If the Power Wedge III will not operate, verify that the supplemental breakers located in the port rear storage compartment are properly set. 2020 Malibu Boats LLC • Owner’s Manual • Page 117...
Page 132: Surf Band
Therefore, if the stereo is turned OFF persons on-board will not be able to hear an alarm. Tower lights will also flash. However, boats without tower stereo speakers or tower lights do not have this functionality. The alarm system is equipped on all boats regardless of optional equipment, and alarm 2020 Malibu Boats LLC • Owner’s Manual • Page 118...
Page 133 If any alarm occurs, the Surf Gate will be locked out from operation. The lock-out can only be cleared by pressing the “either” button on the tachometer and the error corrected. An error also may require cycling the battery switch off and then back on to clear. 2020 Malibu Boats LLC • Owner’s Manual • Page 119...
Page 134 Engine and...
Page 135 Drive Train...
Page 136: Malibu Monsoon Engines, Transmissions & V-Drives
The following information is provided for transmissions the Malibu Monsoon Engines. Unless otherwise directed, the instructions are applicable to all Malibu-built engines and drive trains. & v drives Safety Significant safety information appears in the opening chapter of this Owner’s Manual. It is critical to read the entire manual, with particular attention to the Safety information. All boat owners and boat operators must adhere to the safety requirements as described. It is also the responsibility of these individuals to be aware of U.S. Coast Guard regulations when boating in U.S. waterways, or the governing body(ies) of any waterway system in which 2020 Malibu Boats LLC • Owner’s Manual • Page 122...
Page 137: General Information
Always avoid smoking or open flame near the engine compartment. Other Safety Double-Checks Throughout this section of the Owner’s Manual, additional safety issues are reiterated. Always follow these instructions. Repeating checks and inspections is far superior to ever skipping any of these requirements and suggestions. Serial Number Each engine is assigned a unique serial number that is different from the Hull Identification Number (HIN) found on the transom of the boat. The engine serial number can be found in two locations on the engine. It is extremely rare that an engine requires replacement in a boat; however, general if this occurs, the replacement engine’s serial number must be reported to Malibu’s Warranty Department, even if the warranty statement effective dates have expired. In the event of a safety matter or recall, serial numbers often information alert the factory to which boats may be affected and allow the company to contact consumers. Engine serial numbers that do not match factory records may lead to questions of legality also. 2020 Malibu Boats LLC • Owner’s Manual • Page 123...
Page 138: Engine Specifications
Maintenance section of this Owner’s Manual, especially when operating in salt water or brackish water conditions. Failure to do so will void the warranty. Also see the Salt Water information provided in the Care and Maintenance section of this Owner’s Manual. Engine Oil Use only 5W30 synthetic dexos Gen2 engine oil. The engine requires eight (8) quarts to fill from empty. (Never over-fill the engine oil, nor run the engine without sufficient oil as indicated on the oil dipstick.) The use of any other oil or fluid may void the warranty. Instructions for proper levels, maintenance and oil changes are provided in the Care and Maintenance section of this Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 124...
Page 139: Transmission Fluid
Maintenance Schedule The maintenance schedule for Malibu Monsoon Engines is provided in the Care and Maintenance section of this Owner’s Manual. Do not attempt to operate the boat until after you have read this entire Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 125...
Page 140: California Emissions Information
MANUFACTURER’S WARRANTY COVERAGE: This evaporative emission control system is warranted for five years . If any information evaporative emission-related part on your SIMW is defective, the part will be repaired or replaced by Malibu Boats LLC. OWNER’S WARRANTY RESPONSIBILITIES: As the spark-ignition marine watercraft owner, you are responsible for performance of the required maintenance listed in this Owner’s Manual. Malibu Boats LLC recommends that you retain all receipts covering maintenance on your spark-ignition marine watercraft, but Malibu Boats LLC cannot deny warranty solely for the lack of receipts. As the spark-ignition marine watercraft owner, you should, however, be aware that the Malibu Boats LLC may deny you warranty coverage if your spark-ignition marine watercraft or a part has failed due to abuse, neglect, or improper maintenance or unapproved modifications. You are responsible for presenting your spark-ignition marine watercraft to a Malibu Boats LLC distribution center or service center as soon as the problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your warranty coverage, you should contact Malibu Boats LLC Warranty Department at 1-865-458-5478. 2020 Malibu Boats LLC • Owner’s Manual • Page 126...
Page 141: General Emissions Information
Fuel injectors Vacuum control diaphragms* Fuel pressure regulator Vapor hoses Fuel line All other parts not listed that may affect the evaporative Fuel line fittings emissions control system, including hoses fittings, etc. Fuel tank Idle Air Control (IAC) valve General Emissions Information After January 1, 2009 boats sold or registered in California have a Star label on the port side of the hull adjacent to the vessel registration, as shown. Exhaust emissions should be routinely monitored and verified throughout the life of the boat. The boat owner has responsibility to ensure that the engine is never modified in any fashion that alters the emissions occurring during operation. The engines have been constructed to meet specifications as established by governing bodies with authority in this matter. Routine maintenance performed by authorized Malibu dealers should satisfy these requirements, but having maintenance completed by an authorized Malibu dealer does not absolve the boat owner from the responsibility that emissions requirements are satisfied in the area in which the boat is owned and/or operated. Each engine has an Emissions Control Information (ECI) label affixed. A sample label is illustrated in this section. Information appearing on the label must never be altered. If the original, factory-affixed label is damaged or comes off the engine block, contact an authorized Malibu dealer immediately for a replacement. Malibu does not endorse the replacement of these labels by any unauthorized person. Engine emissions labels with the designation “CE” in the lower right-hand corner have been constructed within the parameters of the Declaration of Conformity requirements. This means that the engine conforms to the appropriate European Community Directive. 2020 Malibu Boats LLC • Owner’s Manual • Page 127...
Page 142: Star Label
Five Star – Level Five Extremely Clean. The five star label identifies engines that meet the Air Resources Board’s Voluntary Standards for spark-ignition marine engines. Engines meeting these standards have 50% lower emissions than Four Star–Super Ultra Low Emission engines. Additional Information, Including Warranty Malibu engines are prepared for the consumer in accordance with the applicable regulations as established by the California Air Resources Board as authorized by Chapters 1 and 2, Part 5, Division 26 of the California Health and Safety Code, and the United States Environmental Protection Agency, as described by 40 CFR 1045. Defects resulting from any source other than that described in the Malibu Limited Warranty Statement are not covered. Parts required for routine maintenance during the warranty period are also not covered. Examples would be, but are not limited to, spark plugs or filters or fluids. However, such components may be covered if failure occurred during the first 10-hour break-in period. The warranty will not be extended beyond its original expiration date for any reason, and the use of unapproved replacement parts may void any remaining warranty, per the Malibu Limited Warranty Statement. Replacement parts do not extend the warranty beyond its original period. Parts replaced under the limited warranty become the property of Malibu Monsoon Engines. Warranty coverage may be denied in instances where the emissions component(s) had been altered or damaged by neglect, or there is evidence of failure to perform maintenance as required by information provided 2020 Malibu Boats LLC • Owner’s Manual • Page 128...
Page 143: Monsoon Engine Support Systems
(PSI) pressure to ensure proper operation. As such, no one can or should ever monsoon attempt to access any portion of the fuel system without proper training and proper equipment. The fuel lines are covered in engine orange “fire-sleeve” protective covering so that they are easily identifiable, and consumers should always avoid these lines, support unless it is noted that one is squeezed or pinched. If it is possible to alleviate this situation systems safely, then do so. The preferable method, however, is to have an authorized Malibu dealer’s trained service technician do so and verify that no damage has been done to the line or other equipment. The Malibu fuel system from tank to plumbing to engine meets or exceeds U.S. Coast Guard requirements (Sec. 183.540 Recreational Boating.) Because of the potential for a dangerous, even catastrophic event if any part of the system fails, Malibu strongly encourages all owners/operators to always be aware of proper operation. Follow operational directives, maintenance requirements 2020 Malibu Boats LLC • Owner’s Manual • Page 129...
Page 144 Over-filling can reduce the ability of the tank to respond, which can cause damage to the fuel system and/or boat, which is not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 130...
Page 145: Fuel Information
Allowing fumes to be vented can also cause a situation in which a spark or open flame could cause a fire, which is extremely dangerous and could result in serious injury or death. 2020 Malibu Boats LLC • Owner’s Manual • Page 131...
Page 146 Always verify that the fuel filler access is closed when the engine is running. Failure to do so may allow water to enter into the fuel system. Such intrusion could result in damage to the engine and is not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 132...
Page 147: Electrical System
Alarms Note: Audible alarms are functional through the instrument panel, EXCEPT the Surf Gate transfer alarm, which sounds through stereo system. Therefore, if the stereo is turned OFF persons on-board will not be able to hear an alarm. The alarm system is equipped on all boats regardless of optional equipment, and alarm information, includ- ing the Surf Gate transfer alarm information, will be available through the video screen. The boat is equipped with several alarm systems. In general, an alarm sound is an indication that a potentially serious issue exists. The low-voltage alarm functions when the battery system charge has fallen to a level that could result in the boat becoming unable to continue the outing. The low-voltage alarm will be accompanied by an indication on the dash. Follow directions as they appear. Sensors will also alert the boat operator when the oil pressure, engine and/or transmission temperatures are outside acceptable parameters. All alarms should be taken seriously, and boaters should return to shore as soon as possible. Seek assistance from your authorized Malibu dealer to determine the cause and solution to any problems that have been indicated. Cooling System Malibu utilizes a closed cooling system. This is particularly critical for operation in salt water or brackish/dirty water. Without the need for a radiator such as used in land-based engines, the functionality of cooling system is 2020 Malibu Boats LLC • Owner’s Manual • Page 133...
Page 148 Never directly touch an overheated engine. Temperatures can exceed 200 degrees Fahrenheit (93 degrees Celsius), which would cause instant and serious burns, even through gloves or clothing. The water pumps on the engine that circulate water and coolant throughout the engine during operation are essentially inaccessible to the consumer. The circulation pump, which circulates coolant, is located on the bottom of the front-end accessory drive. If it requires attention, that should be done by a service technician at an authorized Malibu dealership. Another pump, the raw water intake pump, is utilized to bring in water from the body of water. The raw-water pump is located on the top of the front-end accessory drive, adjacent to the alternator. Its purpose is to draw 2020 Malibu Boats LLC • Owner’s Manual • Page 134...
Page 149 Silt, sand, dirt and weeds can accelerate the deterioration of the impeller. Many Malibu boats are equipped with an optional flush kit. The process for properly using a flush kit is explained in the Care and Maintenance section of this Owner’s Manual.
Page 150: Exhaust System
Always operate the blower for several minutes (at least four [4] minutes) prior to starting the engine, running at a low speed or at idle. (Malibu boats are equipped with an automatic shut-off when the automatic blower system has operated prior to starting the engine.) This must be done with the engine compartment open.
Page 151 State to cause birth defects, cancer or other reproductive harm. Never operate the boat if you or anyone on board suspects that the exhaust or fuel system is not performing as designed. 2020 Malibu Boats LLC • Owner’s Manual • Page 137...
Page 152: Break-In Period-All Boats
(4) minutes venting the engine compartment. Engine temperature is available on the video screen. Always verify that the engine feedback information on the video screen is within acceptable limits and no alarms show or sound before leaving the dock. Often, symptoms of potentially stranding issues will be noticeable at the beginning of the outing. • Vary engine speed, but do not exceed 3500 RPM with light load for the first hour. 2020 Malibu Boats LLC • Owner’s Manual • Page 138...
Page 153 Failure to have the oil change completed by an authorized Malibu dealer may void the warranty! If your dealer is not conveniently close by, instructions for oil and filter change procedures has been provided for oil changes AFTER the break-in, 10-hour oil change. After the break-in period, follow the instructions presented in the Care and Maintenance section of this Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 139...
Page 154: Vapor Lock
When the engine compartment is open, take extra care around the compartment. Rotating and moving parts could catch clothing or body parts, which could result in serious injury or death. If the vapor lock persists, seek assistance from your authorized Malibu dealer. 2020 Malibu Boats LLC • Owner’s Manual • Page 140...
Page 155: Transmissions & V-Drives
After the first 10 hours of operation, as part of the authorized Malibu dealer’ s review during the oil change will be a check of the transmission. How to do the required check of the fluid is explained in Care and Maintenance in this Owner’ s Manual. V-Drives Unlike land-based vehicles, boats can operate with the engine in a 180-degree orientation from how it would normally set in the vehicle. In the Malibu-type boat, this has been adapted into a superior form of propulsion, but it requires a V-drive, which is a system for boats that consists of two drive shafts, a gearbox, and the propeller. The first drive shaft connects the rear of the transmission to a gearbox mounted in the center of the boat. The second drive shaft extends from the gearbox to the rear and out the bottom of the boat to where the propeller is mounted. (The propeller’s functionality is described in How It Works in this Owner’s Manual, as part of the underwater gear.) As with the transmission, the V-drive assembly is very durable and requires little routine attention. Your authorized Malibu dealer will check it during the 10-hour oil change. Afterwards, it will require a periodic check, which is described in the Care and Maintenance section of this Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 141...
Page 156: How It Works
How It Works...
Page 158: Safety First
Malibu dealer prior to operation again. Operation prior to service could result in additional damage to the boat, and may result in serious injury or death. Following discharge of fire suppression material, the system will require recharging. If an automatic system has discharged, it is unlikely that the boat can be run. Malibu recommends getting a tow to shore and having the engine compartment thoroughly cleaned and the fire suppression system recharged prior to running the boat’s engine again. If hand-held units have 2020 Malibu Boats LLC • Owner’s Manual • Page 144...
Page 159: Emergency Engine Stop Switch
Never operate the boat without the emergency engine stop switch lanyard connected between the switch and the boat operator. Malibu recommends the operator of the vessel always remain at the helm any time the engine is running. 2020 Malibu Boats LLC • Owner’s Manual • Page 145...
Page 160: Lighting
Models: All models equipped with towers. DOCKING LIGHTS: These are an option that offer additional visual assis- tance. The lights are located around the bow area, two per boat, and provide white light to the front of the boat. The docking lights are operated from a screen icon. On all Wakesetter models, the control will be from ON-OFF/ HIGH/LOW. This feature is enabled through the touch screen settings. If the setting is disabled, it will function ON/OFF only. Please note that boat operators are not allowed to operate docking lights while the boat is underway. Models: (Optional) All models. 2020 Malibu Boats LLC • Owner’s Manual • Page 146...
Page 161: Tie-Ups
Models: All models as an option. Tie-Ups Several methods of securing boats to shoreline and docks are available. Although Malibu does not provide rope for tie-ups as a standard, dock lines are available through www.mali- buboatsgear.com. Also, many excellent marine aftermarket suppliers offer a wide range of rope for sale. Malibu recommends a two-strand nylon rope. (Three-strand rope may stretch too much and allow the boat to bump other objects.) There are several different knots and hitches to secure boats to docks or shoreline. Malibu recommends making the effort to learn these marine-intended knots and hitches. Consult with your authorized Malibu dealer to determine which ones will work best in the tie-up application you will be using. Some hitches are intended for only short-term docking, while others work better for longer periods of inactivity. Always bear in mind wave ac- tion that may cause the boat to bump the shoreline (and scratch the hull, which is not covered under warranty), or bumping against a dock, or even potentially other boats (also not covered under warranty), when selecting the appropriate method to secure the boat. CLEATS: All boat models offer optional pop-up cleats. Where equipped, the cleats will be located below the windshield on each side of the deck, and also near both rear sides. Some models may also have two additional/optional cleats mounted on either side of the front of the bow. Although there are multiple marine knots, the cleat hitch is a special knot used to tie the rope to a cleat. If a line is not correctly secured on the cleat using a cleat hitch, it can work itself loose. Pop-up cleats have two “horns” around which the line is tied. Begin by bringing the line past the center of the cleat on the outside beneath, and 2020 Malibu Boats LLC • Owner’s Manual • Page 147...
Page 162 Models: All models are equipped with a bow eye and transom eyes. FENDER LOCKS: As an option, the fender lock is a stainless steel component added permanently to the boat deck, with an eye that attaches an optional fender (sold by an authorized Malibu dealer or aftermarket supplier) to provide protection when a boat is docked. The fender eye slides into and out of the lock for ease of use. These locks help protect the finish of the boat. Fender locks are not designed to be used to tie up the boat. They are designed only to support bumpers. Models: (Optional) All Wakesetter models. 2020 Malibu Boats LLC • Owner’s Manual • Page 148...
Page 163: Horn
Models: Bow ladders are standard on the 22MX and 24MXZ models. The flip-down step is optional on some mod- els. Swim board ladders are also available on some models. 2020 Malibu Boats LLC • Owner’s Manual • Page 149...
Page 164: Fuel Fill
Avoid smoking while filling the gas tank or allowing any sparks in the area. Never run the boat engine while filling the gas tank. If any gas is spilled, clean it up with clean rags and dispose of properly on land. 2020 Malibu Boats LLC • Owner’s Manual • Page 150...
Page 165: Interior Performance
STEERING WHEEL CONTROLS: As an option, steering wheel controls will offer redundant control for the Surf Gates, Power Wedge, cruise control speed and audio controls. Operators should always review the Dashes and Video Screens section of this Owner’s Manual for important information about operational require- ments that may be necessary for proper function of these systems. Note that the most-re- cently touched component will override other control compo- nents. Depending on the con- figuration, control of the cruise system, Surf Gates and Power Wedge can be managed from the video screen, the controls on the steering wheel (including audio), and the Surf Band, where equipped. 2020 Malibu Boats LLC • Owner’s Manual • Page 151...
Page 166: Shifter/Throttle
Press on the left side to search left or lower-numbered ID; press right side to search right or higher-numbered ID. Models: Wakesetters offer optional steering wheel controls. Shifter/Throttle NOTE: The engine will not start unless the shifter/throttle control is in the neutral position! To the right of the boat operator is the shift/throttle lever. Any time the boat engine is OFF, the lever should be in the center upright position, which is Neutral (meaning the boat is not in gear. This is apparent when you feel it slot in and hear an auditory click). Boats are not equipped with a “Park” gear as land-based vehicles are. At the base of the throttle is a button. Pushing on the button disengages the transmission, thereby allowing use of the throttle without engaging the transmission. This is used for warm-up of the engine while it is still in Neutral. Be sure to position the throttle vertically (in Neutral) before re-engaging the transmission by again 2020 Malibu Boats LLC • Owner’s Manual • Page 152...
Page 167: Electronic Throttle Control (Etc)
If, for any reason (unplugged, wire cut, a short, loss of power, or sensor failure, as examples) any part of the electronic throttle control system fails, the engine controller will default to idle. The operator will essentially have no control of the throttle and the Engine Fault alarm will activate. If this happens, the operator must turn the ignition key to OFF, and then attempt to restart the engine. This will reset the computer area network. If the condition persists, however, it will be necessary to take the boat to an authorized Malibu dealer for repair. Additional information regarding the throttle control’s safe operation and maintenance is included in addi- tional separate material that is part of the new-boat informational package. Models: All models. 2020 Malibu Boats LLC • Owner’s Manual • Page 153...
Page 168: Pylon(S)
• An expandable smartphone cradle (simply slide the sides toward each other to lessen the size, or away from each other to expand). • A water-resistant storage box with a USB charging port. • An intuitive, analog rotary knob for Surf Gate, Power Wedge II, speed control and stereo (volume, song selection and mute). The dial allows the boat operator to keep his/her eyes on the water ahead while adjusting the controls. • Whenever the power button and dash are ON, the rotary knob is activated to work. It offers redundant controls for the features controlled on the dash touch screen. • Surf Gate and Power Wedge are controlled by the button. • Speed UP/DOWN and song selection are controlled by moving the center joystick UP/DOWN and LEFT/RIGHT. • Pushing the center knob will mute any audio. • Twisting the knob will change the audio volume to louder or softer. • Control the Stow Wedge via command. Models: (Optional) All Wakesetter models. 2020 Malibu Boats LLC • Owner’s Manual • Page 154...
Page 169: Interior Luxury
LED light will be on when the camera is activated. Visual images appear in the 12” video screen. Control for the dock camera is also available through the video screen. Models: (Optional) All Wakesetter models. Stereo Components One of the most enjoyable aspects of boating is the stereo system, and Malibu offers a range of optional media opportunities. Most of these systems are controlled through the main stereo head unit but a stereo transom remote (pictured) is available as an option. Stereo system controls interior are explained in the Dashes and Video Screens section of this Owner’s Manual. luxury Models: (Optional) All models have a variety of stereo options. 2020 Malibu Boats LLC • Owner’s Manual • Page 155...
Page 170: Seating
WakeView seats should never be the loca- tion from which individuals attempt to leap into the water. It can be difficult to determine the water depth, and people can misjudge clearance of the swim board. 2020 Malibu Boats LLC • Owner’s Manual • Page 156...
Page 171: Heated And/Or Powered Driver's Seat
This could result in injury to the driver and/or passengers. The driver’s seat also has a swivel feature. To activate, push down on the T-handle in front of the seat. When the desired position has been achieved, release the handle to lock the position. There are also optional features for the helm seat, which are explained immediately following. It is critical to the long-term use and enjoyment of the boat to perform the rou- tine maintenance required to keep all interior upholstery in top condition. Details are provided in the Care and Maintenance section of this Owner’s Manual. Models: All boats have standard seating that varies by model. The WakeView transom seating is standard on the Wakesetter 23LSV and Wakesetter 24MXZ; optional on other models. Heated and/or Powered Driver’s Seat Among the options available on all models are a heated and/or powered driver’s seat. The heat option may be controlled through the video screen or from a switch on the driver’s side panel. Turned ON, the heat sensor warms the driver’s seat only to a predetermined, but moderate level. The heat 2020 Malibu Boats LLC • Owner’s Manual • Page 157...
Page 172: Armrests
In moving armrests up and down, use caution to avoid pinching fingers or skin. Avoid pinching fingers or skin in moving armrests up or down. Models: Some models. Glove Box Malibu recommends storing this Owner’s Manual in the glove box so that it will always be readily available for reference during outings. Placing the Owner’s Manual in a plastic bag will increase its protection. The glove box is convenient for storing personal items while boating. While the glove box is not waterproof, its design reduces the likelihood of damage from water that may come on-board. Malibu does not warrant the level of water-resistance available when using the glove box. The glove box opens by pushing on the button on the front of the lid. Closing requires only lifting and shutting the lid tight. Closing requires minimal effort. If more effort is required, it is likely the glove box is overloaded and some material should be removed prior to closing. 2020 Malibu Boats LLC • Owner’s Manual • Page 158...
Page 173: Storage Compartments
This could result in serious injury or even death. Items should be evenly distributed and with attention to the number of passengers and where they will sit. Even distribution of added weight is critical to a safe operation. 2020 Malibu Boats LLC • Owner’s Manual • Page 159...
Page 174: Removable Cooler
Models: All models, except Response/TXi. Cup Holders All boats are equipped with cup holders. The cup holders are sized for contemporary, normal-sized cups. Malibu recommends using only cups with covers as boat motion is likely to otherwise slosh liquids out of the cups. If liquids are spilled into the cup holder, or anywhere else, they should be cleaned up as soon as practical to prevent any damage to the boat compo- nents or anything brought on-board. Such damage is not covered under warranty. Models: All models. Removable Trash Receptacle Some models have a removable trash receptacle which is stowed under the aft, starboard seating. Malibu recommends using plastic liners in the receptacle to ease the removal of trash. All trash, regardless of whether the boat is equipped with this feature, should be properly discarded on-shore in a legal and safe manner. Clean the receptacle as needed to prevent staining and odors. Models: All models except the 21VLX, and Response/TXi. 2020 Malibu Boats LLC • Owner’s Manual • Page 160...
Page 175: Carpets And Soft Grip
If it is left inside the deck but unsecured, it could move around and potentially cause injury to people on-board. Models: Option for all Wakesetter models. 2020 Malibu Boats LLC • Owner’s Manual • Page 161...
Page 176: Grab Handles
Carbon monoxide poisoning is addressed in the Safety section of this Owner’s Manual and should be avoided. Models: (Optional) All models. 2020 Malibu Boats LLC • Owner’s Manual • Page 162...
Page 177: Tower, Canvas & Accessories
Also, in opening and closing the lever, take care to avoid pinching fingers, hands or parts of the body. 2020 Malibu Boats LLC • Owner’s Manual • Page 163...
Page 178: Gx Tower
The tower is designed to be used either fully up or full down, not in-between. When raising it is import- ant to raise the tower fully until it physically stops. GX Tower 2020 Malibu Boats LLC • Owner’s Manual • Page 164...
Page 179: Tower Accessories
Such weight limits can also cause the tower to fail, which could result in damage that is not covered under warranty, 2020 Malibu Boats LLC • Owner’s Manual • Page 165...
Page 180: Bimini Top
6. If the boat will be in motion, place the Bimini boot over the canvas and zip it closed. (This will keep the canvas from flapping during operation and potentially tearing it, which is not covered under warranty.) 2020 Malibu Boats LLC • Owner’s Manual • Page 166...
Page 181: Icon 8 Speakers Or Rev 10 2 Or 4 Speakers With Horn
4. Pull down on the pivot release knob again, and pivot the rack to the outward position until it locks in place. NOTE: The rack can pivot and lock in three positions: inward, center and outward. 2020 Malibu Boats LLC • Owner’s Manual • Page 167...
Page 182: G3.5 Tower Mirror
(at least four [4] minutes) prior to starting the engine, running at a low speed or at idle. This must be done with the engine compartment open. Failure to perform this necessary function 2020 Malibu Boats LLC • Owner’s Manual • Page 168...
Page 183 Care and Mainte- nance section of this Owner’s Manual. Never operate the boat if you or any- one on board suspects that the exhaust or fuel system is not performing as designed. 2020 Malibu Boats LLC • Owner’s Manual • Page 169...
Page 184: Bilge System
Individuals on-board could trip and injure themselves if the drain plug is not secured properly. All boats are equipped with two (2) drain plugs, a ½” drain plug on the tran- 2020 Malibu Boats LLC • Owner’s Manual • Page 170...
Page 185 PFD if they are not already wearing one. Return to shore immediately and disembark. Without a properly functional bilge system, the boat is in danger of sinking, placing all on board at serious risk. 2020 Malibu Boats LLC • Owner’s Manual • Page 171...
Page 186: Ballast System
The tanks also provide accurate level readings, which are displayed on the MaliView 12” display screen. All Malibu boats are equipped with at least three (3) ballast tanks and have an optional bow tank, plus op- tional plumbing for Plug ’n Play.
Page 187: Power Wedge
The Power Wedge will not return to “stow” unless the boat speed is above one (1) mph and below ten (10) mph. Always verify there is no person or object around the Power Wedge while it is stowing. If an object is ob- 2020 Malibu Boats LLC • Owner’s Manual • Page 173...
Page 188: Surf Gate
For example, when the left wake is desired, select the left arrow; the right/starboard gate will be the gate that will deploy. The 2020 Malibu Boats LLC • Owner’s Manual • Page 174...
Page 189: Underwater Gear (Rudder, Fins, Strut, Propeller, Paddlewheel And Raw-Water Intake/Sea Strainer)
Even if the water appears deep enough for the hull, it may not be deep enough for the rudder to pass unimpeded. 2020 Malibu Boats LLC • Owner’s Manual • Page 175...
Page 190 GPS (both are standard). The method to switch between speed sources (paddle- wheel and GPS) is explained in the Dashes and Video Screens of this Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 176...
Page 191: Shower
In the ON position, the knob rotates to the left for more hot water, and to the right to add colder water to the mix. The shower nozzle pulls out of the deck at the transom. Twist the nozzle counterclockwise to start the stream 2020 Malibu Boats LLC • Owner’s Manual • Page 177...
Page 192: Flush Kit
Prior to using the flush kit, clean water must be added from on-shore. Run a garden-type hose from the clean-water source to inlet on the port side of the deck, outside the engine well storage compartment. Attach securely, but do not over-tighten. 2020 Malibu Boats LLC • Owner’s Manual • Page 178...
Page 193: Swim Board And Ladders
Additional information regarding the routine maintenance of the swim board is available in the Care and Maintenance section of this Owner’s Manual. Models: All Malibu boats are equipped with a swim board. Under-swim board ladders and bow ladders are optional on some models.
Page 194: Salt Water Series
Replace- ment of the anode is considered part of the routine maintenance procedure and is not covered under warranty. Models: (Optional) The Salt Water Series is available on all models. 2020 Malibu Boats LLC • Owner’s Manual • Page 180...
Page 195 2020 Malibu Boats LLC • Owner’s Manual • Page 181...
Page 196: Trailers
Trailers...
Page 198: Reporting Safety Defects
Failure to observe the safety recommendations contained in this manual 2020 Malibu Boats LLC • Owner’s Manual • Page 184...
Page 199: Connections To The Tow Vehicle
On the left front side of the trailer is a certification label that shows the maximum load-carrying capacity of the trailer. The GVWR will be indicated on this label. 2020 Malibu Boats LLC • Owner’s Manual • Page 185...
Page 200: Trailer Hitch
Or consult with the tow vehicle manufacturer’s authorized dealer for other assistance. In general, for Class 4 rigs, (5,000-10,000 lbs.) a ball of two inches (2”) or two-and-five-sixteenths (2-5/16”) is required. 2020 Malibu Boats LLC • Owner’s Manual • Page 186...
Page 201: Safety Cables
When pressing up on the brake release tab, if it moves up and down freely with just the resistance of its spring, then the emergency brake system was 2020 Malibu Boats LLC • Owner’s Manual • Page 187...
Page 202: Weight Distribution
Such activity requires common sense and care to avoid injury. 2020 Malibu Boats LLC • Owner’s Manual • Page 188...
Page 203: To Open The Coupler
However, the LED lights utilized on Malibu trailers sometimes does not pull a sufficient “load” on the tow vehicle’s electrical system to register. This situation can be simply remedied by the tow-vehicle’s dealership. 2020 Malibu Boats LLC • Owner’s Manual • Page 189...
Page 204: Hitching Up
Failure to lock the ratchet lever on the handle when the boat is being loaded or unloaded or when there is tension on the line, can result in loss-of-control, with the 2020 Malibu Boats LLC • Owner’s Manual • Page 190...
Page 205: Tie-Downs
As part of the security for towing, the boat is equipped with tie-downs fore and aft (optional on trailer) on the boat and on the trailer. Seek assistance from an authorized Malibu Trailer dealer to determine the location 2020 Malibu Boats LLC • Owner’s Manual • Page 191...
Page 206: Trailer Components And How They Function
Failure to properly stow the trailer jack in a horizontal position and lock in place could result in damage to the trailer jack or other trailer components that is not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 192...
Page 207: Removable Guide Poles
However, the LED lights utilized on Malibu trailers sometimes does not pull a sufficient “load” on the tow vehicle’s electrical system to register. This situation can be simply remedied by the tow-vehicle’s dealership. 2020 Malibu Boats LLC • Owner’s Manual • Page 193...
Page 208: Axles
(5) years of service. After that time, the maintenance requirements should be undertaken only by an authorized Malibu Trailer dealer and only the UFP’s Hybrid Oil Lubricant should be used. 2020 Malibu Boats LLC • Owner’s Manual • Page 194...
Page 209: Wheels And Hubs
The torque applied when securing the lug nuts is also extremely important. If it is under-tightened, a lug nut can work loose under operation and come off. An over-tightened lug nut can strip the threads and also come off. 2020 Malibu Boats LLC • Owner’s Manual • Page 195...
Page 210: Lug Nuts
The following information provided about tires is presented courtesy of the National Highway Transportation & Safety Administration. (Reprinted by permission.) 2020 Malibu Boats LLC • Owner’s Manual • Page 196...
Page 211 Finding Your Vehicle’s Recommended Tire Pressure and Load Limits Tire information placards and vehicle certification labels contain information on tires and load limits. These labels indicate the vehicle manufacturer’s information including: 2020 Malibu Boats LLC • Owner’s Manual • Page 197...
Page 212 While your tire may still be slightly under-inflated due to the extra pounds of pressure in the warm tire, it is safer to drive with air pressure that is slightly lower than the 2020 Malibu Boats LLC • Owner’s Manual • Page 198...
Page 213 Other factors such as personal driving style, type of car, quality of the roads, and tire maintenance habits have a significant influence on your tire’s performance and longevity. 2020 Malibu Boats LLC • Owner’s Manual • Page 199...
Page 214 • Inspect tires for uneven wear patterns on the tread, cracks, foreign objects or other signs of wear or trauma. • Remove bits of glass and other foreign objects wedged in the tread. 2020 Malibu Boats LLC • Owner’s Manual • Page 200...
Page 215: Brakes
Excessive heat in the wheels as a result of road use, meeting cooler water can cause damage to the components, especially 2020 Malibu Boats LLC • Owner’s Manual • Page 201...
Page 216 4. At the brake assembly, connect a transparent bleeder hose to the bleed screw fitting on the wheel cylinder and submerge the free end into a container partially filled with brake fluid. Do not reuse this fluid. 2020 Malibu Boats LLC • Owner’s Manual • Page 202...
Page 217 Malibu has developed a kit that can be installed to make the system function correctly with these vehicles, which can be installed by your authorized Malibu Trailer dealer. 2020 Malibu Boats LLC • Owner’s Manual • Page 203...
Page 218 • Check to be certain the breakaway battery is charged and that the breakaway works. This is 2020 Malibu Boats LLC • Owner’s Manual • Page 204...
Page 219: Hand-Parking Brake Option
(No resistance, no brakes!) The pre-load should be adjusted when the brake shoes are periodically replaced. The pre-load should be set only by an authorized Malibu Trailer dealer. 2020 Malibu Boats LLC • Owner’s Manual • Page 205...
Page 220: Additional Options
(Note that some models are too large to have a low profile trailer option and fit in every area.) For more information about these trailers, contact an authorized Malibu Trailer dealer. 2020 Malibu Boats LLC • Owner’s Manual • Page 206...
Page 221: Towing Advice
Towing is more challenging than driving down the road in a single vehicle. Therefore, you would be well-advised to practice, practice, practice before undertaking a genuine tow to a body of water for an outing. 2020 Malibu Boats LLC • Owner’s Manual • Page 207...
Page 222: Launching And Re-Loading The Boat From The Trailer
ThE TRAILER boat as you ease back, and that you will not bog down in the water or on the land surface. Sufficient width, especially if you are inexperienced in backing 2020 Malibu Boats LLC • Owner’s Manual • Page 208...
Page 223 Also, be aware that while the brakes are wet, they will not work as quickly or efficiently as normal. As soon as they dry, the brakes should resume their normal characteristics. 2020 Malibu Boats LLC • Owner’s Manual • Page 209...
Page 224 2020 Malibu Boats LLC • Owner’s Manual • Page 210...
Page 225: Cleaning, Maintenance And Storage
It can also result in trailer failure that could potentially cause serious injury or death, not only to those in the tow vehicle but also to others on the road in the vicinity. 2020 Malibu Boats LLC • Owner’s Manual • Page 211...
Page 227: Get Ready
Get Ready...
Page 228: Malibu Fuel System
Never smoke or operate any spark- producing object within a fifty-foot (50’) range of the boat when fueling. Fumes from gasoline are more likely to produce an explosion and/or fire than the actual fuel. 2020 Malibu Boats LLC • Owner’s Manual • Page 214...
Page 229: Operations
The total number of people and gear on-board does not exceed the maximum allowed and as indicated on the capacity plate. These informational plates are located in the interior walk-through. 2020 Malibu Boats LLC • Owner’s Manual • Page 215...
Page 230 Owner’s Manual. q Give all the on-board equipment and components (such as the tower) a final check to be certain that everything is secure and ready for the expected boating conditions. 2020 Malibu Boats LLC • Owner’s Manual • Page 216...
Page 231: Starting And Operation
It also assures that any new issues that arise involving the engine, fuel system and ventilation system are noted. Accumulation of fumes within the engine compartment can also lead to an explosion. 2020 Malibu Boats LLC • Owner’s Manual • Page 217...
Page 232: To Turn Off-Wakesetters
If the engine does not start as it should, refer to the Troubleshooting section at the conclusion of this Owner’s Manual for assistance in determining the cause. If any alarms sound or warning lights appear, turn OFF the engine and troubleshoot. 2020 Malibu Boats LLC • Owner’s Manual • Page 218...
Page 233: To Turn Off-Response And Txi
Engine section of this Owner’s Manual, where appropriate. Be sure to review this information carefully. Failure to follow the instructions will void the engine warranty! With regard to the boat, pay close attention to the screens, and monitor the readings. Pay particular 2020 Malibu Boats LLC • Owner’s Manual • Page 219...
Page 234: Smart Operations
Always slow to a no-wake speed before attempting these shifts and do not shift into reverse if the boat is moving faster than 2 mph (3.2 km/h). 2020 Malibu Boats LLC • Owner’s Manual • Page 220...
Page 235: High Speed Maneuvers
Under normal circumstances, Malibu boats should not be used to tow other boats. Towing other boats should be undertaken only as a last resort, when other, more appropriate, towing is unavailable. The stress caused by towing lines, along with the difficulty in controlling the disabled boat, could cause damage to the towing boat as well.
Page 236: Anchoring
Before attempting to dock, practice in an open body of water. Slow the throttle to no-wake speed. Shift into neutral and drift slowly toward the dock. If necessary, shift the boat into reverse to further slow or stop the boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 222...
Page 237 Always be certain to visually check that the center and transom drain plugs are installed and SECURED prior to deploying the boat in any body of water. The boat operator still must physically check that the drain plugs are installed and properly secure. 2020 Malibu Boats LLC • Owner’s Manual • Page 223...
Page 238 Care and...
Page 239 Maintenance...
Page 240: On-Going Care
75˚F and relative humidity (RH) of 50%, with rapid spread occurring at 80%; however, some can grow in significantly lower temperature and RH levels. All fabrics will support growth but natural fibers like cotton, due to their 2020 Malibu Boats LLC • Owner’s Manual • Page 226...
Page 241 When you cover your boat, you are sealing the outside air in its present condition under the cover. Also, if the boat wasn’t dried out, that additional moisture will add to the wetness of the trapped environment. As 2020 Malibu Boats LLC • Owner’s Manual • Page 227...
Page 242 The use of abrasive detergents and/or substrates containing solvents or gasoline will damage the fabric. If using high-pressure or steam-cleaning devices, use caution as improper use could damage the vinyl coating and/or fabric. 2020 Malibu Boats LLC • Owner’s Manual • Page 228...
Page 243: Upholstery
In order for mildew to proliferate, spores, food, warmth and moisture are necessary. Elimination of one of these elements would break the cycle, and the mildew problem would be eliminated. 2020 Malibu Boats LLC • Owner’s Manual • Page 229...
Page 244 These actions must be directed to the components of the product and the total construction. Working together, they will assure the highest probability of success in eliminating quality problems associated with mildew contamination. 2020 Malibu Boats LLC • Owner’s Manual • Page 230...
Page 245: Approved Cleaners For Malibu Upholstery
Sun tan lotion* Tar/asphalt Yellow mustard A. Medium-soft brush, warm, soapy water, rinse/dry B. 303 Fabric and Vinyl Cleaner rinse/dry C. Wipe or scrape off excess (chill gum with ice) After all cleaning methods, rinse well with clear, warm water. 2020 Malibu Boats LLC • Owner’s Manual • Page 231...
Page 246: Routine Care
These durable boards should also periodically receive a thorough cleaning. Use only mild detergents and warm water or marine- industry based cleaners that are approved for use on fiberglass and rubber. 2020 Malibu Boats LLC • Owner’s Manual • Page 232...
Page 247: Hull And Deck Finishes
Wash the boat by hand with mild detergent as noted above, and then rinse carefully. 2020 Malibu Boats LLC • Owner’s Manual • Page 233...
Page 248: Salt Water Care And Maintenance
The anodes serve to significantly reduce the potential for corrosive damage to the permanent metal components on the boat. Malibu boats are equipped with a closed cooling system, (see the Engine section of this owner’s manual), which reduces the amount of water utilized from the body of water during operation.
Page 249: Routine Salt Water/Brackish Water Protection
Term Corrosion Inhibitor may be used. Regular WD-40 cannot be used as it does not contain all the protective ingredients of the Long-Term Corrosion Inhibitor.) Avoid getting Corrosion Block on other, non-metal surfaces, particularly vinyl seats or soft-grip flooring. If this occurs, clean immediately as directed by the product’s directions to avoid stains that are also not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 235...
Page 250 1 = Ladder 2 = Ladder door hinges 7 = Vent covers 3 = Ladder door handle 4 = Bow grab handles 5 = Front cup holders 6 = Arm rests 2020 Malibu Boats LLC • Owner’s Manual • Page 236...
Page 251 1 = Cup holders (all on both sides of interior) 2 = Grab handles 3 = Trash lid 4 = Center plate 5 = Tower release hinges (varies by tower) 6 = Rear sliding seat mounts and arms 2020 Malibu Boats LLC • Owner’s Manual • Page 237...
Page 252 16 = Surf Gate logo 1 = Rub rail 2 = Docking lights 3 = Board racks 4 = Tower speaker mounts 5 = Front ladder 6 = Front lifting eye 2020 Malibu Boats LLC • Owner’s Manual • Page 238...
Page 253 Please note that because this is a natural function of operating in certain bodies of water, the cost of replacement is not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 239...
Page 254: Flush Kit
Such corrosion is not covered under warranty. Deterioration of components due to corrosion can result in component failure, which can lead to serious injury or death. 2020 Malibu Boats LLC • Owner’s Manual • Page 240...
Page 255: Routine Maintenance
Note that these instructions should be followed even after the warranty period has expired. The instructions developed for the power trains and drive trains in Malibu boats function as the guidelines to a long-term, positive boating experience. Failure to follow the care and maintenance instructions as provided in this section of the Owner’s Manual can result in damage...
Page 256 Malibu trailer. Failure to follow the maintenance instructions provided in this Owner’s Manual will result in the voiding of the Limited Warranty explained in its own section of this Owner’s Manual. 2020 Malibu Boats LLC • Owner’s Manual • Page 242...
Page 257: Before Starting The Engine
Even with the closed cooling systems, it is necessary to circulate additional water as part of an effective cooling system. To protect the system, a sea strainer is installed near the raw 2020 Malibu Boats LLC • Owner’s Manual • Page 243...
Page 258 Make sure you open the valve prior to running the engine; otherwise, it will overheat. Whenever the engine is running, water is being drawn in and you will not be able to inspect the sea strainer. 2020 Malibu Boats LLC • Owner’s Manual • Page 244...
Page 259: Check Engine Oil Level
As with most acids, this is caustic and corrosive. If it comes in contact with skin, immediately flush the area with copious amounts of fresh, clean water. Follow up with medical assistance. 2020 Malibu Boats LLC • Owner’s Manual • Page 245...
Page 260: Check For Odors
Always verify the source of and correct any leakages prior to use of the boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 246...
Page 261: After Starting The Engine
As noted above, do not attempt to jump-start a dead battery. This is not only dangerous but puts undue stress on the boat engine’s alternator, which may cause it to fail. This is not covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 247...
Page 262: After The Outing
That gives you the clues you need when readings are different or you are anticipating an outing that will be different and you need to prepare for those conditions. 2020 Malibu Boats LLC • Owner’s Manual • Page 248...
Page 263: After 10 Hours On The Hourmeter
2020 Malibu Boats LLC • Owner’s Manual • Page 249...
Page 264: Check The Safety Equipment
Any time you suspect an engine mount is loose, it must be tightened. If the engine is allowed to shake or move during operation, it adversely affects the entire drive-train and could cause damage that would not be covered under warranty. 2020 Malibu Boats LLC • Owner’s Manual • Page 250...
Page 265: Exhaust Flap
• ALWAYS DISCONNECT THE NEGATIVE (-) CABLE FIRST. • Ensure that the negative cable will not come in contact with the positive cable during the rest of the procedure. 2020 Malibu Boats LLC • Owner’s Manual • Page 251...
Page 266: Pumps
CLEAN container. Dirt, oil, or other contaminants can cause damage to the cooling system, which may not be covered under warranty. The coolant in the closed cooling system should be changed every three (3) years or 1200 hours, whichever comes first, but a thorough inspection is required annually. 2020 Malibu Boats LLC • Owner’s Manual • Page 252...
Page 267: Oil System
Malibu dealer technician can advise you whether you should be concerned about the amount of oil used between oil changes. Replacing the Oil Filter: 1. Oil filters are located on the front of the engine. 2. Remove the oil filter housing cap. 3. Use a tool designed for removal or installation of oil filters only. Other tools may crush the filter and release used oil into the engine compartment, the boat or the work area. 2020 Malibu Boats LLC • Owner’s Manual • Page 253...
Page 268: Transmission/V-Drive System
NEVER REUSE OIL! Only new 5W30 SYNTHETIC dexos Gen2 engine oil should be added to the oil system of a 5.3L or 6.2L engine! Transmission/V-Drive System Transmission fluid checks must be done ONLY when the transmission fluid is heated. Therefore, the boat should be run in a body of water for at least five (5) minutes, and then shut down. 1. Remove and wipe down the transmission dipstick. 2020 Malibu Boats LLC • Owner’s Manual • Page 254...
Page 269: Hydraulic Steering System
An annual replacement is recommended for both filters. Hydraulic Steering System The steering in Malibu boats features a hydraulic system that can be maintained or repaired only with specialized tools. Because of the potential for physical harm when working on this system, it cannot be checked, changed or repaired by consumers.
Page 270: Power Wedge And Surf Gate Manual Extension And Retraction
Never ignore the care and maintenance required to keep your boat under warranty and in good condition for the life of the boat. 2020 Malibu Boats LLC • Owner’s Manual • Page 256...
Page 271: Hull Gel Coat
Over time, these components could potentially fail, which would not be covered under warranty.) However, some boaters, especially those who are privileged to live on a 2020 Malibu Boats LLC • Owner’s Manual • Page 257...
Page 272: Winterizing Boats Equipped With Optional Flush Kit
• With the boat shifter in neutral, start the engine and allow it to idle. During the entire process, DO NOT EXCEED 1100 RPM on the engine. (The freshwater hose cannot provide sufficient water supply to adequately cool the engine at higher RPMs.) Also, never take the 2020 Malibu Boats LLC • Owner’s Manual • Page 258...
Page 273 Start the engine and the pump will automatically pump the coolant from the bucket into the engine and manifolds. DO NOT EXCEED 1100 RPM. When the bucket is empty, IMMEDIATELY shut down the engine. • 2020 Malibu Boats LLC • Owner’s Manual • Page 259...
Page 274: Extended Storage And Winterization
ALL PLUGS MUST BE REMOVED AND ALL WATER DRAINED PRIOR TO STORAGE TO PREVENT POTENTIAL FREEZING AND DAMAGE TO THE ENGINE AND BOAT. The engine drain plugs are located: 1. Under the shaft coupler on the front of the v-drive. 2 and 3: On each side of the engine, integrated into the water-circulating manifolds. 2020 Malibu Boats LLC • Owner’s Manual • Page 260...
Page 275 Such damage is not covered under warranty! 2020 Malibu Boats LLC • Owner’s Manual • Page 261...
Page 276 Failure to properly perform annual maintenance, plus storage/winterization procedures as described in this Owner’s Manual is likely to result in damage to the boat, components, drive train and features. Such damage is not covered under warranty! 2020 Malibu Boats LLC • Owner’s Manual • Page 262...
Page 277: Maintenance Schedule
It is always recommended that these requirements be performed by an authorized Malibu dealer. Service technicians from Malibu dealerships have proper equipment, training and resources to best meet the requirements. Please note that routine maintenance is not covered by the Malibu Boats Limited Warranty. For details, please consult the limited warranty statement.
Page 278: Warranty
Warranty...
Page 280: Malibu Boats Llc Limited Warranty
WILLING AND ABLE TO REPAIR OR REPLACE ANY DEFECTIVE GOODS SUBJECT TO THE TERMS PROVIDED HEREIN. UNDER ANY CIRCUMSTANCE, THE ENTIRE LIABILITY OF MALIBU BOATS, LLC IS LIMITED TO THE LESSER OF THE REPAIR OR REPLACEMENT OF ANY DEFECTIVE COMPONENT OR AFFECTED PORTION OF THE MALIBU BOAT, OR THE ACTUAL PRICE PAID FOR THE MALIBU BOAT, DRIVE TRAIN, AND/OR TRAILER.
Page 281 Limited Warranty. Note: This Limited Warranty is expressly conditioned upon the timely completion and return of the warranty registration card to Malibu Boats. Although not obligated to and without creating such an obligation, this will enable Malibu Boats to notify you of any necessary performance or safety modifications to your Malibu Boat, Drive Train and/or Trailer and to verify ownership in case a warranty claim is filed on your Malibu Boat, Drive Train and/or Trailer.
Page 282 The repair and/or replacement of components or parts under warranty does not extend the warranty period beyond the original expiration date. Section 2.1. Structural Limited Warranty. For the life of the boat, Malibu Boats will repair structural materials or structural workmanship supplied by it during the construction of the hull, deck, floor liner, or stringer, which are determined by Malibu Boats to contain substantial manufacturing defects. This Structural Limited Warranty does not apply to the Malibu Boat’s gel coat or powder coat (see below for Gel Coat & Powder Coat Limited Warranty), drive train (see below for Drive Train 2020 Malibu Boats LLC • Owner’s Manual • Page 268...
Page 283 Section 2.3. Gel Coat, Powder Coat and Trailer Paint Limited Warranty. Note: Minor distortions or imperfections resulting from the handcrafted application of the gel coat on a Malibu Boat are considered normal and unavoidable. Gel coat, powder coat and trailer paint maintenance is the Purchaser’s responsibility. Conditioned on the Purchaser having provided and performed all gel coat, powder coat and trailer paint maintenance and care described in this Owner’s Manual, for a period of twelve (12) months, beginning on the date of the original retail purchase or the initial use of the Malibu Boat and/ or Malibu Trailer, whichever occurs first, Malibu Boats will repair materials, or workmanship supplied by it, in 2020 Malibu Boats LLC • Owner’s Manual • Page 269...
Page 284 In addition to any prior limitations and exclusions, the following are NOT covered under this Limited Warranty: • normal maintenance of the Malibu Boat, Malibu Drive Train and/or Malibu Trailer or any component thereof; • normal wear-and-tear of the Malibu Boat, Malibu Drive Train and/or Malibu Trailer or any component thereof; • damages or needed adjustments caused by items that are added, altered or changed after the Malibu Boat, Malibu Drive Train and/or Malibu Trailer leaves the possession of Malibu Boats, including but not limited to installation of aftermarket towers, tower accessories, ballast systems, barefoot booms, canvas accessories, and hull bottom painting; • modification, alteration, unauthorized repair or replacement of components, including but not limited to damages resulting from such installations, on the Malibu Boat, Malibu Drive Train and/or Malibu Trailer; • damages caused by accident (including impacts and collisions with any object), abuse, misuse, neglect, negligence, mishandling or alteration, including any damages caused by or during trailering or towing; 2020 Malibu Boats LLC • Owner’s Manual • Page 270...
Page 285 • any material, component or part of the boat that has a warranty period and/or conditions as specified by the producing entity which differs from this Limited Warranty unless such warranties are administered directly by the producing entity; • damages caused by water intrusion into any part of the boat (including, but not limited to, the glove box and various storage compartments); • performance characteristics, such as speed, acceleration, fuel or oil consumption, etc., as they are estimated and can vary as dictated by individual conditions; • any and all consequential damages including, but not limited to, costs incurred for haul-out, launching, towing, storage charges, telephone, expedited shipping of replacement parts, or rental charges of any type (including slip fees), inconveniences, or loss of time or income; • components such as Surf Gate™, fins and wedges not installed at the time of manufacture. Post-manufacture installation of any of these items, as well as any other component not installed at the time of manufacture, will void the warranty and other components of the boat that have their own warranty(ies) due to potential damage to the boat and possible danger to occupants; • damage or injury resulting from failure to comply with recall notices, service bulletins and advisories, or requests from Malibu Boats to repair the boat or its components; • damage or injury resulting from speeding, demonstration or any type of racing; • damages resulting from the failure to properly maintain and care for the boat and its components in accordance with the instructions found within this Owner’s Manual; • shop supplies used in correction work, such as, but not limited to, sealants, lubricants, cleaning supplies; 2020 Malibu Boats LLC • Owner’s Manual • Page 271...
Page 286 • the use, even temporarily, of a non-Malibu Boat Trailer will void the Gel Coat & Powder Coat Limited Warranty. Section 4: International Exclusions/Requirements Importing or exporting any Malibu Boat, Malibu Drive Train and/or Malibu Trailer manufactured in the United States by Malibu Boats (“US Malibu Boat”, “US Malibu Drive Train” and/or “US Malibu Trailer”) into Australia or New Zealand (the act of importing or exporting any US Malibu Boat, US Malibu Drive Train and/or Malibu Trailer into Australia or New Zealand immediately and completely voids any and all coverage provided under this Limited Warranty and any and all obligations owed by Malibu Boats relative to the US Malibu Boat, US Malibu Drive Train and/or US Malibu Trailer). This Limited Warranty does not provide coverage to any Malibu Boat, Malibu Drive Train and/or Malibu Trailer purchased from a dealer in another country where the primary use of the Malibu Boat, Malibu Drive Train and/or Malibu Trailer will require the Malibu Boat, Malibu Drive Train and/or Malibu Trailer to cross an international border. The Limited Warranty will not be honored by Malibu Boats for any Malibu Boat, 2020 Malibu Boats LLC • Owner’s Manual • Page 272...
Page 287 The repair and/or replacement of components or parts under warranty does not extend the warranty period beyond the original expiration date. Section 6: Warranty Voiding Events The following events will automatically void and discharge Malibu Boats from its obligations under this Limited Warranty and discharge Malibu Boats from any obligations herein: • the unauthorized disconnection, tampering with, or altering of the Malibu Boat’s hour meter; • the unauthorized disabling of any warning device or system installed in any Malibu Boat and/or Malibu Drive Train; • the unauthorized disconnection, disturbance or compromise of any wires, hoses, tubes, cables, looms or other components of the Malibu Boat’s electrical or fuel systems; • the use of the Malibu Boat, Malibu Drive Train and/or Malibu Trailer in any criminal enterprise or to perform any criminal acts; and 2020 Malibu Boats LLC • Owner’s Manual • Page 273...
Page 288 Section 7.3. Design and/or Manufacturing Changes. Malibu Boats reserves the right to implement changes in the construction or components of any Malibu Boat, Malibu Drive Train and/or Malibu Trailer at any time, without incurring any obligation to make the same or similar changes on Malibu Boats, Malibu Drive Trains and/or Malibu Trailers previously built and/or sold. Section 7.4. Other Warranties. Some manufacturers of component parts included in a Malibu Boat, Malibu Drive Train and/or Malibu Trailer may provide limited warranties. Please refer to component part manufacturer’s limited warranty...
Page 289 Trailer to an Authorized Service Facility for repairs. Warranty service must be performed by Malibu Boats or an Authorized Service Dealer. For assistance in locating an Authorized Service Dealer, please visit www. malibuboats.com, select the “Find a Dealer” tab, and utilize Malibu Boats’ Dealer Locator, or call Malibu Boats at (865) 458-7110; and * Malibu Boats reserves the right to require further evaluation and/or information regarding a warranty claim against a Malibu Boat, Malibu Drive Train and/or Malibu Trailer prior to its repair as well as designate the place of repair.
Page 290 (b) If concerns are not resolved by the representatives of the Authorized Service Dealer, contact Malibu Boats’ Customer Service Department at the address noted above. Be prepared to provide the customer service representative with your name, address and phone number, your boat’s hull identification number, the Authorized Service Dealer(s) at which the boat has been serviced, and the nature of the concerns with the boat or the service. Malibu Boats will thereafter provide assistance to the boat owner and the Authorized Service Dealer, as necessary, to attempt to resolve the matter. 2020 Malibu Boats LLC • Owner’s Manual • Page 276...
Page 291 EXCEPT TO THE EXTENT PROHIBITED BY ANY APPLICABLE STATE OR FEDERAL LAW, PRIOR TO INITIATING ANY LEGAL ACTION AGAINST MALIBU BOATS, (1) YOU ARE REQUIRED TO PROVIDE MALIBU BOATS WRITTEN NOTICE, AT THE ADDRESS ABOVE, OF ANY SUBSTANTIAL DEFECT IN MATERIALS OR WORKMANSHIP THAT REMAINS UNRESOLVED TO YOUR SATISFACTION UNDER THE TERMS OF THE LIMITED WARRANTY;...
Page 292: Warranty Transfer
Warranty Transfer • The boat, engine and trailer (herein called the “boat package”) may be transferred from the original owner to a second private owner within the first five years of the original date of purchase to the second owner only. The boat package is not eligible to be transferred to a third owner for purpose of warranty coverage. • The boat package may transfer within the first five years of ownership from the date of purchase. After five years from the date of original purchase, a warranty transfer is no longer eligible. • The boat package must be fully inspected by an authorized Malibu dealer. The dealer will complete a warranty transfer specific to that boat package. The transfer must be signed by the second private owner. The transfer forms are available through the dealership only. • Consumer payment must be made to the dealer directly in the amount of $750.00. Payment cannot be made directly to Malibu Boats LLC. The dealer will complete the warranty transfer process on behalf of the seller and buyer. 2020 Malibu Boats LLC • Owner’s Manual • Page 278...
Page 293: California And U.s. Epa Emission Control Warranty Statement
Manufacturer’s Warranty Coverage Select electronic emission-related control parts from model year 2019 and u forward on Malibu Boats inboard engines are warranted for five (5) years or 500 hours as recorded on the boat’s hour meter, whichever comes first. If any emission-related part on your engine is defective under warranty as emission described in the Malibu Boats Limited Warranty Statement, the part will be repaired or replaced by Malibu Boats. control Owner’s Warranty Responsibilities As the inboard engine owner, you are responsible for the performance of the required maintenance listed in this Owner’s Manual. Malibu Boats warranty recommends retaining all receipts received as a result of the maintenance performed on your inboard engine. Malibu Boats cannot deny warranty...
Page 294 2020 Malibu Boats LLC • Owner’s Manual • Page 280...
Page 295: Troubleshooting The Boat
Gauges, Switches and Video Screens A gauge or video screen does not light up and work as expected. • Be certain the engine electrical system is ON. Generally, this requires turning the ignition key ON or pressing the ON button. • It is possible the display is in a “sleep” mode. Press a key or touch the screen to see if the affected display activates. 2020 Malibu Boats LLC • Owner’s Manual • Page 281...
Page 296 Dashes and Video Screens section of this Owner’s Manual before undertaking any attempt to replace, use both batteries simultaneously, or replace the battery. Alarms The low voltage alarm sounds. • Most often, this signals the need to turn OFF and leave OFF the stereo component or similar electronics that require substantial support from the batteries. Start the engine and allow the alternator to recharge the batteries, which will require a fairly short period of time if there is no additional drain occurring during the recharging time. If this does not work, it may be that the battery or batteries are nearing their terminal life span. 2020 Malibu Boats LLC • Owner’s Manual • Page 282...
Page 297 • Anytime the steering does not respond crisply to turns by the steering wheel, discontinue the outing and return to shore as soon as possible. The steering components are, generally, inaccessible to boat operators and owners. Repairs should be completed by an authorized Malibu dealer. • Inboard-engine boats have an inherent pull to one side due to rudder torque. While some can be adjusted, it is possible that all pull cannot be eliminated. 2020 Malibu Boats LLC • Owner’s Manual • Page 283...
Page 298: Troubleshooting The Trailer
The tongue actuator is making unusual noises, including, but not limited to, clunking or squawking. Consider: • The shock absorber inside the tongue may be worn and require replacement by an authorized Malibu Trailer dealer. • The brakes may require bleeding as there is air in the system that is allowing the actuator to malfunction. • The hitch ball may be too small, too worn or require some lubrication. 2020 Malibu Boats LLC • Owner’s Manual • Page 284...
Page 299 This situation can result in serious injury or death to persons on-board, and damage to the tow vehicle and/or trailer and boat, as well as to other people and vehicles on the road at the time. 2020 Malibu Boats LLC • Owner’s Manual • Page 285...
Page 300: Service Log
Service Performed Date Date Date Oil Change, Including Replace Oil Filter Wax Exterior Thoroughly Clean Interior Replace Battery Charge or Replace Fire Suppression Equipment Check/Repair PFDs and Other Safety Equipment Check/Repair Engine Mounts Check/Repair Exhaust Flaps Check/Repair Steering System Check/Repair Shift & Throttle System Inspect/Repair/Replace Ballast Pumps Inspect/Repair/Replace Bilge Pumps Replace Fuel Filter/Inspect Fuel Lines Check/Repair Wedge & Surf Gate Operation Check Hull Paint (where applied) Prepare for Storage/Winterization Recommission Boat Other Other Other 2020 Malibu Boats LLC • Owner’s Manual • Page 286...
Page 301 Date Date Date Date Date Date Date Date 2020 Malibu Boats LLC • Owner’s Manual • Page 287...
Page 302: Index
Android Apps ..............88 Appearance ................89 Approved Cleaners for Malibu Upholstery .... 231 Apps, Android ..............88 Armrests ................158 Assistance, Rendering ............24 Attaching to the Tow Vehicle ........188 Auto Detect ............... 109 Axles ..................194 2020 Malibu Boats LLC • Owner’s Manual • Page 288...
Page 303 Warranty Statement ..........279 Connecting/Disconnecting Batteries ...... 112 California Emissions Information ......126 Connection ................90 Call Alerts ................83 Connections to the Tow Vehicle ........ 185 Camera (TXI), Rear .............99 Control (TXi), Gauge View and Speed ......95 Camera, Rear and/or Dock ........... 155 Control Operation (TXi), Speed........96 2020 Malibu Boats LLC • Owner’s Manual • Page 289...
Page 304 Finishes, Hull and Deck ..........233 Electronic Throttle Control (ETC) ....... 153 Fins ..................175 Embracing Safety ..............4 Fire Extinguisher ..............14 Emergency Engine Stop Switch ......... 145 Fire Extinguishing Equipment ........144 Emergency Procedures ............45 Fire ...................45 2020 Malibu Boats LLC • Owner’s Manual • Page 290...
Page 305 Lug Nuts ................196 Hitch, Trailer ..............186 Luxury, Interior ..............155 Hitching Up ............... 190 Holders, Cup ..............161 Maintaining the Vessel, Safety While ......8 Home Mode .................77 Maintenance and Storage (Trailer), Cleaning ..211 Horn or Whistle ..............15 Maintenance Schedule (TXi screen) ......125 2020 Malibu Boats LLC • Owner’s Manual • Page 291...
Page 306 Proper Loading ..............21 On and Under the Water ..........168 Prudential Rule, General ..........33 On Product Warning Labels ...........27 Pull Type ................110 On-Going Care ..............226 Pump(s), Bilge ..............15 Open the Coupler ............189 Pumps ................. 252 2020 Malibu Boats LLC • Owner’s Manual • Page 292...
Page 307 Seating ................156 Rules, Basic Safety ..............4 Seating, Recommended ..........72 Running, Night ..............36 Sensors, Engine ..............116 Serial Number (TXi screen) .......... 123 Safe Speed ................17 Service Log ................ 286 Safety (Engine) ..............122 Settings Menu (TXi)............94 Safety and Required Equipment ........12 Settings Menu ..............88 2020 Malibu Boats LLC • Owner’s Manual • Page 293...
Page 308 Storage and Winterization, Extended ...... 260 Tower, G3.5 ................ 163 Storage Compartment (Trailer) ........206 Tower, GX ................164 Storage Compartments ..........159 Towing (Trailer), Prior to ..........207 Strut ..................175 Towing Advice ..............207 2020 Malibu Boats LLC • Owner’s Manual • Page 294...
Page 309 Vehicle, How to Connect to the Tow ......188 Vessel, Burdened ..............32 Vessel, Encountering Another ........31 Vessel, Privileged ..............31 Vessel, Safety While Maintaining the ......8 Video Player (TXi), PDF Viewer and ......99 Video Screens (TXi) ............95 Video Screens, Dashes and ..........76 Visibility of the Operator ..........22 Visual Distress Signals ............15 2020 Malibu Boats LLC • Owner’s Manual • Page 295...

This manual is also suitable for:

Wakesetter 20vtx Wakesetter 21mlx Wakesetter 21vlx Wakesetter 22lsv Wakesetter 23lsv Wakesetter 25lsv ... Show all

Malibu Boats Response TXi Owner's Manual

Safety

Owner Responsibility and Boating Education

Safety and Required Equipment

General Boating Safety Topics

On Product Warning Labels

Basic Rules of the Road

Watersports Safety

Emergency Procedures

Quick Reference Guide

Response Txi

Wakesetter 20VTX

Wakesetter 21MLX

Wakesetter 21VLX

Wakesetter 22LSV

Wakesetter 23LSV

Wakesetter 25LSV

Dashes & Video Screens

Dashes and Video Screens

3-In-1 Event Screen

Basic Electrical Components

Other Electrical Components

Malibu Monsoon Engines, Transmissions & V-Drives

General Information

California Emissions Information

Monsoon Engine Support Systems

Break-In Period-All Boats

Transmissions & V-Drives

How It Works

Safety First

Interior Performance

Interior Luxury

Tower, Canvas & Accessories

On and under the Water

Trailers

Connections to the Tow Vehicle

How to Connect to the Tow Vehicle

Connecting to the Boat

Trailer Components and How They Function

Additional Options

Towing Advice

Launching and Re-Loading the Boat from the Trailer

Cleaning, Maintenance and Storage

Get Ready

Malibu Fuel System

Operations

Care & Maintenance

On-Going Care

Upholstery

Salt Water Care and Maintenance

Routine Maintenance

Before Starting the Engine

After Starting the Engine

After the Outing

After 10 Hours on the Hourmeter

After 50 Hours or Annually (Whichever Comes First)

Storage and Winterization

Quick Links

Troubleshooting

Related Manuals for Malibu Boats Response TXi

Summary of Contents for Malibu Boats Response TXi