Servicing The Water Separator; Servicing The Fuel Filter; Cleaning The Fuel-Intake Screen - Toro Reelmaster 7000-D Operator's Manual

Servicing the Water
Separator
Service Interval: Before each use or daily—Drain
water or other contaminants from
the water separator.
Every 400 hours—Replace the fuel filter
canister.
1. Park the machine on a level surface, lower the
cutting units, engage the parking brake, shut off
the engine, and remove the key.
2. Place a clean container under the fuel filter.
3. Loosen the drain plug on the bottom of the filter
canister.
Figure 92
1. Filter canister
4. Clean the area where the filter canister mounts.
5. Remove the filter canister and clean the
mounting surface.
6. Lubricate the gasket on the filter canister with
clean oil.
7. Install the filter canister by hand until the gasket
contacts mounting surface, then rotate it an
additional 1/2 turn.
8. Tighten the drain plug on the bottom of the filter
canister.

Servicing the Fuel Filter

Service Interval: Every 400 hours
The engine fuel filter should be replaced after every
400 hours of operation.
1. Park the machine on a level surface, lower the
cutting units, engage the parking brake, shut off
the engine, and remove the key.
2. Clean the area around the fuel-filter head
(Figure 93).
1. Fuel-filter head
3. Remove the filter and clean the filter-head
mounting surface
4. Lubricate the filter gasket with clean lubricating
engine oil. Refer to the engine owner's manual,
included with the machine, for additional
information.
5. Install the dry filter canister, by hand, until the
gasket contacts the filter head, then rotate it an
g007367
additional 1/2 turn.
6. Start the engine and check for fuel leaks around
the filter head.
Cleaning the Fuel-Intake
Screen
Park the machine on a level surface, lower the cutting
units, engage the parking brake, shut off the engine,
and remove the key.
The fuel-intake tube, located inside the fuel tank, is
equipped with a screen to help prevent debris from
entering the fuel system. Remove the fuel-intake tube
and clean the screen as required.
58
Figure 93
2. Fuel filter
(Figure 93).
g021291