Advertisement
Quick Links
MH- 45-KFA / MH-75T-KFA / MH-135T-KFA / MH-190T-KFA / MH-215T-KFA
DANGER
instructions and warnings provided with this heater. Failure to comply can result in fire or explosion
that can cause property loss, bodily injury, or loss of life. Only persons who can follow and
understand these instructions should operate or service this heater. If you need heater info; such as
an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996.
DANGER
an unvented portable heater that uses air (Oxygen) from within the area in which it is used. Failure
to provide adequate combustion and ventilation air will result in asphyxiation, carbon monoxide
poisoning, bodily injury or death. Refer to "Ventilation" on Page 7.
668 Stony Hill Road #302 Yardley, PA 19067 USA Toll Free (800)-641-6996
Fax: (215)-891-8461
Model Numbers
© 2014 Pinnacle Products International, Inc.
Be sure to comply with the
This is
701000122-14
Advertisement
Related Manuals for Pinnacle International MASTER MH-45-KFA
Summary of Contents for Pinnacle International MASTER MH-45-KFA
- Page 1 Model Numbers MH- 45-KFA / MH-75T-KFA / MH-135T-KFA / MH-190T-KFA / MH-215T-KFA DANGER Be sure to comply with the instructions and warnings provided with this heater. Failure to comply can result in fire or explosion that can cause property loss, bodily injury, or loss of life. Only persons who can follow and understand these instructions should operate or service this heater.
- Page 2 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Safety Information..........1-2 Maintenance............9-11 Wiring Diagram...........11 45-KFA and 75T-KFA Assembly......4 Troubleshooting Guide........12 Operation............7-6 Parts List............14 Ventilation.............7 Warranty..........Back Cover Keep combustibles such WARNING as; building materials, paper or cardboard a safe distance away from the heater as recommended by these instructions.
- Page 3 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE WARNING WARNING ALWAYS use only the electrical power (voltage and The products described in this manual are frequency) specified on the model plate of the heater. forced air heaters are primarily intended for use for ALWAYS use only three-prong, grounded outlet and temporary heating of buildings under construction, extension cord.
- Page 4 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Model # MH-45-KFA MH-75T-KFA MH-135T-KFA MH-190T-KFA MH-215T-KFA 45,000 75,000 190,000 215,000 1.00 1.42 10.0 Amps Phase Single Single Single Single Single Features Actual product features are subject to change due to ongoing improvements Optional Upper Shell Hot Air Outlet...
-
Page 5: Assembly Instructions
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: MH-45-KFA / MH-75T-KFA - Remove the heater and all packaging materials from the shipping carton Cord Wraps (Optional) Carry Handle (1) 10 mm Screws (2) Carry Handle Assembly 1. - Page 6 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: MH-135T-KFA / MH-190T-KFA / MH-215T-KFA Remove the heater and all packaging - Phillips Head Screw Driver materials from the shipping carton. - 8 mm open end wrench - 19 mm open end wrench Tip: Be sure to remove the axle from the side of the Styrofoam packaging.
- Page 7 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: MH-135T-KFA / MH-190T-KFA / MH-215T-KFA 1. Insert axle through holes in wheel support. 9. Remove the wheels to secure the second set of screws through the rear handle. 2.
- Page 8 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Kerosene (1-K) For optimal performance of this heater, it is strongly suggested that 1-K kerosene be used. eliminate contaminants, such as sulfur, which can cause a rotten egg odor during the operation of the heater.
- Page 9 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Models 75T-KFA / 135T-KFA / 190T-KFA / 215T-KFA: 1. Fill the tank with kerosene or other approved above fuel until needle on fuel gauge points to “F”. 2.
- Page 10 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance WARNING Models 45-KFA / 75T-KFA: 1. Use an approved siphon to drain fuel through the fuel cap opening. DO NOT TAMPER WITH THE UNIT. HAVE Models 135T-KFA / 190T-KFA / 215T-KFA: A COMPETENT SERVICEMAN MAKE ANY NECESSARY ADJUSTMENT OR REPAIRS.
- Page 11 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Clean and re-gap every 600 hours of operation, or Blades should be cleaned at least once per replace as needed. After removing the spark plug, heating season, depending on conditions. clean the terminals with a wire brush.
- Page 12 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance While heater is operating, turn adjusting screw Nozzles should be cleaned or replaced at least clockwise to increase, counter-clockwise to once per heating season. Contaminated fuel could decrease pressure.
- Page 13 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Your serial number can be found on a white label on the right side cover of your heater. It will begin ready before calling customer service at 800-641-6996. Problem Possible Cause Solution...
- Page 14 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE 48** 49** 55** 5 35 52** 51** * MH-45-KFA / MH-75T-KFA Only ** MH-135T-KFA / MH-190T-KFA / MH-215T-KFA Only 53** © 2015, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual...
- Page 15 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Drain Plug – – 70-002-0105 70-002-0105 70-002-0105 Fuel Cap - Large Plastic 70-006-0500 70-006-0500 70-006-0500 70-006-0500 70-006-0500 Window Display – – 70-040-0100 70-040-0100 70-040-0100 Lower Shell – –...
- Page 16 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Pinnacle Products International, Inc. warrants this heater If Pinnacle Products International, Inc. to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect.