Table of Contents
Advertisement
Installation and operating instructions
Installation and operating instructions
JUDO SPEEDYMAT-LF
JUDO SPEEDYMAT-LF
Automatic backwash protective filter ¾" - 2"
Automatic backwash protective filter ¾" - 2"
Valid for: EU countries and Switzerland
Valid for: EU countries and Switzerland
Language: English
Language: English
Read before use and store!
Read before use and store!
Advertisement
Table of Contents
Related Manuals for Judo SPEEDYMAT-LF
Summary of Contents for Judo SPEEDYMAT-LF
- Page 1 Installation and operating instructions Installation and operating instructions JUDO SPEEDYMAT-LF JUDO SPEEDYMAT-LF Automatic backwash protective filter ¾" - 2" Automatic backwash protective filter ¾" - 2" Valid for: EU countries and Switzerland Valid for: EU countries and Switzerland Language: English...
- Page 2 D-71351 Winnenden uct. You have purchased a state-of-the- art device. It has been carefully checked Email: info@judo.eu • judo.eu prior to delivery. Nevertheless, if diffi- culties occur, please contact the closest customer service (see chapter Customer Office address: service).
-
Page 3: Table Of Contents
5.1 Potential-free message......16 Fault..........17 Servicing...........18 7.1 Cleaning..........18 7.2 Warranty and maintenance....18 Technical data........19 8.1 Installation dimensions...... 20 8.2 Spare parts........21 8.3 Accessories........26 Disposal..........26 10 EU Declaration of Conformity..27 11 Customer service......28 1701429 • 2018/12 JUDO JSY-LF-AT... -
Page 4: Safety
Before using the device with water that wet rooms. does not comply with this Directive, it is Only low voltages can be used for the essential to consult the manufacturer. remote transmission of the fault indica- tion via the potential-free output! JUDO JSY-LF-AT 1701429 • 2018/12... - Page 5 The device may only be repaired by For the installation of the device in qualified technical personnel. domestic water piping, only use the sup- Only use original spare parts for repairs. 1701429 • 2018/12 JUDO JSY-LF-AT...
-
Page 6: Symbols Used
Instructions attached directly to the device, e.g.: SPEEDYMAT-LF ¾" - 1¼": The filter bowl is visible through the viewing slot of the • Direction of flow (arrow) UV protection screen. The UV protection •... -
Page 7: Materials Used
They meet the requirements speci- eral Environmental Agency (UBA) W 270. fied in the following standards: Metallic materials fulfil the requirements of DIN 50930-6. • DIN EN 13443-1 • DIN 19628 ("Mechanical filters in drink- ing water installations") 1701429 • 2018/12 JUDO JSY-LF-AT... -
Page 8: Approval Marks
The built-in rotary flange serves as a con- necting element between the domestic water station and the device. It consists of: • rotary flange fitting • profile flange seal • two union nuts JUDO JSY-LF-AT 1701429 • 2018/12... -
Page 9: Installation Of The Device
2. Position the device with the fitted rotary flange fitting between the grommets and insert the flat gaskets on both sides. 3. Screw the device with the union nuts on both sides. 4. Place the flange cover back on. 1701429 • 2018/12 JUDO JSY-LF-AT... -
Page 10: Draining Of The Backwash Water
The dimen- sioning of this pipe must correspond to the backwashing water valve. JUDO JSY-LF-AT 1701429 • 2018/12... - Page 11 Installation 3.4.1 Drainage options for the backwash water 1701429 • 2018/12 JUDO JSY-LF-AT...
-
Page 12: Commissioning
By reversing the water flow from inside to to increased dirt deposits. In this case, a outside, deposits on the sieve fabric are carried away and rinsed out with the back- wash water. The suction pipes also clean JUDO JSY-LF-AT 1701429 • 2018/12... - Page 13 Fig. 6: Close cover and insert plug automatic system. To do this, attach the cable lug of the short cable strand to the pin with the inscription corresponding to the desired time interval (see Figure 5). 1701429 • 2018/12 JUDO JSY-LF-AT...
-
Page 14: Conversions, Changes
(see battery marking). matically started. The manufacturer recommends the use Dispose of used batteries according to of the following batteries: valid regulations! • Energizer Industrial • Energizer High Tech • Energizer Ultra + JUDO JSY-LF-AT 1701429 • 2018/12... -
Page 15: Maintenance, Repair, Spare Parts
• Protect the device from dirt so as not to impair drinking water hygiene. • Store the device in a frost-free place to prevent damage caused by freezing water and leakage. 1701429 • 2018/12 JUDO JSY-LF-AT... -
Page 16: Remote Transmission Of Messages
: When the power supply unit is plugged in, the relay changes its switching state into “operating”. If there is a fault indication, the relay switches to “zero-current or fault” state. JUDO JSY-LF-AT 1701429 • 2018/12... -
Page 17: Fault
Inadmissi- Check the safety relief valve of the warm sure increases slowly at ble pressure water boiler. zero flow. increase due to Inform the installer or the closest customer process water service point. heating. Troubleshooting 1701429 • 2018/12 JUDO JSY-LF-AT... -
Page 18: Servicing
4.2). The DIN EN 13443-1 pre- CAUTION scribes that the backwashing must take Do not use household cleaning place every six months. JUDO however agents to clean the outside of the recommends to comply with the information device, but only use clear water to in chapter 4.2.1 Backwashing interval. -
Page 19: Technical Data
Technical data Technical data Automatic backwash protective filter JUDO SPEEDYMAT-LF JSY-LF-AT The water to be filtered must comply with the European Drinking Water Directive. JSY-LF-AT JSY-LF-AT JSY-LF-AT JSY-LF-AT JSY-LF-AT Information about: ¾" 1" 1¼" 1½" 2" Pipe connection ¾" 1"... -
Page 20: Installation Dimensions
A Installation length B Unit depth C Height above the pipe middle D Height below the pipe middle E Installation depth up to the pipe middle G Waste water nominal diameter G1 Waste water nominal diameter (alternative) JUDO JSY-LF-AT 1701429 • 2018/12... -
Page 21: Spare Parts
Technical data Spare parts SPEEDYMAT-LF ¾" - 1¼" 1701429 • 2018/12 JUDO JSY-LF-AT... - Page 22 Technical data SPEEDYMAT-LF ¾" - 1¼" Order Item Designation Wear part set “Sieve insert 0.1 mm, suction pipe *** 2990412 and seal” (comprising items 5, 6, 7) Wear part set “Backwash valve und seals” **** 2170561 (comprising items 5, 9, 22) Spare part set “Automatic”...
- Page 23 Handwheel Spare parts list ¾" - 1¼" 1) AU = Accounting unit (articles without an accounting unit are only available as part of a set) Replacement interval: *** = 3 years **** = 4 years 1701429 • 2018/12 JUDO JSY-LF-AT...
- Page 24 Technical data SPEEDYMAT-LF 1½ - 2" JUDO JSY-LF-AT 1701429 • 2018/12...
- Page 25 Technical data SPEEDYMAT-LF 1½ - 2" Order Item Designation Wear part set “Sieve insert 0.1 mm, suction pipe” **** 2170565 183 (comprising items 11, 13, 14) Wear part set “Backwash valve und seals” *** 2170563 76 (comprising items 2, 6, 18) Spare part set “Automatic”...
-
Page 26: Accessories
Replacement interval: *** = 3 years **** = 4 years Accessories • JUDO expansion QUICKSET JQR (order no. 8250041) for series con- nection of two devices, e.g. automatic domestic water station and water treat- ment plant • Cable for external fault signal (order no. -
Page 27: Eu Declaration Of Conformity
EU Declaration of Conformity 72 / 03.18 Manufacturer: JUDO Wasseraufbereitung GmbH Address: Hohreuschstraße 39 - 41 D-71364 Winnenden JUDO SPEEDYMAT-LF ¾" - 2" Product designation: Automatic backwash protective filter • EU Directive Electromagnetic Compatibility (EMC) 2014/30/EU • Harmonised Electromagnetic compatibility, basic stan-... -
Page 28: Customer Service
Industriestrasse 15 • CH-4410 Liestal Phone +41 (0)61 906 40 50 • Fax +41 (0)61 906 40 59 E-mail: info@judo-online.ch • judo-online.ch JUDO Wasseraufbereitung GmbH • Filiaal - Filiale BeNeLux Laarbeeklaan - Av. du Laerbeek, 72 A1 • B-1090 Brussel-Bruxelles BENELUX Phone +32 (0)24 60 12 88 •...
Need help?
Do you have a question about the SPEEDYMAT-LF and is the answer not in the manual?
Questions and answers